IllustrationVEHICLE FIRST STARTED CUTTING OFF WHEN PLACED IN DRIVE AND REVERSE. IT IS NOW CUTTING OFF EVEN WHEN VEHICLE IS BEING DRIVEN WHEN PULLING OFF FROM A STOPPED POSITION. THIS HAS BEEN HAPPENING NOW FOR A WEEK. CHECK ENGINE LIGHT CAME ON AND GAVE A P0010 CODE. CAM SENSOR WAS REPLACED AND ISSUE IS STILL CONTINUING TO HAPPEN.
2012 Chevrolet Equinox
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chevrolet Equinox do not stand out strongly from the model-year median of 382.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Equinox years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
5325–50K
11450–75K
11375–100K
137100–150K
30150K+
498 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 354 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports6 fire reports11 injury reports
Power Train complaints
84 reportsVEHICLE FIRST STARTED CUTTING OFF WHEN PLACED IN DRIVE AND REVERSE. IT IS NOW CUTTING OFF EVEN WHEN VEHICLE IS BEING DRIVEN WHEN PULLING OFF FROM A STOPPED POSITION. THIS HAS BEEN HAPPENING NOW FOR A WEEK. CHECK ENGINE LIGHT CAME ON AND GAVE A P0010 CODE. CAM SENSOR WAS REPLACED AND ISSUE IS STILL CONTINUING TO HAPPEN.
I WAS DRIVING ABOUT 20 MILES PER HOUR WHEN ALL THE GAUGES ON THE DASH BOARD WENT CRAZY. THE ECO FUEL ECONOMY LIGHT WAS FLASHING ON AND OFF, THE STABILI TRAK LIGHTS APPEARED ON THE DASHBOARD WITHOUT ME EVEN TOUCHING THE BUTTON, THE SPEEDOMETER AND ENGINE COOLANT TEMPERATURE GAUGE WERE GOING UP AND DOWN ERADICALLY. THE CHECK ENGIN…
Read full complaint
I WAS DRIVING ABOUT 20 MILES PER HOUR WHEN ALL THE GAUGES ON THE DASH BOARD WENT CRAZY. THE ECO FUEL ECONOMY LIGHT WAS FLASHING ON AND OFF, THE STABILI TRAK LIGHTS APPEARED ON THE DASHBOARD WITHOUT ME EVEN TOUCHING THE BUTTON, THE SPEEDOMETER AND ENGINE COOLANT TEMPERATURE GAUGE WERE GOING UP AND DOWN ERADICALLY. THE CHECK ENGINE INDICATOR THEN APPEARED ON THE DASH BOARD. I STOPPED AT A RED LIGHT, WHEN I WENT TO STEP ON THE ACCELERATOR, I HAD NO POWER. THE ACCELERATOR WAS PUSHED TO THE FLOOR AND I WAS GOING ABOUT 5 MILES AND HOUR. ALL THE ABOVE WAS STILL HAPPENING ON THE DASHBOARD. THE AC WAS NOW BLOWING WARM AIR. IT SMELLED LIKE SOMETHING WAS BURNING. THIS HAPPENED THREE TIMES. IN THE END THE SPEEDOMETER WASN'T WORKING. I REACHED SOMEWHERE SAFE AND PARKED THE CAR. I WENT TO SHIFT THE CAR INTO DRIVE AND THERE WAS A HARD LOUD CLUNKING NOISE. THIS ONLY HAPPENED WHEN THE CAR WAS SHIFTED INTO DRIVE. MY HUSBAND TOOK THE CAR TO AUTO ZONE WHERE THEY PRINTED OUT THE CODES APPEARING FOR THE CHECK ENGINE INDICATOR. ( P069E, P0700, U0073, U0100) THE BATTERY IN THE CAR HAS ALSO BEEN REPLACED WITH A NEW ONE TWICE. IT HAS BEEN TOWED TO THE DEALERSHIP TWICE DUE TO NOT STARTING THE NEXT DAY AFTER IT HAS BEEN DRIVEN THE DAY BEFORE AND WORKING NORMAL. WE TOOK THE CAR TO THE CHEVROLET DEALERSHIP. THEY UNDERSTOOD WHAT HAD HAPPENED. THAT EVENING THEY CALLED US BACK SAYING, " WE CAN'T DUPLICATE THE PROBLEM, SO EVERYTHING IS FINE." WE LOST OUR MIND AND TOLD THEM TO KEEP THE CAR AT THE DEALERSHIP UNTIL THEY COULD DUPLICATE THE PROBLEM BECUASE THE CAR ISN'T THREE YEARS OLD AND SHOULDN'T HAVE THESE PROBLEMS. FURTHER, THE CAR ISN'T SAFE!! WE READ BLOGS WHERE THIS IS COMMON WITH THE EQUINOX AND INDICATED THAT TO THE DEALERSHIP. THE CAR IS STILL AT THE DEALERSHIP.
THIS VEHICLE EXHIBITS THE EXACT SAME ISSUES NOTED IN BULLETIN #12313B, WHICH AFFECTS THE 2010 AND 2011 2.4L EQUINOX. OVER THE LAST SEVERAL MONTHS THE ENGINE BECAME INCREASINGLY LOUDER. A LARGE AMOUNT OF FUEL WAS DISCOVERED IN THE CRANKCASE. THE DEALER REPLACED THE TIMING CHAIN ASSEMBLY AND THE HIGH PRESSURE FUEL PUMP AS OUTLI…
Read full complaint
THIS VEHICLE EXHIBITS THE EXACT SAME ISSUES NOTED IN BULLETIN #12313B, WHICH AFFECTS THE 2010 AND 2011 2.4L EQUINOX. OVER THE LAST SEVERAL MONTHS THE ENGINE BECAME INCREASINGLY LOUDER. A LARGE AMOUNT OF FUEL WAS DISCOVERED IN THE CRANKCASE. THE DEALER REPLACED THE TIMING CHAIN ASSEMBLY AND THE HIGH PRESSURE FUEL PUMP AS OUTLINED IN BULLETIN #12313B, BUT THE 2012 MODEL YEAR IS NOT INCLUDED UNDER THE SPECIAL COVERAGE OF 10 YEARS, 120K MILES, AS OUTLINED IN THE BULLETIN. THIS SPECIAL COVERAGE SHOULD BE EXTENDED TO LATER MODEL CHEVROLET EQUINOX 2.4L ENGINES. THE COVERAGE IS A NECESSITY DUE TO THE WEAR THAT HAS OCCURRED FROM FUEL BEING IN THE OIL.
HI, MY 2012 EQUINOX STALLED ON ME WHILE I WAS IN REVERSE. I WAS BACKING OUT A DRIVE WAY AND IT STARTED TO JERK. AFTER JERKING IT DID EVENTUALLY GO IN GEAR. ONCE I PUT IT IN DRIVE I DROVE NO LESS THEN A MILE AND THE CAR CUT OFF. I TURN IT BACK ON AND PUT IT BACK IN DRIVE AND IT STALLED OUT AGAIN. THAT WAS THE FIRST INCIDENT IT HA…
Read full complaint
HI, MY 2012 EQUINOX STALLED ON ME WHILE I WAS IN REVERSE. I WAS BACKING OUT A DRIVE WAY AND IT STARTED TO JERK. AFTER JERKING IT DID EVENTUALLY GO IN GEAR. ONCE I PUT IT IN DRIVE I DROVE NO LESS THEN A MILE AND THE CAR CUT OFF. I TURN IT BACK ON AND PUT IT BACK IN DRIVE AND IT STALLED OUT AGAIN. THAT WAS THE FIRST INCIDENT IT HAPPEN A SECOND TIME ON 5/2/15. WHILE DRIVING MY CAR WAS JERKING WHEN AT A STOP LIGHT AND THEN IT STALLED OUT ON ME AGAIN. AM NOT SURE WHY THIS IS HAPPENING CONSIDERING I DO HAVE REGULAR MAINTENANCE DONE ON MY CAR. IF THIS IS A KNOWN ISSUE PLEASE LET ME. THANKS *TR
WHILE DRIVING DOWN I-96 IN MICHIGAN AT MILE 62, I FELT AN EXPLOSION UNDER MY FEET. THERE WAS A LARGE CLOUD OF BLACK SMOKE FOLLOWED BY FLAMES UNDERNEATH AND OUT THE BACK OF THE VEHICLE. I PULLED TO THE SIDE OF THE ROAD, RAN TO SAFETY WHILE WATCHING THE VEHICLE BURN UNDERNEATH. THE AIR DRAFT FROM PASSING TRAFFIC EXTINGUISHED THE…
Read full complaint
WHILE DRIVING DOWN I-96 IN MICHIGAN AT MILE 62, I FELT AN EXPLOSION UNDER MY FEET. THERE WAS A LARGE CLOUD OF BLACK SMOKE FOLLOWED BY FLAMES UNDERNEATH AND OUT THE BACK OF THE VEHICLE. I PULLED TO THE SIDE OF THE ROAD, RAN TO SAFETY WHILE WATCHING THE VEHICLE BURN UNDERNEATH. THE AIR DRAFT FROM PASSING TRAFFIC EXTINGUISHED THE FIRE. QUALIFIED TECHNICIANS AT OUR LOCAL CHEVROLET DEALER HAVE TOLD US THERE IS A GOLF-BALL SIZE HOLE AND A SOFTBALL SIZE HOLE IN THE ENGINE IN ADDITION TO NUMEROUS ISSUES RESULTING FROM THE FIRE (MELTED FUEL AND BRAKE LINES, CHARRED AND BUBBLED PAINT AND MELTED PLASTIC PARTS, ETC.) ALTHOUGH THIS IS COVERED BY GM WARRANTY AND THEIR INVESTIGATION "TOTALED" THE CAR , CUSTOMER SERVICE HAS NOT OFFERED ASSISTANCE THAT WILL COVER REPLACEMENT OF THIS VEHICLE. *TR
WHEN THE CAR IS STOP AND YOU START TO DRIVE IT WILL JERK FORWARD AS THE TRANSMISSION SHIFT. *TR
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. WHILE DRIVING 15 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 2…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. WHILE DRIVING 15 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 29,000..UPDATED 09/ 30/14 *BF THE CONSUMER STATED WHILE MAKING A RIGHT TURN, THE STEERING WHEEL SEEMED TO BREAK FREE AND CONTINUED MOVING ABOUT TWO INCHES. AT THE SAME TIME, THE VEHICLE SHUT OFF, THE LIGHTS WENT OUT. THE CONSUMER HAD TO COAST TO THE SIDE OF THE ROAD. WHEN HE FINALLY STOPPED, HE WAS ABLE TO MOVE THE GEAR SHIFT FROM DRIVE TO PARK AND RESTARTED THE VEHICLE. THE DEALER WAS UNABLE TO FIND A PROBLEM. UPDATED 10/08/14
WHILE DRIVING I SLOWED DOWN TO STOP FOR LIGHT , LIGHT CHANGED SO I ACCELERATED WHEN I STEP ON GAS VEHICLE HESITATED AND LURCHED FORWARD WITH AN IMPACT SIMILAR TO BEING REAR ENDED AT A HIGH RATE OF SPEED. ON ANOTHER OCCASION WHEN ACCELERATING VEHICLE ALMOST STALLED BEFORE TRANSMISSION ENGAGED. ON ANOTHER OCCASION THE VEHICLE WAS …
Read full complaint
WHILE DRIVING I SLOWED DOWN TO STOP FOR LIGHT , LIGHT CHANGED SO I ACCELERATED WHEN I STEP ON GAS VEHICLE HESITATED AND LURCHED FORWARD WITH AN IMPACT SIMILAR TO BEING REAR ENDED AT A HIGH RATE OF SPEED. ON ANOTHER OCCASION WHEN ACCELERATING VEHICLE ALMOST STALLED BEFORE TRANSMISSION ENGAGED. ON ANOTHER OCCASION THE VEHICLE WAS AT A DEAD STOP AND WHEN I STEPPED ON GAS PEDDLE VEHICLE DID NOT MOVE IMMEDIATELY . THIS HAS BEEN AN INTERMITTENT PROBLEM GOING ON FOR OVER 2 YEARS AND 30000 MILES. EVERY TIME I TOOK IT IN FOR MAINTENANCE I WOULD COMPLAIN ABOUT PROBLEM TO NO HELP FROM DEALER THEY COULD NOT DUPLICATE. I CONTACTED GM ABOUT PROBLEM THEY SENT ME TO SELLING DEALER WHO KEPT IT FOR ONE AND A HALF DAYS AND COULD NOT DUPLICATE .THE SERVICE MANAGER TOLD ME HIS WIFE HAD THE SAME PROBLEM AND THEY ARE TRADING THERE VEHICLE IN ON THE SAME VEHICLE WITH A 6 CYLINDER. THE SERVICE WRITER WHO WROTE UP MY VEHICLE HAS THE SAME PROBLEM IN A DIFFERENT MODEL BUT HE JUST LIVES WITH IT. WE FEEL THIS VEHICLE HAS BECOME VERY UNSAFE AND WE DO NOT KNOW HOW TO GET THIS RESOLVED. I HAVE CONTACTED GM AGAIN AND THEY HAD NOT RESPONDED. WE HAVE FOUND SEVERAL OTHER PEOPLE EXPERIENCING THE SAME PROBLEM ON SEVERAL WEBSITES INCLUDING CHEVY FORUM . *TR
2012 CHEVROLET EQUINOX. CONSUMER WRITES IN REGARDS TO VEHICLE TRANSMISSION ISSUES. *SMD A MONTH AFTER PURCHASING THE VEHICLE, THE CONSUMER STATED THE VEHICLE WAS SLUGGISH, AS THE TRANSMISSION WAS NOT SHIFTING CORRECTLY. THE NEXT OCCURRENCE HAPPENED ON JANUARY 2, 2013. THE CONSUMER STATED BEFORE SHE COULD COME TO A COMPLETE ST…
Read full complaint
2012 CHEVROLET EQUINOX. CONSUMER WRITES IN REGARDS TO VEHICLE TRANSMISSION ISSUES. *SMD A MONTH AFTER PURCHASING THE VEHICLE, THE CONSUMER STATED THE VEHICLE WAS SLUGGISH, AS THE TRANSMISSION WAS NOT SHIFTING CORRECTLY. THE NEXT OCCURRENCE HAPPENED ON JANUARY 2, 2013. THE CONSUMER STATED BEFORE SHE COULD COME TO A COMPLETE STOP, THE VEHICLE STOPPED ON ITS OWN, AS IF SHE HIT A STONE WALL. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. ALSO, THE VEHICLE WOULD STALL, WHEN SLOWING DOWN. THERE WAS A NOISE COMING FROM THE FRONT END. THE DEALER CALLED THE CONSUMER TO LET HER KNOW, THEY ORDERED SOME BOLTS, SO THEY COULD BE BOLTED TO THE FRAME. ON ANOTHER OCCASION, WHILE THE CRUISE CONTROL WAS SET, THE CONSUMER APPLIED THE BRAKE, BUT THE VEHICLE DID NOT STOP. THE CONSUMER RETURNED TO THE DEALER, BECAUSE OF A GRINDING/GRATING NOISE COMING FROM THE VEHICLE. ON SEVERAL OCCASIONS, THE VEHICLE WENT INTO A HIGH RATE OF RATE SPEED AND APPLYING THE BRAKES, DID NOT STOP THE VEHICLE. UPDATED 03/27/14
Official recalls
316V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
11V511000 · Tires:pressure Monitoring And Regulating Systems
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.