NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
187 reportsClear category filter18,071 miles · Apr 20, 2004
Electrical SystemService Brakes, Hydraulic
PROBLEMS WITH THE BRAKING SYSTEM AT 18K MILES. *PH THE BRAKES BEGAN TO VIBRATE AND HUM, THE DASH BOARD LIGHTS CAME ON WHICH STATED THERE WAS AN ABS AND TRACTION PROBLEM. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND A THERE WAS A SENOR PROBLEM. THE REAR WHEEL SENOR WAS SHOWING A PROBLEM WHICH RESULTED FROM THE LEFT FRONT …
Read full complaint
PROBLEMS WITH THE BRAKING SYSTEM AT 18K MILES. *PH THE BRAKES BEGAN TO VIBRATE AND HUM, THE DASH BOARD LIGHTS CAME ON WHICH STATED THERE WAS AN ABS AND TRACTION PROBLEM. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND A THERE WAS A SENOR PROBLEM. THE REAR WHEEL SENOR WAS SHOWING A PROBLEM WHICH RESULTED FROM THE LEFT FRONT STRUT, WHERE CONNECTOR C101 AND CONNECTOR C045 WIRES PASSED INTO THE TRUNK UNDER THE CARPET. THE CONSUMER EXPERIENCED PROBLEMS WITH THE BRAKES ON SEVERAL OTHER OCCASIONS. THE CONSUMER ALSO EXPERIENCED ELECTRICAL PROBLEMS WITH THE VEHICLE. *JB
NHTSA ODI #10071574
Mileage unknown · Feb 11, 2004
Electrical System
DASHBOARD LIGHTING FAILED TO LIGHT UP WHEN CAR IS STARTED. SPECIALLY DANGEROUS AT NIGHT TIME, BECAUSE THIS IS ALSO ACCOMPANIED BY FAILURE OF THE TAIL LIGHTS TO TURN ON. HEAD LIGHTS ARE NOT AFFECTED. THERE IS NO OVERRIDE TO MANUALLY TURN ON THE TAIL LIGHTS NOR DASHBOARD LIGHTS. APPARENTLY THERE IS A SENSOR THAT TURNS THESE L…
Read full complaint
DASHBOARD LIGHTING FAILED TO LIGHT UP WHEN CAR IS STARTED. SPECIALLY DANGEROUS AT NIGHT TIME, BECAUSE THIS IS ALSO ACCOMPANIED BY FAILURE OF THE TAIL LIGHTS TO TURN ON. HEAD LIGHTS ARE NOT AFFECTED. THERE IS NO OVERRIDE TO MANUALLY TURN ON THE TAIL LIGHTS NOR DASHBOARD LIGHTS. APPARENTLY THERE IS A SENSOR THAT TURNS THESE LIGHTS ON WHEN CAR IS STARTED. THIS IS A RECURRING PROBLEM. AGAIN, SPECIALLY DANGERROUS SITUATION WHEN DRIVING AT NIGHT BECAUSE OF NO TAIL LIGHTS, AND NO WAY FOR DRIVER TO TELL WHAT IS THE DIRVING SPEED. ACCIDENT WAITING TO HAPPEN.*AK
NHTSA ODI #10056974
17,500 miles · Jan 22, 2004
Electrical SystemEquipmentLatches/locks/linkages
THE SECURITY SYSTEM CAME ON WHILE DRIVING AND SHUT THE AUTOMOBILE DOWN. CHEVROLET PUT IN A BODY CONTROL MODULE IN 08-12-03. ON 01-15-2004, WHILE ATTEMPTING TO START, VEHICLE SHUT DOWN. THIS TIME THE DRIVER WAS LOCKED INSIDE THE VEHICLE. THE DOOR LOCKS DID NOT RELEASE, AND THE KEY DID NOT COME OUT OF THE IGNITION.*AK
NHTSA ODI #10055683
65,000 miles · Dec 19, 2003
Electrical System
WHEN YOU PUT THE KEY IN THE IGINTION THE KEY WILL NOT TURN. TRIED SPARE KEY AND TURNING THE STEERING WHEEL BACK AND FORTH AND THE KEY STILL WILL NOT TURN.*AK IN THE PAST WE HAVE HAD THE "FIDDLE" WITH THE KEY IN THE IGINTION TO GET IT TO TURN. NOW IT DOES NOT TURN AT ALL EVEN WHEN YOU "FIDDLE" WITH THE KEY.
NHTSA ODI #10050763
33,150 miles · Nov 30, 2003
Electrical SystemEquipmentExterior Lighting
MUSTY SMELL COMING FROM AIR CONDITIONING. ALSO, THE STEERING WHEEL MAKES A WEIRD NOISE WHEN TURNING. THE TURN SIGNALS WILL GO BALLISTIC AT TIMES, FLICKERING FASTER AND FASTER. THE INSIDE LIGHTS ALSO FLICKER AT DIFFERENT INTENSITIES. *AK
NHTSA ODI #10048920
Mileage unknown · Nov 25, 2003
Electrical System
ELECTRICAL SYSTEM - DASHBOARD LIGHTS AND OTHER INSTRUMENT LIGHTS DO NOT TURN ON OR WILL TURN ON ONLY AFTER SEVERAL MINUTES OF DRIVING. VERY INCONSISTENT. POSE DANGER ESPECIALLY WHEN DRIVING AT NIGHT. THE PROBLEM APPEARED TO HAVE BEEN FIXED ABOUT A YEAR AGO, BUT THE PROBLEM STARTED TO SURFACE AGAIN RECENTLY (FALL 2003). *LA
NHTSA ODI #10047543
Mileage unknown · Nov 11, 2003
Electrical System
LIGHTS IN DASHBOARD CLUSTER DON'T ILLUMINATE.*AK
NHTSA ODI #10045992
66,000 miles · Nov 3, 2003
Electrical System
ONGOING PROBLEM WITH VEHICLE STALLING WITHOUT WARNING. VEHICLE COULD BE DRIVEN 5 MPH OR 55 MPH THE PROBLEM WOULD STILL OCCUR. VEHICLE HAD BEEN INSPECTED BY THE DEALER ON THREE OCCASIONS, AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10046191
80,123 miles · Oct 1, 2003
Electrical System
CAR COMPLETELY TURNED OFF WHILE THE SECRUITY WARNING SHOWED IN THE MESSAGE CENTER WHEN DRIVING AT 65MPH ON THE FREEWAY AND HAD TO FORCE THE CAR OFF THE ROAD WITH NO BRAKES AND NO POWER STEERING. *LA
NHTSA ODI #10041045
34,000 miles · Aug 7, 2003
Electrical SystemFire
WHEN THE VEHICLE WAS STARTED, THERE WAS AN EXPLOSION AND THE ENGINE CAUGHT ON FIRE. THE IGNITION COMPONENTS IN THE FIREWALL AREA OVERLOADED OR SHORTED OUT RAPIDLY WHICH CAUSED THE PLASTIC COVER AND PARTS AROUND IT TO INCINERATE. POSSIBLE FUEL LEAK, HOSES, OR SEALS DAMAGED BY EXPLOSION IGNITING FUEL. GENERAL MOTORS OFFERED TO R…
Read full complaint
WHEN THE VEHICLE WAS STARTED, THERE WAS AN EXPLOSION AND THE ENGINE CAUGHT ON FIRE. THE IGNITION COMPONENTS IN THE FIREWALL AREA OVERLOADED OR SHORTED OUT RAPIDLY WHICH CAUSED THE PLASTIC COVER AND PARTS AROUND IT TO INCINERATE. POSSIBLE FUEL LEAK, HOSES, OR SEALS DAMAGED BY EXPLOSION IGNITING FUEL. GENERAL MOTORS OFFERED TO REPLACE VEHICLE. INSTEAD SETTLED CLAIM. REPLACED NEW IMPALA. *JB *CB *JB
NHTSA ODI #10011666
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration