2017 Chevrolet Equinox

My husband was driving our vehicle on his way to work on [XXX] very early in the morning. He was on the highway going 70 mph. While driving he noticed a tire pressure monitoring system warning come up. Shortly after the vehicle went into reduced power mode. He was able to exit the highway and get the vehicle stopped. Upon stopping the vehicle died. Upon getting out of the vehicle he noticed a large oil leak on the ground and coating the underside of the vehicle. Had this incident happened during a busier traffic hour the sudden drastic slow in speed could have resulted in an accident. There was also oil left on the roadway that could be a hazard to other drivers. We had the vehicle towed to our mechanic. He confirmed that the engine had blown and would need replaced. He informed us that this vehicle has a known oil overconsumption issue. GM has settled on a class action lawsuit involving this make and model for the 2010 to 2013 model years. There is also a class action lawsuit currently in process out of Missouri against GM for the model years 2014 to 2017. I contacted GM and was told there was no active recall on my vehicle. I inquired about help getting the issue resolved and was told they were unable to help due to the vehicle not being diagnosed at a GM dealership. O have contacted GM dealerships and am having a hard time finding one that is willing to work with me on getting this issue resolved. This vehicle never warned of low oils or oil pressure. The engine did not make any kind of noise to indicate an issue. There was nothing indication anything was wrong with the vehicle until the vehicle went into low power mode and the engine was blown. A police report was not filed and insurance has not been contacted due to no accident being caused by the incident. The vehicle is still with my independent mechanic as we try to figure out how to cover the cost of this very costly repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2/4/19 bulletin issued for PCV valve defect [XXX] bought car from dealer, was told nothing wrong with car [XXX] sold me a extended warranty to assure me the car would be protected [XXX] car wouldn’t start in driveway had it towed to Tarr Chevrolet. [XXX] warranty refused to fix car, seems they excluded the PCV valve from warranty. The PCV valve blew the rear seal, part of the power train which I have a lifetime warranty on. But since the PCV valve caused it , they didn’t cover that either. This repair cost me $2800.00. Living on social security that’s a lot of money. I have called Chevy, the dealer and the warranty co to no avail, I have read about all the class action suits. This is a very serious problem. The bulletin states below 0 temperatures can cause this, we live in Tennessee, we don’t have that kind of weather. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Chevrolet Equinox. The contact stated while driving 71 MPH, the engine lost power with the check engine and stability-track warning lights illuminated. The vehicle entered LIMP Mode. The contact was able to coast the vehicle to a local gas station. The contact approached the gas station, and the vehicle shut off. Due to the failure, the vehicle was towed to an independent mechanic where a diagnostic test was performed; however, the mechanic could not determine the cause of the failure. The vehicle was towed to the residence. The dealer was notified of the failure and the contact was informed that the PCV valve had frozen due to the cold weather. The contact was informed that the failure then pressurized the crankcase valve and blew the engine oil seal. The contact was also informed that the timing chain had failed and caused the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 68,000.

Two massive oil leaks experienced while driving during cold weather months. One two years ago (Feb 2023) and the other January 2025. Both instance caused by Rear Main Seal and led to mass oil loss while operating and vehicle almost shutting down on roadway. There appears to have been bulletins sent to dealers from GM on the matter but no indication to customers of the potential dangers.

My 2017 Chevy Equinox, equipped with the 2.4L Ecotec engine, experienced a catastrophic failure due to a faulty PCV system. In cold weather, condensation caused the PCV valve to malfunction, leading to excessive pressure and ultimately blowing out the rear main seal. This issue has been well-documented in the 2010–2013 models, which were covered under a class-action lawsuit, but the same defect persists in later models, including mine, which are not covered. This design flaw creates a significant safety and financial burden for owners and needs further investigation. My car shut off several times while driving in heavy traffic. I was in the car with my 6 year old child taking him to school on a busy street. This could have been catastrophic. In addition, I was informed my engine is burning oil excessively which is also a known issue. The safety risk posed by the defect, readily know by service techs, is substantial, the lawsuits claim, given that an engine operating without sufficient oil could wear down and fail prematurely, even during the course of normal operation, due to friction. According to the lawsuits, General Motors, for its part, actively concealed from consumers that its Equinox and Terrain vehicles suffered from an oil consumption defect. Worse, the suits say, GM allegedly failed to offer vehicle owners and lessees any help by way of repairs or recalls. Oil leak caused by insufficient ventilation and excessive oil burning caused rear main seal and timing chain belts to fail. My oil warning systems never detected the low oil. Research has shown that this has been a known Chevy problem since 2017, with a recall being issued earlier on but no known recall now. Dealer has confirmed issues and also that the engine design is flawed and leads to oil burning excessively