NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
515 reports66,800 miles · Apr 14, 2014
Electrical SystemSteering
AS I WAS DRIVING DOWN THE OFF RAMP OF THE FREEWAY THE FRONT OF MY CAR STARTED TO SHAKE AND RATTLE. A COUPLE MINUTES LATER AFTER TURNING A CORNER, ONLY GOING 30MI/HR, THE CARS POWER STEERING THEN TURNED OFF. EVERY TIME I TURN MY CAR ON AND TAKE A TRIP THE POWER STEERING GOES OFF AT LEAST TWICE. WHICH IS ABOUT 5-6 TIMES A DAY. *…
Read full complaint
AS I WAS DRIVING DOWN THE OFF RAMP OF THE FREEWAY THE FRONT OF MY CAR STARTED TO SHAKE AND RATTLE. A COUPLE MINUTES LATER AFTER TURNING A CORNER, ONLY GOING 30MI/HR, THE CARS POWER STEERING THEN TURNED OFF. EVERY TIME I TURN MY CAR ON AND TAKE A TRIP THE POWER STEERING GOES OFF AT LEAST TWICE. WHICH IS ABOUT 5-6 TIMES A DAY. *JS
NHTSA ODI #10579571
80,811 miles · Apr 14, 2014
Electronic Stability Control (esc)Service BrakesSteering
PLEASE INCLUDE REPAIRING THIS ISSUE IN THE RECALL OF 2010 HHR VEHICLES. THIS IS THE MOST RECENT OF MULTIPLE INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. AS A CHIME SOUNDS, AND A MESSAGE IS FLASHED ON THE DISPLAY, THE VEHICLE BRIEFLY…
Read full complaint
PLEASE INCLUDE REPAIRING THIS ISSUE IN THE RECALL OF 2010 HHR VEHICLES. THIS IS THE MOST RECENT OF MULTIPLE INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. AS A CHIME SOUNDS, AND A MESSAGE IS FLASHED ON THE DISPLAY, THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. ON THIS OCCASION, THE SERVICER FOUND THE FEMALE CONNECTORS TO THE ABS SPEED SENSOR WERE NOT MAKING PROPER CONTACT. HE CRIMPED THE NEW ONES TIGHTLY WHEN INSTALLING THE REPLACEMENT ENDS. THE SERVICE ADVISOR ADMITTED THAT MY CAR IS NOT THE ONLY ONE WITH THIS ISSUE, HE HAD SEEN THIS PROBLEM REPEATEDLY. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. *JS
NHTSA ODI #10579499
75,907 miles · Apr 14, 2014
Electronic Stability Control (esc)Service BrakesSteering
FOR THE SECOND TIME IN A WEEK, THE VEHICLE IS BEING SERVICED BECAUSE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATED SEVERAL TIMES SINCE THE LAST SERVICE WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED.…
Read full complaint
FOR THE SECOND TIME IN A WEEK, THE VEHICLE IS BEING SERVICED BECAUSE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATED SEVERAL TIMES SINCE THE LAST SERVICE WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. ON THIS OCCASION, THE DEALER COULD NOT DUPLICATE THE PROBLEM. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. THIS NEEDS TO BE ELEVATED TO A RECALL. *JS
NHTSA ODI #10579498
75,692 miles · Apr 14, 2014
Electronic Stability Control (esc)Service BrakesSteering
THIS IS ON OF REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. A CHIME SOUNDS, A MESSAGE APPEARS ON THE DISPLAY, THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CA…
Read full complaint
THIS IS ON OF REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. A CHIME SOUNDS, A MESSAGE APPEARS ON THE DISPLAY, THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. ON THIS OCCASION, THE RIGHT FRONT HUB WAS REPLACED. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. THIS NEEDS TO BE ESCALATED TO A RECALL. *JS
NHTSA ODI #10579496
Mileage unknown · Apr 10, 2014
Electrical SystemSteering
YOU TELL ME THAT THERE ARE RECALLS ON MY 2010 CHEVY HHR AND WHEN I CALL THE CHEVY DEALER THAT I BOUGHT IT FROM ( DEERY BROTHER CHEVROLET) IN PLEASANTHILL IA. AND CHEVROLET MOTORS THEY TELL ME THERE ARE NO RECALLS ON MY VEHICLE. *TR
NHTSA ODI #10579006
16,234 miles · Apr 10, 2014
Electronic Stability Control (esc)Steering
LOST POWER STEERING VERY HARD TO TURN STEERING WHEEL. *TR
NHTSA ODI #10578857
Mileage unknown · Apr 7, 2014
Steering
I PLACED A COMPLAINT HERE IN FEBRUARY REGARDING THE POWER STEERING MOTOR GOING OUT. I HAD THIS HAPPEN TO MY 2010 CHEVY HHR AND THE RECALL IS ONLY FOR THE VEHICLES MADE IN THE US NOT IN MEXICO LIKE MINE WAS. PLEASE HAVE GM LOOK INTO THIS. UNDER THE NHTSA CAMPAIGN NUMBER: 14V153000, IN THE LETTER SECTION 573.6 (C)(5) STATES EXACTL…
Read full complaint
I PLACED A COMPLAINT HERE IN FEBRUARY REGARDING THE POWER STEERING MOTOR GOING OUT. I HAD THIS HAPPEN TO MY 2010 CHEVY HHR AND THE RECALL IS ONLY FOR THE VEHICLES MADE IN THE US NOT IN MEXICO LIKE MINE WAS. PLEASE HAVE GM LOOK INTO THIS. UNDER THE NHTSA CAMPAIGN NUMBER: 14V153000, IN THE LETTER SECTION 573.6 (C)(5) STATES EXACTLY WHAT HAPPENED TO MY VEHICLE. SOUNDS LIKE GM IS NOT OWNING UP TO ALL THE VEHICLES THEY INSTALLED CHEAP DEFECTIVE PARTS INTO. THANK YOU. *TR
NHTSA ODI #10577987
Mileage unknown · Apr 3, 2014
Unknown Or Other
HELLO, I WOULD LIKE TO REPORT THE INTOLERABLE ODOR COMING OUT OF THE AC VENT IN MY CAR, WHICH IS AFFECTING MY HEALTH (EG: THROAT INFECTION) AND WELL BEING. THE CAR HAS ~32000 MILES IN IT AND OUT OF WARRANTY BY ~10 MONTHS. I FOUND A TSB (#99-01-39-004C) ON THIS ISSUE. THE TSB ADVISORY STATES GM TO INSTALL AN AFTER BLOWER KIT IF …
Read full complaint
HELLO, I WOULD LIKE TO REPORT THE INTOLERABLE ODOR COMING OUT OF THE AC VENT IN MY CAR, WHICH IS AFFECTING MY HEALTH (EG: THROAT INFECTION) AND WELL BEING. THE CAR HAS ~32000 MILES IN IT AND OUT OF WARRANTY BY ~10 MONTHS. I FOUND A TSB (#99-01-39-004C) ON THIS ISSUE. THE TSB ADVISORY STATES GM TO INSTALL AN AFTER BLOWER KIT IF THE CUSTOMERS COMPLAIN. THESE AFTER BLOWER KITS ARE INSTALLED IN SOME OF THE CARS AND NOT OTHERS DEPENDING ON THE LOCATION OF SALES. I BOUGHT THIS AS A NEW CAR AT CINCINNATI DURING 2010 AND MOVED TO CHARLOTTE DURING 2011 TIME FRAME. DURING MAR 2013, I STARTED NOTICING THE BAD ODOR, BUT I CONVINCED MYSELF THAT THIS WILL GO AWAY DURING SUMMER AND DIDN'T TAKE IT TO A DEALER AT THAT TIME. LATER, HOWEVER IT GOT WORSE AND I TOOK IT TO THE DEALER DURING DEC/2013. THE DEALER RECOMMENDED DEHUMIDIFYING THE EVAPORATOR CORE AND I WENT AHEAD DID IT. IT COST ME ~$110. IT SEEMED TO WORK FINE FOR A WEEK OR SO, BUT THE BAD ODOR RETURNED. I WAS GETTING SICK WITH THROAT INFECTION(S). ON FURTHER INVESTIGATION, I CAME TO KNOW ABOUT THIS TSB THAT I MENTIONED ABOVE. BUT THE DEALER DIDN'T DISCLOSE ABOUT THIS TSB TO ME IN FIRST PLACE, WHEN I TOOK THE CAR THERE DURING DEC/2013. I COMPLAINED ABOUT THIS TO GM AND MENTIONED THAT IT IS THEIR RESPONSIBILITY TO INSTALL THE MISSING AFTER BLOWER KIT. GM REPLIED TO ME SAYING THAT THEY CAN OFFER A COST ASSISTANCE PROGRAM TO INSTALL THIS MISSING KIT AND COVER 1/2 THE COSTS BECAUSE MY CAR IS OUT OF WARRANTY. TO ME, THIS IS A CLEAR DESIGN AND MANUFACTURING ISSUE. GM DIDN'T ADVISE ME (DURING PURCHASE OF THIS CAR) IF I MOVE OUT OF CINCINNATI AREA, I MAY NEED THIS AFTER BLOWER KIT TO AVOID MOLD AND MILDEW BUILD UP IN THE AC SYSTEM. PLEASE ADVISE AS I DON'T WANT TO PAY FOR EXPENSIVE FIX THAT IS NOT MY FAULT TO BEGIN WITH. *TR
NHTSA ODI #10577044
Mileage unknown · Apr 2, 2014
Structure
I ATTEMPTED TO OPEN MY 2010 CHEVY HHR'S REAR PASSENGER DOOR. THE DOOR WOULD NOT OPEN. ALL OTHER DOORS ARE OPENING OK. THE REAR DRIVER'S SIDE PASSENGER DOOR WOULD NOT OPEN UNDER ANY CIRCUMSTANCES. THIS AN EXTREMELY DANGEROUS SITUATION. NOT BEING TO EXIT A VEHICLE UNDER EMERGENCY CIRCUMSTANCES CAN CAUSE SERIOUS INJURY OR DEATH. IT…
Read full complaint
I ATTEMPTED TO OPEN MY 2010 CHEVY HHR'S REAR PASSENGER DOOR. THE DOOR WOULD NOT OPEN. ALL OTHER DOORS ARE OPENING OK. THE REAR DRIVER'S SIDE PASSENGER DOOR WOULD NOT OPEN UNDER ANY CIRCUMSTANCES. THIS AN EXTREMELY DANGEROUS SITUATION. NOT BEING TO EXIT A VEHICLE UNDER EMERGENCY CIRCUMSTANCES CAN CAUSE SERIOUS INJURY OR DEATH. IT IS MY UNDERSTANDING THAT ALTHOUGH GM IS AWARE OF THIS PROBLEM THEY HAVE DONE NOTHING ABOUT IT. THE GM DEALER I BROUGHT THE VEHICLE TO TOLD ME IT WAS MY PROBLEM, NOT GM'S. I HAVE FACED MULTIPLE ISSUES WITH THIS VEHICLE; KEY STUCK IN IGNITION, POWER STEERING FAIL WHILE DRIVING, MULTIPLE SETS OF BRAKES BURNT OUT, INSIDE DRIVER'S DOOR HANDLE BREAKING OFF AND NOW THIS NEW ISSUE WITH THE DOOR. THE NHTSA REALLY NEEDS TO URGENTLY ADDRESS THE MULTIPLE PROBLEMS WITH THIS VEHICLE AND HOLD GM RESPONSIBLE FOR THEIR POOR ENGINEERING AND QUALITY CONTROL, BEFORE SOMEONE ELSE LOSES THEIR LIFE. *TR
NHTSA ODI #10576691
41,700 miles · Apr 2, 2014
Electrical System
I COULD NOT TURN OFF THE IGNITION AFTER STARTING THE CAR. DEALER WHO REPLACED THE SWITCH TOLD ME THE "IGNITION HAD EXPLODED, THAT HAPPENS ALL THE TIME WITH THIS CAR." HE WOULD NOT SHOW ME THE UNIT HE HAD REMOVED, AND SAID "THEY HAVE TO SEND IT THE GM." IT WAS NOT A GM WARRANTY REPLACEMENT. I HAD TO PAY THE DEDUCTIBLE FOR TH…
Read full complaint
I COULD NOT TURN OFF THE IGNITION AFTER STARTING THE CAR. DEALER WHO REPLACED THE SWITCH TOLD ME THE "IGNITION HAD EXPLODED, THAT HAPPENS ALL THE TIME WITH THIS CAR." HE WOULD NOT SHOW ME THE UNIT HE HAD REMOVED, AND SAID "THEY HAVE TO SEND IT THE GM." IT WAS NOT A GM WARRANTY REPLACEMENT. I HAD TO PAY THE DEDUCTIBLE FOR THE AFTERMARKET SERVICE CONTRACT. *TR
NHTSA ODI #10576588
Official recalls
3Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration