NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
424 reportsClear category filter60,000 miles · Mar 5, 2010
Steering
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH. THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATED ON THE DASHBOARD. THERE WAS A LOSS OF POWER STEERING. THE CONTACT WAS ABLE TO CONTINUE DRIVING WITH DIFFICULTY IN STEERING THE VEHICLE. THE FAILURE WOULD OCCUR AT ANY GIVEN SPEED. THE VEH…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH. THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATED ON THE DASHBOARD. THERE WAS A LOSS OF POWER STEERING. THE CONTACT WAS ABLE TO CONTINUE DRIVING WITH DIFFICULTY IN STEERING THE VEHICLE. THE FAILURE WOULD OCCUR AT ANY GIVEN SPEED. THE VEHICLE HAS NOT BEEN DIAGNOSED FOR THE MALFUNCTION. THE CURRENT AND FAILURE MILEAGES WERE 60,000.
NHTSA ODI #10317225
50,000 miles · Mar 3, 2010
SteeringCrash
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE DRIFTED TO THE LEFT WHILE DRIVING APPROXIMATELY 35 MPH. THE DEALER DIAGNOSED THE FAILURE AND STATED THAT THERE WAS NOTHING WRONG WITH THE STEERING ON THE VEHICLE. THE CONTACT STATED THAT THE STEERING WHEEL MALFUNCTIONED REGARDLESS OF WHETHER YOU'RE …
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE DRIFTED TO THE LEFT WHILE DRIVING APPROXIMATELY 35 MPH. THE DEALER DIAGNOSED THE FAILURE AND STATED THAT THERE WAS NOTHING WRONG WITH THE STEERING ON THE VEHICLE. THE CONTACT STATED THAT THE STEERING WHEEL MALFUNCTIONED REGARDLESS OF WHETHER YOU'RE DRIVING ON A HIGHWAY OR MAKING A TURN. THE FAILURE MILEAGE WAS 50000. THE CURRENT MILEAGE WAS 63000. UPDATED 04/16/10. *LJ AS THE CONSUMER PULLED INTO THE DRIVEWAY, THE STEERING WHEEL TURNED SHARPLY TO THE RIGHT AND STRUCK AN ANTENNA TOWER DAMAGING THE DRIVERS SIDE DOOR AND FENDER. UPDATED 08/20/10*JB
NHTSA ODI #10316073
51,000 miles · Mar 2, 2010
Steering
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING THE POWER STEERING WARNING LIGHT INTERMITTENTLY ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, THEN THE STEERING COLUMN WOULD LOCK. AFTER RESTARTING THE VEHICLE THE STEERING COLUMN WOULD RESET. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE MOTOR FOR $339. THE CHEVROL…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING THE POWER STEERING WARNING LIGHT INTERMITTENTLY ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, THEN THE STEERING COLUMN WOULD LOCK. AFTER RESTARTING THE VEHICLE THE STEERING COLUMN WOULD RESET. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE MOTOR FOR $339. THE CHEVROLET MANUFACTURER WAS NEVER CALLED. THE FAILURE MILEAGE WAS 51,000. UPDATED 5/17/2010 * CN THE DEALER REPALCED THE STERING MOTOR. UPDATED 05/20/10
NHTSA ODI #10315655
Mileage unknown · Feb 20, 2010
Steering
HHR WAS BROUGHT IN ON FRIDAY 02/12 FOR RUBBING NOISE IN STEERING COLUMN. CAR WAS KEPT FOR 1 DAY TO REPAIR. I WAS TOLD "RATTLING" NOISE REPAIRED. I STATED IT WAS A RUBBING NOISE. TOLD TO BRING THE CAR IN WHEN IT WAS MAKING THE NOISE. CAR RETURNED TO POWER ON 02/18/10 WITH SAME RUBBING NOISE (SEE REPAIR ORDER 473237- NO SURVE…
Read full complaint
HHR WAS BROUGHT IN ON FRIDAY 02/12 FOR RUBBING NOISE IN STEERING COLUMN. CAR WAS KEPT FOR 1 DAY TO REPAIR. I WAS TOLD "RATTLING" NOISE REPAIRED. I STATED IT WAS A RUBBING NOISE. TOLD TO BRING THE CAR IN WHEN IT WAS MAKING THE NOISE. CAR RETURNED TO POWER ON 02/18/10 WITH SAME RUBBING NOISE (SEE REPAIR ORDER 473237- NO SURVEY CARD GIVEN TO ME). SPENT 15 MINUTES WITH THE MECHANIC IN PARKING LOT WHILE CAR WAS MAKING THE RUBBING SOUND. IT WAS CLEARLY HEARD BY THE MECHANIC. CAR KEPT FOR ANOTHER DAY FOR REPAIR. WHEN I CALLED ON 02/19/10, I WAS TOLD BY MIKE THAT MARC WAS NOT IN AND THAT THE MECHANIC WORKED ON THE CAR ALL DAY, BUT COULD NOT DUPLICATE THE SOUND. I WAS TOLD HE EVEN DROVE THE CAR 25 MILES TO DUPLICATE AND YET MILEAGE IN/OUT ARE THE SAME ON INVOICE. PER THE MECHANIC, YOU CANNOT KEEP BRINGING THE CAR IN FOR THE SAME PROBLEM, THAT THEY (WHOEVER "THEY" ARE) WOULD START QUESTIONING THE WARRANTY. I FEEL THEY SHOULD QUESTION THE ABILITY OF THE MECHANIC TO DO THE JOB. *TR
NHTSA ODI #10312370
34,631 miles · Nov 4, 2009
Steering
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHEN DRIVING THE FRONT-END OF THE VEHICLE WILL SHIMMY . THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER REPLACED THE BUSHING LINK, BUT THE FAILURE WAS NOT CORRECTED. HE TOOK THE VEHICLE BACK TO THE DEALER FOR INSPECTION. THE DEALER REPLACED THE POWER STEERI…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHEN DRIVING THE FRONT-END OF THE VEHICLE WILL SHIMMY . THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER REPLACED THE BUSHING LINK, BUT THE FAILURE WAS NOT CORRECTED. HE TOOK THE VEHICLE BACK TO THE DEALER FOR INSPECTION. THE DEALER REPLACED THE POWER STEERING ASSEMBLY. THE DEALER DID NOT GUARANTEE THAT THE FAILURE WILL NOT REOCCUR, AND IT DID . THE FAILURE MILEAGE WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 34,631.
NHTSA ODI #10290960
49,500 miles · Oct 13, 2009
Steering
POWER STEERING FAILURE. *TR
NHTSA ODI #10287238
35,440 miles · Jul 26, 2009
Power TrainService Brakes, HydraulicSteering
DRIVER WAS LEAVING PARKING LOT WHEN PASSENGER SIDE (RIGHT FRONT) CV SHAFT BROKE COMPLETELY IN HALF AT 35,440 MILES WITHOUT WARNING. CV SHAFT COULD BE HEARD SLAPPING AROUND UNDER CAR WHILE MOTOR RUNNING IN GEAR, PROBABLY TEARING UP OTHER COMPONENTS UNDER THE HOOD AND SUSPENSION. THE CV SHAFT BREAKAGE LEFT THE VEHICLE UNDER NO P…
Read full complaint
DRIVER WAS LEAVING PARKING LOT WHEN PASSENGER SIDE (RIGHT FRONT) CV SHAFT BROKE COMPLETELY IN HALF AT 35,440 MILES WITHOUT WARNING. CV SHAFT COULD BE HEARD SLAPPING AROUND UNDER CAR WHILE MOTOR RUNNING IN GEAR, PROBABLY TEARING UP OTHER COMPONENTS UNDER THE HOOD AND SUSPENSION. THE CV SHAFT BREAKAGE LEFT THE VEHICLE UNDER NO POWER BECAUSE PASSENGER WHEEL IS THE DRIVE WHEEL....VEHICLE STARTED TO ROLL BACKWARDS INTO TRAFFIC. ALSO, THE VEHICLE'S STEERING WHEEL ALSO HAD NO ABILITY TO BE TURNED TO THE LEFT DUE TO THE BROKEN CV SHAFT BLOCKING IT BY SHAFT HITTING THE WHEEL/HEAT SHIELD/ROTOR ASSY. OWNER HAD TO PUSH CAR BACKWARDS OUT OF TRAFFIC AND INTO PARKING LOT. VEHICLE WOULD STILL ROLLED WHILE IN PARK, HAD TO USE PARKING BRAKE TO MAKE VEHICLE STATIONARY. I WAITED 2.5HRS FOR GM ROAD SIDE ASSISTANCE TO GET TOW TRUCK TO MY VEHICLE. 1ST TOW TRUCK DIDN'T COME DUE TO GM NOT CHECKING TO SEE HOW FAR THEY WERE FROM VEHICLE LOCATION. VEHICLE WAS TOWED TO JBA CHEVROLET (GLEN BURNIE, MD) ON JUNE 25TH, 09 (NEXT DAY). I WENT TO DEALERSHIP TO CHECK ON CAR AND GET LOANER. JBA OFFERED NO LOANER STATING THAT SERVICE DEPT NOT OPEN AND THEY MUST DIAGNOSE FIRST AND WAIT UNTIL MONDAY AND THEN MAYBE I GET A LOANER. ALSO GM CUST ASST 1-800 NUMBER STATED I COULD RENT AND GET REIMBURSE BUT I DON'T TRUST GM AND MONEY AT ALL AFTER SEEING HOW OTHERS TREATED ABOUT AND HOW POORLY THEY MANAGE THEIR OWN MONEY. THIS CV SHAFT INCIDENT HAPPENED 1 WEEK AFTER GETTING CAR BACK FROM DEALERSHIP FOR BRAKE OVERHEATING/WARPING AND HEAT SHIELD GRINDING PROBLEM. THE MECHANIC THEN STATED HE KNEW BRAKES WERE CHEAPLY MADE AND PROBLEM BUT NO RECALL AND IF OVER 36,000 MILES...THEY WON'T BE FREE ANYMORE.... CV SHAFT LOOKED TO BE MADE OF CHEAP ALUMINUM CAST AND I BELIEVE SAME HEAT PROBLEM THAT MADE CAUSED ROTOR TO WARP, CAUSED CV SHAFT TO BECOME BRITTLE. EITHER THIS OR COMPONENTS WERE REINSTALLED INCORRECTLY BY JBA CHEVROLET WHEN THEY REPAIRED BRAKE PROBLEM. *TR
NHTSA ODI #10278351
11,000 miles · Mar 16, 2009
Steering
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING BETWEEN 50-70 MPH IN WINDY CONDITIONS, THE VEHICLE BECAME VERY DIFFICULT TO STEER. THE CONTACT ATTEMPTED TO SELL THE VEHICLE, BUT WAS UNSUCCESSFUL. THE FAILURE HAS CAUSED A MAJOR SAFETY ISSUE WITH THE VEHICLE. AN ALIGNMENT WAS PERFORMED, BUT NO ERRORS WERE FOUND. THE M…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING BETWEEN 50-70 MPH IN WINDY CONDITIONS, THE VEHICLE BECAME VERY DIFFICULT TO STEER. THE CONTACT ATTEMPTED TO SELL THE VEHICLE, BUT WAS UNSUCCESSFUL. THE FAILURE HAS CAUSED A MAJOR SAFETY ISSUE WITH THE VEHICLE. AN ALIGNMENT WAS PERFORMED, BUT NO ERRORS WERE FOUND. THE MECHANIC SPECULATED THAT THERE MAY BE AN ISSUE WITH THE ELECTRONIC STEERING SYSTEM. THE CURRENT MILEAGE WAS 31,000 AND FAILURE MILEAGE IS 11,000. UPDATED 04-14-09 *BF UPDATED 04/16/09*JB
NHTSA ODI #10262040
50,000 miles · Mar 9, 2009
Service Brakes, HydraulicSteering
THE BRAKES STARTED SHUTTERING AFTER 20000 MILES, THE DEALER FOUND THE BRAKE ROTORS WERE WARPED AND TURNED THE ROTORS. AT 55000 MILES THE TROUBLE HAS RETURNED AND SINCE THE CAR IS OUT OF THE 3 YRS 36000 MILE WARRANTY WILL NOT FIX. THE BRAKES PULSATE BADLY AT THIS POINT AND 2 SERVICE MANAGERS CLAIM IS THE RESULT OF THE ROTORS BEIN…
Read full complaint
THE BRAKES STARTED SHUTTERING AFTER 20000 MILES, THE DEALER FOUND THE BRAKE ROTORS WERE WARPED AND TURNED THE ROTORS. AT 55000 MILES THE TROUBLE HAS RETURNED AND SINCE THE CAR IS OUT OF THE 3 YRS 36000 MILE WARRANTY WILL NOT FIX. THE BRAKES PULSATE BADLY AT THIS POINT AND 2 SERVICE MANAGERS CLAIM IS THE RESULT OF THE ROTORS BEING TOO LIGHT FOR THE WEIGHT OF THE CAR AND IT IS HAPPENING TO MANY CHEVY HHR OWNERS. THE 2ND PROBLEM IS THE ELECTRONIC STEERING. THE STEERING SHAKES WHEN THE WARPED BRAKES ARE APPLIED DUE TO THE PLASTIC GEARS WEARING AND WHEN YOU ARE DRIVING OVER A ROUGH SURFACE. AGAIN THE DEALER NOR GM WILL MAKE REPAIRS DUE TO CAR OUT OF 3 YR 36000 WARRANTY. AGAIN THE SERVICE MANAGERS HAS ADMITTED THIS PROBLEM IS HAPPENING TO MANY OWNERS. BOTH PROBLEMS CAN LEAD TO A LOSS OF CONTROL AND THE ROTORS COULD CAUSE THE BRAKE PADS TO DETERIORATE AND PREVENT PROPER BRAKING LEADING TO LOSS OF CONTROL AND ACCIDENTS. *TR
NHTSA ODI #10261373
Mileage unknown · Sep 30, 2008
Service Brakes, HydraulicSteeringSuspension
WHEN BRAKES ARE APPLIED, THE STEERING WHEEL AND FRONT END SHAKES. THE VEHICLE HAS BEEN PUT IN THE SHOP 4 TIMES. I BELIEVE THIS FALLS UNDER THE LEMON-LAW. THE VEHICLE IS STILL UNDER WARRANTY. I WANT THE VEHICLE REPLACED OR FIXED. THE CAR IS UNSAFE, FOR MY FAMILY. I HAVE TWINS THAT ARE 3 YEARS OLD!! SOMETHING NEEDS TO BE REPLACE…
Read full complaint
WHEN BRAKES ARE APPLIED, THE STEERING WHEEL AND FRONT END SHAKES. THE VEHICLE HAS BEEN PUT IN THE SHOP 4 TIMES. I BELIEVE THIS FALLS UNDER THE LEMON-LAW. THE VEHICLE IS STILL UNDER WARRANTY. I WANT THE VEHICLE REPLACED OR FIXED. THE CAR IS UNSAFE, FOR MY FAMILY. I HAVE TWINS THAT ARE 3 YEARS OLD!! SOMETHING NEEDS TO BE REPLACED OR FIXED. IT HAS BEEN BACK TO THE DEALER 4 TIMES AND ITS NOT FIXED!!!!! HOWARD H. HEROLD *TR
NHTSA ODI #10243977
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration