IllustrationTHE FUEL LINE RUSTED OUT IN FRONT OF DRIVERS SIDE REAR TIRE, SPRAYING A FINE STREAM OF GAS WHEN UNDER PRESSURE. I UNDERSTAND THIS IS A COMMON PROBLEM WITH HHR'S, LUCKILY, I CAUGHT IT EARLY COMPARED TO OTHERS. VEHICLE HAD JUST OVER 100,000 MILES AT THE TIME, AND HAS BEEN VERY WELL TAKEN CARE OF.
2010 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
9425–50K
13950–75K
7575–100K
50100–150K
21150K+
413 reports with mileage · 102 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports1 fire reports9 injury reports
Fuel/propulsion System complaints
46 reportsFUEL LINES ON THESE VEHICLES ARE EXPOSED WHICH HAS CAUSED RUSTING AND THE LINES BREAK. VEHICLE IS LEAKING GAS AND ONLY THE DEALER CARRIES THE PART
CAR ONLY HAS 54,168 MILES. CHECK ENGINE LIGHT APPEARED 4 MONTHS AGO. I HAVE TAKEN IT TO A NUMBER OF MECHANICS AS WELL A DEALER BUT NO ONE CAN SEEM TO FIGURE OUT WHAT THE CAUSE OF IT IS. GROSSINGER CHEVY KEPT IT FOR 1 DAY CLAIMS TO NOT FIND ANYTHING BUT LIGHT STILL ON. TREMENDOUSLY CONCERNING.
SHORTLY BEFORE CHRISTMAS (2015) WE BAGAN TO SMELL FUEL FROM THE REAR DRIVER'S SIDE OF OUR 2010 HHR. THERE DID NOT APPEAR TO BE ANY LEAKING GAS; HOWEVER, WE TOOK THE CAR TO THE DEALER FOR PROPER DIAGNOSIS. THE DEALER DETERMINED THE FUEL LINES HAD RUSTED THROUGH. WHEN WE TOOK THE CAR HOME TO DECIDE OUR NEXT ACTION, WE DISCOVERED I…
Read full complaint
SHORTLY BEFORE CHRISTMAS (2015) WE BAGAN TO SMELL FUEL FROM THE REAR DRIVER'S SIDE OF OUR 2010 HHR. THERE DID NOT APPEAR TO BE ANY LEAKING GAS; HOWEVER, WE TOOK THE CAR TO THE DEALER FOR PROPER DIAGNOSIS. THE DEALER DETERMINED THE FUEL LINES HAD RUSTED THROUGH. WHEN WE TOOK THE CAR HOME TO DECIDE OUR NEXT ACTION, WE DISCOVERED IT WAS NOW LEAKING A SIGNIFICANT AMOUNT OF FUEL, AND PROMPTLY BROUGHT THE VEHICLE BACK FOR FULL REPAIR. THE CAR WAS 5 YEARS OLD. EVERYONE I HAVE SPOKEN WITH SINCE HAS NEVER HEARD OF RUSTED FUEL LINES ON A 5 YEAR OLD VEHICLE. I WROTE GM'S EXECUTIVE OFFICE, AND THEY SIMPLY STATED THAT IT WAS DUE TO ENVIRONMENTAL CONDITIONS. I LIVE IN FLORIDA, BUT DO NOT LIVE DIRECTLY ON OR NEAR THE OCEAN. I ALSO DO NOT PARK THE CAR AT OR NEAR THE OCEAN ON ANY KIND OF REGULAR BASIS. THIS CAR ALSO NEVER DRIVES IN SNOW. IF ENVIRONMENTAL CONDITIONS CAUSED THE FUEL LINES TO GO BAD, EVERY CAR IN FLORIDA WOULD HAVE THEIR FUEL LINES REPLACED EVERY FIVE YEARS, AND THIS IS SIMPLY NOT THE CASE. THE DISTINCTION IS THAT FUEL LINES DO NOT RUST THROUGH ON VEHICLES OF THIS AGE. THERE ARE NUMEROUS MODEL YEARS OF THE HHR REPORTING THE EXACT SAME ISSUE IN NUMEROUS STATES ALL OVER THE USA; THUS, THIS IS NOT A LOCALIZED ENVIRONMENTAL ISSUE. FAULTY DESIGN AND/OR MATERIALS IS CAUSING THESE FUEL LINES TO PREMATURELY RUST OUT AT THE JOINTS. ALMOST ALL OF THE REPORTS OF THIS ISSUE OCCUR BEFORE FIVE YEARS OF AGE FOR THE VEHICLE. IF CORVETTE'S WERE HAVING THEIR FUEL LINES RUST OUT WITHIN 5 YEARS, THERE WOULD BE A RECALL; HOWEVER, AS THE HHR IS DISCONTINUED, NOTHING HAS BEEN INVESTED INTO RESEARCHING THIS INHERENT VICE. BY THE TIME WE ACTUALLY HAD THE REPAIR DONE ON OUR HHR, IT WAS ACTUALLY LEAKING A SIGNIFICANT AMOUNT OF GAS, AND IT EASILY COULD HAVE IGNITED AND KILLED OUR FAMILY. APPARENTLY SOMEONE HAS TO DIE, FOR A RECALL TO BE ISSUED.
THIS CAR HAS A KNOWN ISSUE BY GM ENOUGH TO HAVE THEM PLACE A BULLETIN OUT ON HOW TO FIX IT....THE FUEL LINE RUSTS THEN LEAKS....THIS CAR IS 4 YEARS OLD AND I HAD TO REPLACE A POTENTIAL FIRE HAZARD AT MY COST...GM SHOULD FIX THIS ISSUE NOT I....I CALLED MY MECHANIC AND TOLD HIM I HAD A LEAK IN THE FUEL LINE.....I QUOTE HIM EXACTL…
Read full complaint
THIS CAR HAS A KNOWN ISSUE BY GM ENOUGH TO HAVE THEM PLACE A BULLETIN OUT ON HOW TO FIX IT....THE FUEL LINE RUSTS THEN LEAKS....THIS CAR IS 4 YEARS OLD AND I HAD TO REPLACE A POTENTIAL FIRE HAZARD AT MY COST...GM SHOULD FIX THIS ISSUE NOT I....I CALLED MY MECHANIC AND TOLD HIM I HAD A LEAK IN THE FUEL LINE.....I QUOTE HIM EXACTLY...LET ME GUESS DRIVERSIDE IN FRONT OF THE REAR TIRE....ITS A KNOWN ISSUE...I SAT ON THE PHONE WITH MY MOUTH OPEN....I COULD NOT BELIEVE THIS....THIS IS ABHORRENT AND CHEVROLET GM....NEEDS TO BE ACCOUNTABLE FOR THESE ROLLING BALLS OF FIRE. *TR
TL* THE CONTACT OWNS A 2010 CHEVROLET HHR. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT SHE NOTICED FUEL HAD LEAKED ON THE FLOOR AND THE VEHICLE HESITATED WHEN STARTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER …
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET HHR. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT SHE NOTICED FUEL HAD LEAKED ON THE FLOOR AND THE VEHICLE HESITATED WHEN STARTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 55,000.
Official recalls
314V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.