IllustrationFUEL LEAK BY DRIVERS SIDE REAR WHEEL SPRAYING ON EXHAUST SYSTEM DISCOVERED WHILE CAR WAS IDLING IN DRIVE WAY
2011 Chevrolet Hhr
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 2011 Chevrolet Hhr are lower than the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3825–50K
3550–75K
2175–100K
27100–150K
4150K+
144 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports3 fire reports12 injury reports
Fuel/propulsion System complaints
43 reportsGAS LEAK UNDER CAR DRIVERS SIDE NEAR THE FRONT OF THE REAR TIRE. REPLACED FUEL LINES. PUDDLES OF GASOLINE UNDERNEATH CAR AND STRONG SMELL OF FUMES.
MY FUEL LINE JUST IN FRONT OF THE DRIVERS SIDE REAR TIRE HAS STARTED LEAKING REALLY BAD. THERE IS A STRONG SMELL OF GASOLINE PLUS VISIBLE GASOLINE LEAKING ON THE GROUND. VERY DANGEROUS. AFTER A SEARCH, IT APPEARS THAT THIS PROBLEM IS BEING INVESTIGATED BY NHTSA AND GM. ADD MY 2011 HHR TO THE LIST OF FUEL LINES THAT HAS START…
Read full complaint
MY FUEL LINE JUST IN FRONT OF THE DRIVERS SIDE REAR TIRE HAS STARTED LEAKING REALLY BAD. THERE IS A STRONG SMELL OF GASOLINE PLUS VISIBLE GASOLINE LEAKING ON THE GROUND. VERY DANGEROUS. AFTER A SEARCH, IT APPEARS THAT THIS PROBLEM IS BEING INVESTIGATED BY NHTSA AND GM. ADD MY 2011 HHR TO THE LIST OF FUEL LINES THAT HAS STARTED LEAKING.
REAR FUEL LINE CORRODED AND LEAKED ! NOTICED SMELL AND LEAK WHEN PARKED !
MY VEHICLE HAS A GAS LEAK. SMELLS LIKE GAS WHILE DRIVING AND NOTICED GAS UNDER VEHICLE WHILE PARKED.
CORRODED FUEL LINES AT BACK OF VEHICLE CAUSING FUEL LEAK
ABS AND TRACTION STABILITY LIGHTS ON..REPLACED WHEEL HUB AND CLEANED SELINOIDS..ESC SERVICE COMES ACROSS DASH HOLE IN DRIVERS SIDE BACK FUEL LINE...REPLACED FUEL LINE DUE TO GAS LEAK...TROUBLE STARTING CAR DRIVING CAR WHEN ABS AND TRACTION LIGHTS CAME ON AT HOME AND WENT TO LEAVE WHEN NOTICED CAR HAVING TROUBLE STARTING
INTENSE GAS SMELL AND SLIGHT IGNITION DELAY. NO GAS SMELL UNTIL AFTER IT IS RUNNING.. I UNDERSTAND I SHOULD NOT EVEN DRIVE VEHICLE TO REPAIR SHOP BECAUSE OF A FIRE DANGER. MANY MORE COMPLAINTS EXACTLY LIKE MIND. THIS IS A HUGE SAFETY RISK BECAUSE OF FIRZE. I QUESTION WHY THERE WAS NEVER A RECALL. WE CERTAINLY DON'T HAVE …
Read full complaint
INTENSE GAS SMELL AND SLIGHT IGNITION DELAY. NO GAS SMELL UNTIL AFTER IT IS RUNNING.. I UNDERSTAND I SHOULD NOT EVEN DRIVE VEHICLE TO REPAIR SHOP BECAUSE OF A FIRE DANGER. MANY MORE COMPLAINTS EXACTLY LIKE MIND. THIS IS A HUGE SAFETY RISK BECAUSE OF FIRZE. I QUESTION WHY THERE WAS NEVER A RECALL. WE CERTAINLY DON'T HAVE A YEAR TO WAIT FOR AN INVESTIGATION.
MY 2011 CHEVY HHR LIKE MANY OTHERS I'VE LEARNED FROM CHECKING ONLINE IS LEAKING GAS NEAR THE REAR PASSENGER SIDE DOOR. THIS IS A DESIGN FLAW AND IS VERY DANGEROUS . WHY IS THERE NOT A RECALL ON THIS ARE YOU WAITING FOR ONE OF THESE CARS TO BURST IN FLAMES AND SOMEONE TO BE KILLED BEFORE GM IS MADE RESPONSIBLE TO FIX THE DEFECT .…
Read full complaint
MY 2011 CHEVY HHR LIKE MANY OTHERS I'VE LEARNED FROM CHECKING ONLINE IS LEAKING GAS NEAR THE REAR PASSENGER SIDE DOOR. THIS IS A DESIGN FLAW AND IS VERY DANGEROUS . WHY IS THERE NOT A RECALL ON THIS ARE YOU WAITING FOR ONE OF THESE CARS TO BURST IN FLAMES AND SOMEONE TO BE KILLED BEFORE GM IS MADE RESPONSIBLE TO FIX THE DEFECT . I DON'T HAVE HUNDREDS OF DOLLARS TO REPAIR THIS .AND EVEN WHEN GM IS HELD RESPONSIBLE THEY DO AS LITTLE AS POSSIBLE AND THEY DON'T REALLY ADDRESS THE PROBLEM. I ALSO HAVE A 2004 CHEVY IMPALA AND THERE IS A RECALL ON THAT FOR THE IGNITION , BY THE TIME THEY NOTIFIED ME MY IGNITION SWITCH HAD MALFUNCTIONED AND THEY WON'T FIX THAT . THERE FIX IS TO ALTER THE KEY SO THERE ISN'T SO MUCH PRESSURE ON THE SWITCH. THAT DOES ME NO GOOD SINCE THE CAR IS SITTING IN MY HARD AND IT IS DEAD BECAUSE THE SWITCH MALFUNCTIONED AND I CAN'T AFFORD TO GET IT FIXED.. WHEN THEY SELL A CAR THEY MAKE A LOT OF MONEY KN IT BUT THEY DON'T STAND BEHIND THEIR PRODUCT . AND NO ONE MAKES THEM DO SO. BUT AS SOON AS SOMEONE IS KILLED THEN THEY DO DAMAGE CONTROL AND YOU HEAR ALL THIS BULL, WE DIDN'T KNOW ,WE DIDN'T THINK IT WAS THAT BAD , AND WE ARE NOT RESPONSIBLE . I KNOW THIS RANT WILL DO NO GOOD BUT I COULDN'T SLEEP AT NIGHT IF I KNEW I WAS THE ONE RESPONSIBLE FOR THINGS LIKE THIS . THANKS
RUSTED FUEL LINES.
Official recalls
214V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.