TL* THE CONTACT OWNS A 1995 CHEVROLET G20. THE CONTACT WAS DRIVING 20 MPH AND APPLIED THE BRAKES WHEN THE PEDAL DEPRESSED TO THE FLOORBOARD ABNORMALLY. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND COASTED TO A STOP. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME WHERE AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE BUT WAS UNABLE TO…
Read full complaint
TL* THE CONTACT OWNS A 1995 CHEVROLET G20. THE CONTACT WAS DRIVING 20 MPH AND APPLIED THE BRAKES WHEN THE PEDAL DEPRESSED TO THE FLOORBOARD ABNORMALLY. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND COASTED TO A STOP. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME WHERE AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO FILED A COMPLAINT WITH THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 62,173. THE PLUNGER IN THE MASTER CYCLINDER WAS INCAPABLE OF PROPELLING THE BRAKE FLUID THROUGH THE LINES AND THE BRAKE CYCLINDERS COULD NOT EXPAND. VEHICLE HAS STOP BECAUSE OF TRANSMISSION. FAILURE DURING DOWN GRADE. VEHICLE PICKED UP SPEED WHEN TRANSMISSION WAS USED TO STOP ITS FORWARD PROGRESS. UPDATED 11/09/2011 *LN *TR
NHTSA ODI #10426891
Mileage unknown · Mar 6, 2002
Electrical SystemEngine And Engine CoolingExterior Lighting
WE HAVE ALSO HAD PROBLEMS WITH THE RIGHT SIDE AXLE AND BEARINGS. ALSO THE COIL WENT OUT, AS WELL AS THE ENGINE SMALL BLOCK - WHICH DID NOT FIX THE PROBLEM - THEY THEN HAD TO REPLACE THE ENTIRE ENGINE.
NHTSA ODI #759009
Mileage unknown · Oct 27, 2001
Power Train
REAR DRIVE AXEL ALWAYS NOISY, SEAL BROKE 2 TIMES, CAUSING DAMAGE TO BREAKS. THERE IS SCORING OF THE DRIVE AXLE AND HOUSING DAMAGE. I T HAS BEEN REPAIRED BUT I AM INFORMED I NEED A NEW REAR END BUT THAT CHEVROLET DOES NOT PRODUCE THEM. NHTSA REPORTS INDICATE THIS IS A COMMON PROBLEM. I DO NOT WANT TO PAY 850.00 TO RELACE MY USED …
Read full complaint
REAR DRIVE AXEL ALWAYS NOISY, SEAL BROKE 2 TIMES, CAUSING DAMAGE TO BREAKS. THERE IS SCORING OF THE DRIVE AXLE AND HOUSING DAMAGE. I T HAS BEEN REPAIRED BUT I AM INFORMED I NEED A NEW REAR END BUT THAT CHEVROLET DOES NOT PRODUCE THEM. NHTSA REPORTS INDICATE THIS IS A COMMON PROBLEM. I DO NOT WANT TO PAY 850.00 TO RELACE MY USED REAR END WITH A USED ONE THAT WILL FUNCTION JUST AS BADLY. WHERE CAN I GET NEW RELIABLE REPAIR PARTS FROM THE FACTORY. DO THEY ACKNOWLEDGE THIS DEFECT AND ARE THEY MAKING ANY COMPENSATION. COME ON THIS IS A 44,000.00 G-20 MARK III CONVERSION VAN, I WOULD EXPECT A BETTER DRIVE SYSTEM THAN THIS. HELP PLEASE. THANK YOU MRS. SHEPHERD
NHTSA ODI #753765
Mileage unknown · May 24, 2001
Electrical SystemEngine And Engine CoolingEquipment
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONS…
Read full complaint
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONSUMER ALSO COMPLAINED OF A TICKING NOISE BUT WAS ADVISED THAT WAS NORMAL, ALSO SPEAKER ON LEFT SIDE HAS STATIC UNABLE TO BE DUPLICATED, NOISE IN BRAKES WHEN BACKING UP,FRONT DOOR DOES NOT CLOSE PROPERLY MAKES A BANG NOISE,DRIVE BELT SQUEAKING, SERPENTINE BELT WAS REPLACED, WATER LEAKING INTO VEHICLE WINDSHIELD WAS FITTING POOLY REPLACED WINDSHIELD, VACUUM BRAKE BOOSTER WAS REPLACED,STEERING WHEEL VIBRATES AT 40 MPH, CIGARRETTE LIGHTER WHEN IN USE SMOKES DUE TO ASHES ON LIGHTER ELEMENT ALSO IGNITION COIL HAD TO BE RELACED DUE TO CORROSION HYDRAULIC SYSTEM WAS REPLACED .*JB
NHTSA ODI #889102
Mileage unknown · Sep 28, 1999
Power Train
WHILE VEHICLE WAS IN REVERSE IT WOULD NOT ENGAGE IMMEDIATELY. WHEN IT FINALLY ENGAGED, A THUMPING NOISE WAS HEARD. DEALER HAS BEEN NOTIFIED. *AK
NHTSA ODI #848893
Mileage unknown · Nov 4, 1996
Power Train
DIFFERENTIAL RING AND PINION GEAR FAILURE, CAUSING REAR END NOISE. *AK
NHTSA ODI #510868
Mileage unknown · Apr 12, 1995
Power Train
ONCE REACHING AROUND 15 MPH, AUTOMATIC TRANSMISSION HESITATES, THEN BANGS INTO GEAR. PLEASE DESCRIBE DETAILS. TT
VEHICLE DESCRIPTION: CHEVROLET AND GMC G VANS EQUIPPED WITH SLIDING SIDE DOORS AND REMEDIED DURING SAFETY CAMPAIGN (95V197/95-C-58) BETWEEN JULY 18, 1997 AND FEBRUARY 6, 1999. THE SLIDING SIDE-DOOR REAR LATCH WAS REPLACED WITH A LATCH THAT WAS IMPROPERLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE DOOR MAY NOT PERFORM AS REQUIRED AND INCREASED INJURIES COULD RESULT.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH.
THESE VEHICLES WERE BUILT WITH A SLIDING SIDE-DOOR REAR LATCH THAT WAS IMPROPERLY RIVETED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WILL NOT PERFORM AS REQUIRED BY THE STANDARD.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH ON ALL SUSPECT VEHICLES.
BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1995 Chevrolet G20 Problems, Complaints & Recalls | Skip That Year
Illustration