WE DEVELOPED A SIGNIFICANT LEAK IN A REAR BRAKE LINE OF OUR VAN. THE LEAK DID NOT LEAD TO A LOSS OF CONTROL, BUT THE BRAKE RESERVOIR WAS NEARLY EMPTY WHEN I DISCOVERED THE ISSUE. THE LEAK WAS DISCOVERED BASED ON A LARGE SPOT LEFT ON OUR DRIVEWAY UNDER THE VAN. THE VEHICLE WAS PROBABLY DRIVEN ABOUT 50-100 MILES (ONE TO TWO DAYS) …
Read full complaint
WE DEVELOPED A SIGNIFICANT LEAK IN A REAR BRAKE LINE OF OUR VAN. THE LEAK DID NOT LEAD TO A LOSS OF CONTROL, BUT THE BRAKE RESERVOIR WAS NEARLY EMPTY WHEN I DISCOVERED THE ISSUE. THE LEAK WAS DISCOVERED BASED ON A LARGE SPOT LEFT ON OUR DRIVEWAY UNDER THE VAN. THE VEHICLE WAS PROBABLY DRIVEN ABOUT 50-100 MILES (ONE TO TWO DAYS) AFTER THE LEAK DEVELOPED BUT BEFORE THE ISSUE WAS DISCOVERED AND ADDRESSED. WHILE FIXING THE PROBLEM, I FOUND THAT THE LEAK WAS DUE TO AN ASSEMBLY ERROR. THE VAN'S FUEL FILLER DOWN-PIPE HAS A WORM-GEAR CLAMP THAT WAS NOT PROPERLY CLOCKED. THIS CAUSED THE CLAMP TO RUB ONE OF THE REAR BRAKE LINES AND WEAR A HOLE IN IT. I SENT TWO PICTURES SHOWING THE CLAMP AND BRAKE LINE AS I DISCOVERED THEM. I ALSO SENT A PICTURE OF THE DAMAGED LINE AFTER BEING REMOVED FROM THE VEHICLE. THE VAN HAD ABOUT 87,000 MILES WHEN THE LEAK DEVELOPED.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A CLEARANCE CONDITION IN WHICH THE RIGHT REAR BRAKE HOSE MAY CONTACT THE TIRE OR WHEEL RIM. IF THE BRAKE HOSE REPEATEDLY CONTACTS THE TIRE OR WHEEL RIM, A HOLE COULD BE WORN IN THE BRAKE HOSE.
Consequence & remedy
Consequence: A DAMAGED BRAKE HOSE MAY REDUCE THE EFFECTIVENESS OF THE REAR BRAKES AND INCREASE THE DISTANCE REQUIRED TO STOP THE VEHICLE. AN INCREASED BRAKING DISTANCE MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL SECURE THE RIGHT REAR BRAKE HOSE TO ENSURE SUFFICIENT CLEARANCE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2011 Chevrolet Express 1500 Problems, Complaints & Recalls | Skip That Year
Illustration