Illustration-Transmission locked - broken output shaft ring gear weld. -Yes its available for inspection. -Vehicle came to complete stop in middle of freeway as if emergency brake was applied unknowingly. Could be bad if going around corner or downhill -Problem confirmed by dealer -No -No warning signs or check engine light
2019 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports2 injury reports
Power Train complaints
4 reportsI am reporting a recurring transmission defect in my 2019 Chevy Express Cargo Van. Shortly after purchase, I noticed clunking sounds when slowing down or coming to a stop. The issue progressed into rough shifting and eventual check engine lights with codes P0722 and P0700. The dealership stated the valve body had already been re…
Read full complaint
I am reporting a recurring transmission defect in my 2019 Chevy Express Cargo Van. Shortly after purchase, I noticed clunking sounds when slowing down or coming to a stop. The issue progressed into rough shifting and eventual check engine lights with codes P0722 and P0700. The dealership stated the valve body had already been replaced in 2020 and suspects the torque converter is the root cause, which is causing repeated valve body failures. These transmission failures create unsafe driving conditions, including loss of smooth deceleration and unpredictable shifting behavior. I believe this is a design flaw affecting the Hydra-Matic transmission system and may qualify as a safety risk. There are multiple class action lawsuits currently pending regarding GM’s 8-speed transmissions (Speerly v. GM; Battle v. GM), and many consumers are reporting similar symptoms.
The contact owns a 2019 Chevrolet Express 2500. The contact stated that while her husband was driving, the vehicle failed to accelerate after a stop. The vehicle failed to shift into reverse but continued to start. There were no warning lights illuminated. The vehicle was towed to the local dealer but was not diagnosed or repair…
Read full complaint
The contact owns a 2019 Chevrolet Express 2500. The contact stated that while her husband was driving, the vehicle failed to accelerate after a stop. The vehicle failed to shift into reverse but continued to start. There were no warning lights illuminated. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 140,000.
The contact owns a 2019 Chevrolet Express. The contact stated that while the vehicle was stopped with the transmission in reverse(R), the vehicle moved forward. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no…
Read full complaint
The contact owns a 2019 Chevrolet Express. The contact stated that while the vehicle was stopped with the transmission in reverse(R), the vehicle moved forward. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall on the VIN. The failure mileage was approximately 4,783.
Official recalls
421V115000 · Tires
Feb 25, 2021
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
19V644000 · Electrical System: Instrument Cluster/panel; Seat Belts:front:warning Light/devices
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2019 Chevrolet Express and GMC Savana vehicles. The seatbelt-unfastened warning light will not illuminate for approximately five seconds after the ignition is moved to the "on" or "start" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without the seatbelt warning reminder, the driver may forget to fasten the seatbelt, increasing the risk of injury in the event of a crash.
Remedy: GM will notify owners, and dealers will reprogram the instrument panel cluster, free of charge. The recall began October 3, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192264500.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
General Motors LLC (GM) is recalling certain 2019 Chevrolet Express and GMC Savana vehicles. The seatbelt-unfastened warning light will not illuminate for approximately five seconds after the ignition is moved to the "on" or "start" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: Without the seatbelt warning reminder, the driver may forget to fasten the seatbelt, increasing the risk of injury in the event of a crash.
Remedy: GM will notify owners, and dealers will reprogram the instrument panel cluster, free of charge. The recall began October 3, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192264500.
Seat Belts:front:warning Light/devices
General Motors LLC (GM) is recalling certain 2019 Chevrolet Express and GMC Savana vehicles. The seatbelt-unfastened warning light will not illuminate for approximately five seconds after the ignition is moved to the "on" or "start" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: Without the seatbelt warning reminder, the driver may forget to fasten the seatbelt, increasing the risk of injury in the event of a crash.
Remedy: GM will notify owners, and dealers will reprogram the instrument panel cluster, free of charge. The recall began October 3, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192264500.
19V428000 · Equipment
Jun 11, 2019
Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & remedy
Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy: Unicell will work with ASA Electronics to notify owners and offer a remedy, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service 1-800-384-4400 or Unicell at 1-716-853-8628.
19V387000 · Visibility:glass, Side/rear
May 23, 2019
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Remedy: GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.