IllustrationTHE CHECK ENGINE LIGHT IS ON AND STABILITY TRAC.CONES UP AND REDUCE ENGINE POWER AND CAN'T DRIVE TURN CAR OFF FOR A MIN RESTART AND IT GOES OFF BUT AS DRIVING COMES BACK ON.HAPPENED FIRST ON HIGHWAY.
2012 Chevrolet Equinox
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chevrolet Equinox do not stand out strongly from the model-year median of 382.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Equinox years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
5325–50K
11450–75K
11375–100K
137100–150K
30150K+
498 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 354 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports6 fire reports11 injury reports
Electrical System complaints
70 reportsWHEN MY VEHICLE IDOLS AT A STOP LIGHT, IT STARTS TO SHAKE AS IF IT WANTS TO CUT OFF. WHEN I TURN MY WHEEL THE INSIDE MAKES A SCREECHING SOUND.
MY VEHICLE KEEPS RED LINING AT 6000 RPMS AND BANGS INTO GEAR..BEEN AT THE DEALER MANY TIMES AND THEY SAY NOTHING'S WRONG BUT KEEP REPLACING PARTS...MY CAR IS STILL UNDER WARRANTY AND NOW THEY WANNA CHARGE ME FOR A TRANSMISSION I HAVE EVERY RECORD SINCE WE BOUGHT THE CAR THAT THIS PROBLEM HAS BEEN HAPPENING SINCE DAY 1...THE VEHI…
Read full complaint
MY VEHICLE KEEPS RED LINING AT 6000 RPMS AND BANGS INTO GEAR..BEEN AT THE DEALER MANY TIMES AND THEY SAY NOTHING'S WRONG BUT KEEP REPLACING PARTS...MY CAR IS STILL UNDER WARRANTY AND NOW THEY WANNA CHARGE ME FOR A TRANSMISSION I HAVE EVERY RECORD SINCE WE BOUGHT THE CAR THAT THIS PROBLEM HAS BEEN HAPPENING SINCE DAY 1...THE VEHICLE IS IN MOTIONS AND IT HAPPENS AT DIFFERENT SPEEDS I ALSO HAVE VIDEOS OF IT ACTING UP
THE CONTROL MODULE FAILED AND RESULTED IN HEADLIGHT GONE AT ~50K MILES. THE TRANSFER CASE WENT BAD AND THE CAR DID NOT MOVE AT ALL AT 64K MILES. CAN NOT BELIEVE THE POWERTRAIN GOT PROBLEM JUST AFTER THE WARRANTY EXPIRED.
MORE THAN ONCE WHILE DRIVING I HAVE GOTTEN POWER STEERING WARNINGS WHILE DRIVING, VEHICLE LOCKED UP IN THE PROCESS AND TOOK ALL OF MY MIGHT TO TURN AND GET TO THE SIDE OF THE ROAD. I HAVE CONSTANT OIL CHANGES AND WAS ISSUED A RECALL LETTER THAT THE OIL CENSOR WAS OFF LAST MAY AND THE DEALERSHIP SAID NO SUCH RECALL EXISTED. RECEN…
Read full complaint
MORE THAN ONCE WHILE DRIVING I HAVE GOTTEN POWER STEERING WARNINGS WHILE DRIVING, VEHICLE LOCKED UP IN THE PROCESS AND TOOK ALL OF MY MIGHT TO TURN AND GET TO THE SIDE OF THE ROAD. I HAVE CONSTANT OIL CHANGES AND WAS ISSUED A RECALL LETTER THAT THE OIL CENSOR WAS OFF LAST MAY AND THE DEALERSHIP SAID NO SUCH RECALL EXISTED. RECENTLY MY MECHANIC SAYS THE TIMING IS OFF, AN ENGINE POWER REDUCED WARNING HAS COME UP MORE THAN ONCE AND I HAVE STOPPED DRIVING THE CAR ALL TOGETHER FOR FEAR IS STOPS WITH MY CHILDREN AND MYSELF IN IT. THE FIRST TIME IT CAME ON TWO WEEKS AGO, I WAS AT AN INCREDIBLY BUSY INTERSECTION AND COULD NOT GO OVER 20 MPH, IT WAS AS IF I WAS DRIVING IN NEUTRAL. I TOOK MYSELF AND CHILDREN STRAIGHT TO THE MECHANIC. MY MECHANIC HAS INFORMED ME THAT THE AMOUNTS OF REPAIRS IS MORE THAN THE CAR MAY BE WORTH. I SEE SEVERAL COMPLAINTS WITH ISSUES MATCHING MY OWN AND CHEVROLET HAS DONE NOTHING. MY SCREEN RANDOMLY GOES OUT, THE RADIO GOES OUT, THE OIL CENSOR HAS STOPPED COMING ON, ENGINE LIGHTS COMES ON AND OFF. MY RADIATOR WAS RECENTLY REPLACED AS IT WAS RUSTED AND OVERHEATING THE CAR. A CAR THIS AGE SHOULD NOT HAVE THIS MANY ISSUES. THEY MUST LIE IN THE MANUFACTURING PROCESS.
THE BATTERY JUST DIED BUT THE SCARY PART WAS THAT THE DOOR DIDNT OPEN, NEITHER THE WINDOWS. I WAS LOCKED INSIDE MY CAR FOR APPROXIMATELY 10 MINUTES, ALSO THE KEY SWITCH DID NOT WORK, THE IGNITION KEY DID NOT COOPERATE IN RELEASING THE KEY.
I WAS DRIVING WITH MY WIFE AND DOG IN THE CAR LATE AT NIGHT IN COLD ICIEY CONDITIONS IN WYOMING. CAR BEGAN TO LOSE POWER DRAMATICALLY, STEERING WAS TIGHT, LIGHTS DIMMED, ALSO ENGINE STALLED AFTER A BIT A OF A SLIDE AND SAFELY PULLING OVER. WE COULD HAVE WRECKED IN THE MIDDLE OF NOWHERE IN THE ICEY COLD TEMPERATURES. ENGINE LIG…
Read full complaint
I WAS DRIVING WITH MY WIFE AND DOG IN THE CAR LATE AT NIGHT IN COLD ICIEY CONDITIONS IN WYOMING. CAR BEGAN TO LOSE POWER DRAMATICALLY, STEERING WAS TIGHT, LIGHTS DIMMED, ALSO ENGINE STALLED AFTER A BIT A OF A SLIDE AND SAFELY PULLING OVER. WE COULD HAVE WRECKED IN THE MIDDLE OF NOWHERE IN THE ICEY COLD TEMPERATURES. ENGINE LIGHT WAS ONE. TRACTION CONTROL LIGHT WAS ON. DASH READS 'SERVICE STABILITRAK' AND 'ENGINE POWER REDUCED !'. I COULD NOT GET THE CAR TO QUIT STALLING. I WASN'T SAFELY ABLE TO DRIVE IT. SO I THEN DID A ECU RESET. (DISCONNECT ECU AND BATTERY). SAT FOR 20 MINUTES. RESTARTED AND STILL SAME PROBLEM AFTER IT IDLED ROUGH FOR 5 MINUTES ROUGHLY. SO NEXT I DISCONNECTED THE ECU FUSE NUMBER 42 IN THE ENGINE FUSE BOX. I THEN TURNED KEY IN FIRST POSITION AND HAD SAME READINGS. NEXT I RESET THE CODE WITH MY OBD SCAN TOOL. REPEATED THE FUSE METHOD AGAIN... STILL SAME READING BUT WITHOUT STARTING THE MOTOR ONCE DURING THIS.... MY GUESS IS THE ECU IS VOLITIL TO THIS VEHICLE MOTOR CLASS. SERVICE BULLETIN STATES IT NEEDS A REFLASH. UPDATES FOR ENGINE OIL CONSUMPTION AS WELL. VERY INTERESTING AS WE CONSUME TOO MUCH OIL. I BELIEVE ALL MOTOR ISSUES IN OUR VEHICLE WE HAVE NOW (WORN PISTON RINGS ETC) ARE DUE TO A FAULTY ECU. THE FACT THAT THE WARNING SHOWS WHEN RESET AND NOT CONNECTED BECAUSE THE FUSE IS REMOVED PROVES TO ME THE ECU IS HAVING SOFTWARE ISSUE IN RENDERING PROPER DIAGNOSTICS AS WELL AS SAFE ENGINE PERFORMANCE. THIS INCIDENT TOOK PLACE IN AUGUST OF 2017. PROBLEM STILL PERSISTS IN DRY CLIMATES WHERE WE LIVE IN TEXAS. SAME ISSUES. SAME SYMPTOMS. NEW SENSORS, BATTERY, SPARK PLUGS AND OIL CHANGE REGULARLY. THIS VEHICLE IS UNSAFE AND WILL TAKE LIVES IF NOT RECALLED. IMAGINE DRIVING ON ICE WITH YOUR KIDS INSIDE AND THEN YOUR STEERING GOES OUT AND THE ENGINE LOSES POWER AND BRAKES.... IS THAT WHAT IT WILL TAKE?
SINCE I PURCHASED THE VEHICLE IN SEPTEMBER 2014 I HAVE HAD THREE INSTANCES WHERE THE CAR HAS STALLED WHILE DRIVING. TWICE IT WAS RELATED TO CAM SENSORS AND A CHECK ENGINE LIGHT CAME ON. THIS MOST RECENT TIME ON 1/5/2018 THE CAR WAS IDLING FUNNY AND STALLED OUT NO LIGHTS ON DASH. I JUST GOT AN OIL CHANGE ONE WEEK PRIOR. AS I WAS …
Read full complaint
SINCE I PURCHASED THE VEHICLE IN SEPTEMBER 2014 I HAVE HAD THREE INSTANCES WHERE THE CAR HAS STALLED WHILE DRIVING. TWICE IT WAS RELATED TO CAM SENSORS AND A CHECK ENGINE LIGHT CAME ON. THIS MOST RECENT TIME ON 1/5/2018 THE CAR WAS IDLING FUNNY AND STALLED OUT NO LIGHTS ON DASH. I JUST GOT AN OIL CHANGE ONE WEEK PRIOR. AS I WAS TRYING TO MAKE IT TO MY MECHANIC I HEARD AN AWFUL NOISE FROM THE ENGINE I HAD NEVER HEARD BEFORE. I JUST BARELY MADE IT TO THE MECHANIC. IT STALLED AT EVERY RED LIGHT ON MY WAY THERE....BUT WHEN I GOT THERE AND THEY HOOKED UP THE COMPUTER WITHOUT A CHECK ENGINE LIGHT ON A MESSAGE POPPED UP ON THE DASH THAT SAID LOW OIL PRESSURE. I HAD ONLY ONE QUART OF OIL IN THERE AND LIKE I SAID I JUST HAD THE OIL CHANGED ONE WEEK PRIOR. IN THE PAST I HAD TAKEN IT TO VALVOLINE IN BETWEEN OIL CHANGES FOR TOP OFFS BECAUSE THAT TICKING/RATTLING SOUND WHEN THE OIL IS LOW WAS HAPPENING. THEY RECENTLY TOLD ME THE EQUINOX IS NOTORIOUS FOR HIGH OIL CONSUMPTION AND OWNERS ARE HOPING FOR A RECALL. I HAVE CONSISTENTLY LOOKED FOR LEAKS BECAUSE THAT SEEMS TO BE MY LUCK WITH CARS. I NEVER SAW ONE UNTIL THE OTHER DAY AND IT APPEARS TO BE A REAR SEAL AS IT LEAKS ALMOST AT THE RATE OF AN OIL CHANGE DRAIN, BUT I WON'T ACTUALLY KNOW FOR SURE UNTIL THEY TAKE THE ENGINE APART. I AM BEYOND FRUSTRATED BECAUSE OF COURSE MY WARRANTY ON THE VEHICLE WAS UP ABOUT 3500 MILES AGO AND THIS IS CLEARLY A VERY EXPENSIVE REPAIR THAT ISN'T AT THE FAULT OF THE DRIVER BUT RATHER THE MANUFACTURER. ADDITIONALLY, I'M DRIVING A NEWBORN AND TWO OTHER CHILDREN AROUND IN A CAR THAT WILL RANDOMLY STALL OR POTENTIALLY COMBUST DUE TO ENGINE FAILURE AS A RESULT OF LACK OF OIL WITH NO WARNING FROM THE COMPUTER SYSTEM IN THE VEHICLE. THIS HAS HAPPENED IN THE VEHICLE MULTIPLE TIMES IN 3 YEARS ROUGHLY EVERY 25-30K MILES.
MY 2012 EQUINOX IS CURRENTLY DEAD AT A CHEVY DEALERSHIP. HERE IS THE HISTORY: ON OCTOBER 20, 2017 THE ENGINE OF MY 2012 EQUINOX BLEW AT 109,866 MILES WHEN KEY WAS TURNED. THE ENGINE BLEW BECAUSE WAS ABSOLUTELY NO OIL IN MY ENGINE AND NO LEAKS WERE PRESENT. I DID NOT SEE ANY LIGHTS SAYING THERE WAS AN OIL PROBLEM. IN FA…
Read full complaint
MY 2012 EQUINOX IS CURRENTLY DEAD AT A CHEVY DEALERSHIP. HERE IS THE HISTORY: ON OCTOBER 20, 2017 THE ENGINE OF MY 2012 EQUINOX BLEW AT 109,866 MILES WHEN KEY WAS TURNED. THE ENGINE BLEW BECAUSE WAS ABSOLUTELY NO OIL IN MY ENGINE AND NO LEAKS WERE PRESENT. I DID NOT SEE ANY LIGHTS SAYING THERE WAS AN OIL PROBLEM. IN FACT, MY DASHBOARD READ THAT I HAD ENOUGH OIL BEFORE THE NEXT OIL CHANGE WAS NEEDED. I RECENTLY PURCHASED AN OIL CHANGE ON SEPTEMBER 15, 2017 AT 108,500 MILES. I PROVIDED THE RECEIPT TO DEALERSHIP. I HAVE ALWAYS GOTTEN REGULAR OIL CHANGES. RECENTLY I HAD TO GET OIL CHANGES AND CHECKS MORE FREQUENTLY THAN GM RECOMMENDS DUE TO OIL MISSING FROM MY VEHICLE FOR NO APPARENT REASON OR EXPLANATION. BECAUSE I HAD TO PUT IN SO MUCH OIL, I WOULD OFTEN TAKE MY CAR IN FOR AN OIL CHANGE AT A LOCAL OIL CHANGE BUSINESS OR REQUEST MY FATHER TO CHANGE/ADD OIL INTO MY VEHICLE. I TRAVEL AROUND SE MI AND RELY ON MY VEHICLE FOR WORK, SO I DO NOT HAVE THE TIME OR EXTRA FUNDS TO MAKE AN APPOINTMENT TAKE MY VEHICLE INTO THE DEALERSHIP FOR MONTHLY OIL CHANGES AND TOP-OFFS (SEE BELOW). FEBRUARY 10, 2017 - OIL CHANGED MARCH 14, 2017 - OIL CHANGED APRIL 26, 2017 - OIL ADDED MAY 18, 2017 - OIL CHANGED JUNE 1, 2017 - OIL ADDED JUNE 30, 2017 - OIL CHANGED JULY 8, 2017 - OIL ADDED AUGUST 3, 2017 - OIL ADDED AUGUST 15, 2017 - OIL CHANGED AUGUST 28, 2017 - OIL ADDED SEPTEMBER 15, 2017 - OIL CHANGED AT 108,500 MILES OCTOBER 20, 2017 - ENGINE BLEW AT 109,866 MILES, WITHOUT ANY INDICATION THAT ENGINE NEEDED TO BE SERVICED, OIL WAS LOW, ETC. IN FACT, MY DASHBOARD SHOWS THAT I HAVE AMPLE OIL LIFE LEFT IN MY ENGINE BEFORE OIL NEEDS TO BE CHANGED. I HAVE A FEW RECEIPTS FOR THESE SERVICE DATES.
FIRST ONE WEEK AGO, THE CAR WAS SLOW TO TURN ON WHEN TURNING THE IGNITION AND ALL THE LIGHTS ON THE INSTRUMENT PANEL LITE UP WITH THE MESSAGE CHECK POWER STEERING. TONIGHT 8/11/17 THE CAR WILL NOT TURN OVER, BUT IT STILL HAS A WORKING HORN, LIGHTS. AND RADIO. CHECK ENGINE LIGHT COMES ON FOLLOWED BY SERVICE POWER STEERING, SER…
Read full complaint
FIRST ONE WEEK AGO, THE CAR WAS SLOW TO TURN ON WHEN TURNING THE IGNITION AND ALL THE LIGHTS ON THE INSTRUMENT PANEL LITE UP WITH THE MESSAGE CHECK POWER STEERING. TONIGHT 8/11/17 THE CAR WILL NOT TURN OVER, BUT IT STILL HAS A WORKING HORN, LIGHTS. AND RADIO. CHECK ENGINE LIGHT COMES ON FOLLOWED BY SERVICE POWER STEERING, SERVICE STABILTRACK MESSAGE, ELECTRIC WINDOWS WOULD NOT ROLL UP, SPEEDOMETER AND RPM GAUGES MOVE ALL THE WAY OVER AND BACK, AND ALL THE LIGHTS ON THE ELECTRIC PANEL ARE ON. ENGINE WILL NOT TURN ON.
Official recalls
316V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
11V511000 · Tires:pressure Monitoring And Regulating Systems
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.