IllustrationWhile driving engine inexplicably shut off leaving us without power steering or brakes and unable to safely navigate off of the roadway. Fault: Fuel Pump Control Module GM representative stated they are seeing numerous failures of these components
2021 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 13 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
What owners actually said
13 reportsThe contact rented a 2021 Chevrolet Express. The contact stated that while driving approximately 30 MPH, the power steering malfunctioned, and the steering wheel became difficult to turn in either direction. The vehicle was slowed to 10 MPH for the contact to regain control of the steering wheel. The vehicle was later towed to t…
Read full complaint
The contact rented a 2021 Chevrolet Express. The contact stated that while driving approximately 30 MPH, the power steering malfunctioned, and the steering wheel became difficult to turn in either direction. The vehicle was slowed to 10 MPH for the contact to regain control of the steering wheel. The vehicle was later towed to the local dealer who diagnosed that the steering gears were faulty and needed to be replaced. The vehicle was repaired. The manufacturer was not yet notified of the failure. The failure mileage was 23.
TPS monitoring system displayed front right tire pressure low. Seconds later tire blew-out where sidewall meets tread. We luckily were traveling at low rate of speed (25mph). This is new van with 100 miles on it.
Official recalls
221V189000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Mar 18, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Express and GMC Savana vehicles equipped with 6.6L gasoline engines. The positive battery cable terminals may contact a fuse block assembly attachment post and cause an electrical short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the repair is complete. GM will notify owners, and dealers will remove a portion of the anti-rotation tab on both positive battery cable terminals near the fuse block assembly attachments, free of charge. If too much of the tab had been removed during prior servicing, the battery cable will be replaced, free of charge. The recall began April 16, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202325160.
21V115000 · Tires
Feb 25, 2021
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.