IllustrationHAVING TO CONTINUES PUT OIL IN THE VEHICLE HAVE HAD IT CHECK OUT. THEY SAID NO SIGNS OF A LEAK. DO NOT SMELL ANY OIL BURNING. SEEMS LIKE A LOT OF PEOPLE ARE HAVING THESE SAME PROBLEMS.
2012 Chevrolet Equinox
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chevrolet Equinox do not stand out strongly from the model-year median of 382.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Equinox years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
5325–50K
11450–75K
11375–100K
137100–150K
30150K+
498 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 354 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports6 fire reports11 injury reports
What owners actually said
683 reportsI PURCHASED THE VEHICLE FROM A DEALERSHIP IN LEXINGTON KY 6K AND UNDER. I HAD TO CHANGE THE BREAKS AND I WAS UNABLE TO JACK THE CAR UP. AFTER TAKING IT TO THE AUTO SHOP THE FRAME AND ROCKER PANELS ARE RUSTED OUT. THE VEHICLE WAS MADE IN CANADA AND I SEEN THERE WAS A RECALL ON THE VEHICLE. IT IS DANGEROUS TO DRIVE BECAUSE THE FRA…
Read full complaint
I PURCHASED THE VEHICLE FROM A DEALERSHIP IN LEXINGTON KY 6K AND UNDER. I HAD TO CHANGE THE BREAKS AND I WAS UNABLE TO JACK THE CAR UP. AFTER TAKING IT TO THE AUTO SHOP THE FRAME AND ROCKER PANELS ARE RUSTED OUT. THE VEHICLE WAS MADE IN CANADA AND I SEEN THERE WAS A RECALL ON THE VEHICLE. IT IS DANGEROUS TO DRIVE BECAUSE THE FRAME IS WEAK. WHAT SHOULD I DO AND IS THE RECALL STILL VALID?
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. ADDITIONALLY, THE ENGINE WAS OVERHEATING. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE ABNORMALLY WHILE COMING TO A STOP. THE CONTACT NOTICED THAT THE ENGINE WOULD RUN FOR AN EXTENDED PERIOD AFTER THE IGNITION HAD …
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. ADDITIONALLY, THE ENGINE WAS OVERHEATING. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE ABNORMALLY WHILE COMING TO A STOP. THE CONTACT NOTICED THAT THE ENGINE WOULD RUN FOR AN EXTENDED PERIOD AFTER THE IGNITION HAD BEEN TURNED OFF. THE VEHICLE ALSO STALLED SUDDENLY WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT STATED THAT INITIALLY THE VEHICLE WOULD RESTART RIGHT AWAY HOWEVER, AFTER THE LAST FAILURE, SEVERAL ATTEMPTS WERE NEEDED FOR THE VEHICLE TO RESTART. THE CONTACT TOOK THE VEHICLE TO DIAMOND AUTO SALES (255 EASTON RD, GLENSIDE, PA 19038, (215)887-2345) WHO REPLACED THE MASS AIR FLOW SENSOR AND THE CAM SHAFT SOLENOID ADJUSTER HOWEVER, THE FAILURE PERSISTED. THE CONTACT THEN TOOK THE VEHICLE TO BRYNER CHEVROLET, INC. (1750 THE FAIRWAY, JENKINTOWN, PA 19046, (215)402-7267) WHO REPLACED THE WATER PUMP HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE WARRANTY WOULD NOT COVER THE REPAIR. THE CONTACT WAS THEN REFERRED TO NHTSA FOR ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
THE CAR WAS IN MOTION WHEN THE REDUCED ENGINE POWER SENSOR CAME ON AND SHUT DOWN. IT WAS TOWED TO A LOCAL REPAIR SHOP WHERE IT WAS DETERMINED THAT THE TIMING CHAIN BROKE DUE TO LACK OF OIL DUE TO BENT PISTON RINGS AND THE OIL ESCAPING. ALL OF THAT WAS REPAIRED AND MAYBE 6 MONTHS LATER THE CHECK ENGINE LIGHT WAS BACK ON. WE TOOK …
Read full complaint
THE CAR WAS IN MOTION WHEN THE REDUCED ENGINE POWER SENSOR CAME ON AND SHUT DOWN. IT WAS TOWED TO A LOCAL REPAIR SHOP WHERE IT WAS DETERMINED THAT THE TIMING CHAIN BROKE DUE TO LACK OF OIL DUE TO BENT PISTON RINGS AND THE OIL ESCAPING. ALL OF THAT WAS REPAIRED AND MAYBE 6 MONTHS LATER THE CHECK ENGINE LIGHT WAS BACK ON. WE TOOK IT BACK TO THE SHOP AND IT WAS DECIDED THERE WAS EXTENSIVE DAMAGE DONE TO THE ENGINE BASED ON THE PREVIOUS OIL CONSUMPTION ISSUE. THE ENGINE WAS THEN REPLACED AS WELL AS THE ECM BOARD DUE TO OIL BEING ALL OVER IT COMPLETELY RUINING THE SENSORS. WE ALSO HAVE HAD TO REPLACE THE EVAP SYSTEM DUE LACK OF OXYGEN AND THE CAR CONSTANTLY CHOCKING OUT WHILE IN MOTION AND WHILE IDELING. WE FILED OUR CLAIM WHEN THE CLASS ACTION LAWSUIT CAME OUT AND OF COURSE WE'RE DENIED, JUST LIKE THE THOUSANDS OF OTHER PEOPLE DUE TO THERE BEING 'LACK OF PROOF' THAT IT WAS DUE TO LACK OF OIL. I WAS CONSTANTLY CHECKING MY OIL, GETTING IT CHANGED, ADDING THE RIGHT OIL WHEN IT WAS LOW AND BECAUSE I DID NOT DO THE OIL CONSUMPTION TEST THROUGH GM WE ARE OUT ALMOST 10 THOUSAND DOLLARS ON A CAR THAT STILL HAD ISSUES DUE TO THE LACK OF OIL. THE FIRST TIME IT BROKE DOWN I HAD A POWER TRAIN WARRANTY ON THE VEHICLE AND THEY DID AN INVESTIGATION TO MAKE SURE IT WAS DUE TO A LACK OF OIL CHANGES AND BUILD UP OF DIRTY OIL, IT WAS PROVED THAT THE OIL ESCAPED THROUGH THE BENT PISTON RINGS AND BURNT OFF INSTEAD OF GOING BACK INTO THE ENGINE. THEY DID COVER THE TIMING CHAIN BUT ONCE THE ENGINE NEEDED TO BE REPLACED WE NO LONGER HAD THE WARRANTY. I'M NOT SURE WHY THAT INVESTIGATION WAS NOT GOOD ENOUGH FOR THE SETTLEMENT TO GO THROUGH BUT REGARDLESS THESE VEHICLES ARE SO UNSAFE AND MONEY PITS AND ARE STILL BEING SOLD TO INNOCENT PEOPLE WHO HAVE NO IDEA WHAT THEY ARE GETTING THEMSELVES INTO. A RECALL ABSOLUTELY SHOULD BE MADE.
I'VE BEEN TO PLENTY OF MECHANIC SHOPS AND THEY ALL HAVE SAID THE SAME THING ABOUT THE MOTOR AND THE ENGINE THAT'S IN THESE CARS THEY SAY THEY ARE NOT THE RIGHT ENGINES AND EVERYONE THAT HAVE THESE CARS HAVE THE SAME PROBLEM I HAVE GOTTEN EVERYTHING FIXED AND MY ENGINE IS GOING BAD. I'VE BEEN TOLD THERE IS A RECALL FOR MY ENGINE …
Read full complaint
I'VE BEEN TO PLENTY OF MECHANIC SHOPS AND THEY ALL HAVE SAID THE SAME THING ABOUT THE MOTOR AND THE ENGINE THAT'S IN THESE CARS THEY SAY THEY ARE NOT THE RIGHT ENGINES AND EVERYONE THAT HAVE THESE CARS HAVE THE SAME PROBLEM I HAVE GOTTEN EVERYTHING FIXED AND MY ENGINE IS GOING BAD. I'VE BEEN TOLD THERE IS A RECALL FOR MY ENGINE & OR MOTOR. FOR THE LAST FEW WEEKS MY CHECK ENGINE LIGHT GAVE BEEN ON THEN OUT THE BLUE MY STABILITRAK COMES ON NO ONE COULD FIGURE IT OUT I TOOK IT TO GM THEY DIDN'T FIND ANYTHING BESIDES SPARK PLUGS, OIL CHANGE ,FUEL FLUSH & ENGINE TOP CLEANER NOW THEY SAYING AFTER THE SPARKPLUGS GOT DONE IT CLEARED THAT CODE BUT NOW MY ENGINE IS BAD. I GET OIL CHANGED EVERY MONTH. WHICH MEANS IT'S GETTING TO MUCH OIL.
2012 CHEVORLET EQUINOX WITH 2.4L ENGINE WITH 123,525 MILES HAS MANY SAFETY CONCERNS. AS A RESULT OF THIS SPECIFIC ENGINE, THERE ARE ISSUES THAT AFFECT THE QUALITY OF SAFETY. THIS VEHICLE HAS EXCESSIVE OIL CONSUMPTION, NEEDS FREQUENT OIL REFILLING (AT LEAST 1QUART/WEEKLY), AND EMITS THE SMELL OF FUMES AND LINGERS WHEN VEHICLE IS …
Read full complaint
2012 CHEVORLET EQUINOX WITH 2.4L ENGINE WITH 123,525 MILES HAS MANY SAFETY CONCERNS. AS A RESULT OF THIS SPECIFIC ENGINE, THERE ARE ISSUES THAT AFFECT THE QUALITY OF SAFETY. THIS VEHICLE HAS EXCESSIVE OIL CONSUMPTION, NEEDS FREQUENT OIL REFILLING (AT LEAST 1QUART/WEEKLY), AND EMITS THE SMELL OF FUMES AND LINGERS WHEN VEHICLE IS ON. I AM NOT ABLE TO HAVE THE CAR ON STOPPED AT A STOPLIGHT OR SIMPLY WHILE IN PARK WITHOUT THE OVERWHELMING SMELL OF FUMES. THIS VEHICLE HAS COMPLETELY SHUT OFF ON TWO OCCASIONS: FIRST, IT SHUT OFF HALFWAY UP A RAMP LEADING OFF FROM THE HIGHWAY AND SECOND, DURING A RED LIGHT AT A BUSY INTERSECTION. THERE WERE VEHICLES DRIVING BEHIND AT BOTH TIMES. I NO LONGER FEEL SAFE DRIVING THIS VEHICLE, NOR DO I THINK IT IS SAFE TO HAVE OTHERS IN THE CAR.
MY CAR RANDOMLY SHUTS OFF. IT STUTTERS, STALLS, JERKS, THEN DIES. NO CHECK ENGINE LIGHT COMES ON. WE HAVE REPLACED THE O2 SENSORS 3 TIMES, MASS AIR FLOW SENSOR, EXHAUST MANIFOLD, INTAKE AND EXHAUST VALVES TWICE, ALTERNATOR, BATTERY TWICE, SPARK PLUG PACKS TWICE, THROTTLE BODY, AND CATALYTIC CONVERTOR. MY CAR STILL STUTTERS, STAL…
Read full complaint
MY CAR RANDOMLY SHUTS OFF. IT STUTTERS, STALLS, JERKS, THEN DIES. NO CHECK ENGINE LIGHT COMES ON. WE HAVE REPLACED THE O2 SENSORS 3 TIMES, MASS AIR FLOW SENSOR, EXHAUST MANIFOLD, INTAKE AND EXHAUST VALVES TWICE, ALTERNATOR, BATTERY TWICE, SPARK PLUG PACKS TWICE, THROTTLE BODY, AND CATALYTIC CONVERTOR. MY CAR STILL STUTTERS, STALLS, ROUGH IDLES, JUMPS WHILE STOPPED AT RED LIGHTS, AND RANDOMLY SHUTS OFF WITH NO WARNING. RECENTLY IT HAS BEEN SLOW TO ACCELLERATE AS WELL. I WAS UNAWARE OF THE OIL CONSUMPTION ISSUE UNTIL THIS WEEKEND. MY CAR SAYS IT IS 40% OIL, IT IS NOT DUE FOR ANOTHER OIL CHANGE FOR ANOTHER 1000 MILES. AFTER LEARNING ABOUT THE OIL CONSUMPTION ISSUE I CHECKED THE OIL, VIA THE DIPSTICK, AND MY CAR WAS BONE DRY! I NEVER RECEIVED A LOW OIL WARNING. I AM ASSUMING THIS IS WHY MY CAR HAS BEGUN ACTING CRAZY IN THE LAST YEAR. UNFORTUNATELY THE CHEVY DEALERSHIP NEVER INFORMED ME OF ANY OIL ISSUES SO I HAVE HAD TO CONTACT GM DIRECTLY, BECAUSE NOW MY CAR IS AT 126,000 MILES!!!
I WAS DRIVING ON A BUSY RURAL ROUTE WHEN I CAME TO A STOP , WENT TO TAKE OFF THE CAR HAD NO POWER. I HAVE ONLY HAD THIS VEHICLE 1 MONTH, AND THE CODE SAYS IT IT THE TRANSMISSION CONTROL MODULE . LUCKILY WE WERE NOT HIT AFTER ABOUT 30 SECONDS IT KICKS IN AND HAS POWER , NOT VERY SAFE AT ALL .
I BOUGHT A NEW 2012 EQUINOX IN 2012 ([XXX]) LAST WEEK THE ENGINE FAILED. LOW OIL WARNING LIGHT NEVER CAME ON! DO I HAVE ANY OPTIONS? DO DON'T SEE ANY RECALLS FOR THIS? I BOUGHT A NEW 2012 EQUINOX IN 2012 ([XXX]) LAST WEEK THE ENGINE FAILED. LOW OIL WARNING LIGHT NEVER CAME ON! DO I HAVE ANY OPTIONS ? DO DON'T SEE ANY…
Read full complaint
I BOUGHT A NEW 2012 EQUINOX IN 2012 ([XXX]) LAST WEEK THE ENGINE FAILED. LOW OIL WARNING LIGHT NEVER CAME ON! DO I HAVE ANY OPTIONS? DO DON'T SEE ANY RECALLS FOR THIS? I BOUGHT A NEW 2012 EQUINOX IN 2012 ([XXX]) LAST WEEK THE ENGINE FAILED. LOW OIL WARNING LIGHT NEVER CAME ON! DO I HAVE ANY OPTIONS ? DO DON'T SEE ANY RECALLS FOR THIS? [XXX] [XXX] I BOUGHT A NEW 2012 EQUINOX IN 2012 ([XXX]) LAST WEEK THE ENGINE FAILED. LOW OIL WARNING LIGHT NEVER CAME ON! DO I HAVE ANY OPTIONS ? DO DON'T SEE ANY RECALLS FOR THIS? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
WHILE DRIVING MY 2012 CHEVY EQUINOX ON ILLINOIS, I-90 AT 70 MPH VEHICLE STARTED TO LOSE POWER. ENGINE COULD NOT ACCELERATE, STARTED SHAKING, THAN STALLED. PUTTING MYSELF & FAMILY AT RISK & IN DANGER. ENGINE NEEDED TO BE REPLACED OR REBUILT, HAD IT REBUILT. GM IS AWARE OF THEIR FAULTY ENGINES BUT CONTINUES TO SELL THESE CARS AND …
Read full complaint
WHILE DRIVING MY 2012 CHEVY EQUINOX ON ILLINOIS, I-90 AT 70 MPH VEHICLE STARTED TO LOSE POWER. ENGINE COULD NOT ACCELERATE, STARTED SHAKING, THAN STALLED. PUTTING MYSELF & FAMILY AT RISK & IN DANGER. ENGINE NEEDED TO BE REPLACED OR REBUILT, HAD IT REBUILT. GM IS AWARE OF THEIR FAULTY ENGINES BUT CONTINUES TO SELL THESE CARS AND PUT FAMILIES AT RISK. THEY LOST A LAWSUIT BUT CONTINUE TO DENY CLAIMS & RESELL THE FAULTY VEHICLES. WAITED ALMOST A YEAR TO BE DENIED. THESE VEHICLES WITH THE FAULTY ENGINES NEED TO BE PULLED IMMEDIATELY & CONSUMERS NEED TO BE REIMBURSED FOR THE COST OF FIXING GM'S MISTAKES.
Official recalls
316V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
11V511000 · Tires:pressure Monitoring And Regulating Systems
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.