NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
12 reportsClear category filter168,000 miles · Aug 3, 2026
EngineFuel System, Gasoline
The contact owns a 2011 Chevrolet Equinox. The contact stated that after starting the vehicle, there was an abnormal fuel odor inside the cabin of the vehicle, and the engine was rattling and vibrating abnormally. During the failure, there was no warning light illuminated. The cause of the failure was not yet determined. The man…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that after starting the vehicle, there was an abnormal fuel odor inside the cabin of the vehicle, and the engine was rattling and vibrating abnormally. During the failure, there was no warning light illuminated. The cause of the failure was not yet determined. The manufacturer and the local dealer were not yet contacted. No further information was available. The failure mileage was 168,000.
NHTSA ODI #11754526
90,000 miles · Jul 15, 2025
EngineFuel System, Gasoline
The contact owns a 2011 Chevrolet Equinox. The contact stated while driving 70 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated that once the fuel gauge displayed that 1/4 tank of gasoline was available, the vehicle jerked, and there was an abnormal sound c…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated while driving 70 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated that once the fuel gauge displayed that 1/4 tank of gasoline was available, the vehicle jerked, and there was an abnormal sound coming from the engine with the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the pistons had failed, and the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 90,000.
NHTSA ODI #11673817
100,000 miles · Jul 14, 2025
Fuel System, Gasoline
The contact owns a 2011 Chevrolet Equinox. The contact stated that while his wife was driving at various speeds, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle jerked, and an abnormal sound was heard coming from the engine. The check engine warning light was illumina…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that while his wife was driving at various speeds, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle jerked, and an abnormal sound was heard coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the pistons had failed, and the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.
NHTSA ODI #11673471
80,000 miles · Dec 23, 2019
Electrical SystemEngineFuel System, Gasoline
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING AT LOW SPEEDS, THE BRAKE PEDAL WAS APPLIED; HOWEVER, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP, CAMSHAFT, AND BATTERY NEEDED TO BE REPLACED. THE LOCAL DEALER AN…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING AT LOW SPEEDS, THE BRAKE PEDAL WAS APPLIED; HOWEVER, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP, CAMSHAFT, AND BATTERY NEEDED TO BE REPLACED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11290947
81,000 miles · Feb 25, 2014
EngineFuel System, Gasoline
I HAVE HAD PROBLEMS WITH MY 2011 CHEVROLET EQUINOX SINCE THE DAY I GOT IT BUT YESTERDAY WAS THE WORST. THE ENGINE ALL OF A SUDDEN STALLED ON THE HIGHWAY AND I HAD TO PULL OFF THE ROAD. I JUST HAD IT IN THE SHOP LAST WEEK AND HAD THE FUEL PUMP AND TIMING CHAIN REPLACED. I WAS ABLE TO GET MY CAR HOME ONLY ABLE TO DRIVE 40 MPH. …
Read full complaint
I HAVE HAD PROBLEMS WITH MY 2011 CHEVROLET EQUINOX SINCE THE DAY I GOT IT BUT YESTERDAY WAS THE WORST. THE ENGINE ALL OF A SUDDEN STALLED ON THE HIGHWAY AND I HAD TO PULL OFF THE ROAD. I JUST HAD IT IN THE SHOP LAST WEEK AND HAD THE FUEL PUMP AND TIMING CHAIN REPLACED. I WAS ABLE TO GET MY CAR HOME ONLY ABLE TO DRIVE 40 MPH. THIS MORNING I WAS GOING TO TRY TO GET IT TO WORK TO BE CLOSER TO SOMEONE WHO COULD CHECK THE CODE OUT ON IT BUT AS I WAS GOING DOWN THE ROAD IT COMPLETELY STALLED OUT AND I BARELY GOT OFF THE ROAD BEFORE THE ENGINE CUT OUT ALL TOGETHER. I HAVE READ NUMEROUS FORUMS OF CUSTOMER WITH THE SAME VEHICLE HAVING THE SAME PROBLEM. THIS IS A SAFETY ISSUE AND GM NEEDS TO ADDRESS IT. THE SHOP IS SAYING THAT IF IT'S THE FUEL THROTTLE BODY WHICH IS WHAT I SUSPECT THEY WILL NOT COVER IT UNDER WARRANTY. FROM WHAT I UNDERSTAND THERE WAS A BULLETIN PUT OUT ON THIS ISSUE AND IT WAS COVERED FOR AWHILE ON THE POWERTRAIN WARRANTY BUT THEY PULLED THE BULLETIN AND NO LONGER COVER IT. I NEED HELP. GM KNOWS THEY HAVE ISSUES WITH THIS VEHICLE BUT THEY WILL NOT DO ANYTHING ABOUT IT. *TR
NHTSA ODI #10565822
48,000 miles · Nov 16, 2013
Electrical SystemEngineFuel System, Gasoline
CHECK ENGINE LIGHT CAME ON, HAD AUTOZONE RUN ON COMPUTER, CAME BACK CODE P0011, FOUND RECALL ON CODE IN 2011(11195A), CAR IS DOING SAME THING AS RECALL STATED, I CALLED GM AND THEY SAID IT WAS NOT PART OF RECALL, I EXPLAINED PROBLEM AND THEY WOULD NOT TELL IF PART WAS UNDER WARRANTY, ALL THEY SAID WAS TAKE TO DEALER. GM TOLD M…
Read full complaint
CHECK ENGINE LIGHT CAME ON, HAD AUTOZONE RUN ON COMPUTER, CAME BACK CODE P0011, FOUND RECALL ON CODE IN 2011(11195A), CAR IS DOING SAME THING AS RECALL STATED, I CALLED GM AND THEY SAID IT WAS NOT PART OF RECALL, I EXPLAINED PROBLEM AND THEY WOULD NOT TELL IF PART WAS UNDER WARRANTY, ALL THEY SAID WAS TAKE TO DEALER. GM TOLD ME SO ES VINS WERE RECALLED, BUT NOT ALL, COULDN'T TELL ME WHY THIS ONE WAS NOT RECALLED EVEN THOUGH IT IS DOING SAME THING. *TR
NHTSA ODI #10552559
27,381 miles · Oct 17, 2013
EngineFuel System, Gasoline
I RECEIVED A LETTER FROM CHEVROLET (JULY 2013) EXPLAINING THAT THERE ARE ISSUES WITH NUMEROUS ENGINE PARTS, PARTICULARLY THE FUEL PUMP AND BALANCE CHAIN. CHEVROLET STATED THAT THEY ARE EXTENDING MY POWER TRAIN WARRANTY TO 10 YEARS OR 120,000 MILES, WHICHEVER OCCURS FIRST. I HAVE HAD THE BALANCE CHAIN REPLACE TWICE ALREADY. I AM …
Read full complaint
I RECEIVED A LETTER FROM CHEVROLET (JULY 2013) EXPLAINING THAT THERE ARE ISSUES WITH NUMEROUS ENGINE PARTS, PARTICULARLY THE FUEL PUMP AND BALANCE CHAIN. CHEVROLET STATED THAT THEY ARE EXTENDING MY POWER TRAIN WARRANTY TO 10 YEARS OR 120,000 MILES, WHICHEVER OCCURS FIRST. I HAVE HAD THE BALANCE CHAIN REPLACE TWICE ALREADY. I AM CONCERNED THAT THE CONDITION WITH THE FUEL PUMP COULD CAUSE A FIRE OR SERIOUS ENGINE DAMAGE. THE LETTER FROM CHEVROLET STATES: "IN ADDITION, THE FUEL PUMP PLUNGER SHAFT SEAL MAY WEAR AND ALLOW FUEL TO LEAK INTO THE CRANKCASE, WHICH WOULD ILLUMINATE THE MALFUNCTION INDICATOR LIGHT. THIS CAN CAUSE RUN-ON AND/OR THE ENGINE TO RUN ROUGH". I WOULD ASSUME THAT THE ENGINE AND OIL IN THE EQUINOX WOULD REACH VERY HIGH TEMPERATURES WHEN THEY HAVE BEEN OPERATED FOR A PERIOD OF TIME. THE INTRODUCTION OF FUEL INTO THE CRANKCASE AND ENGINE COULD POSSIBLY IGNITE. ALSO THE FAILURE OF THE BALANCE CHAIN COULD CAUSE ENGINE FAILURE UNDER SOME DRIVING CONDITIONS THAT COULD LEAVE THE CAR INOPERABLE, CAUSING AN ACCIDENT. I BELIEVE CHEVY SHOULD BE HELD ACCOUNTABLE FOR THE DEFECTIVE PARTS AND POTENTIAL DANGER THEIR FAILURE COULD CAUSE. CHEVROLET SHOULD BE DIRECTED TO ISSUE A RECALL TO REPLACE THESE DEFECTIVE PARTS.. *TR
NHTSA ODI #10548313
11,000 miles · May 3, 2013
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE STALLED AND HESITATED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. A DIAGNOSTIC WAS PERFORMED BY A DEALER, WHO STATED THAT THE HIGH PRESSURE FUEL PUMP WAS LEAKING GASOLINE INTO THE MOTOR OIL. THE VEHICLE WAS REPAIRED. THE DETAILS OF THE…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE STALLED AND HESITATED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. A DIAGNOSTIC WAS PERFORMED BY A DEALER, WHO STATED THAT THE HIGH PRESSURE FUEL PUMP WAS LEAKING GASOLINE INTO THE MOTOR OIL. THE VEHICLE WAS REPAIRED. THE DETAILS OF THE REPAIR WERE UNKNOWN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 11,000. THE CURRENT MILEAGE WAS 11,100. UPDATED 7/15/13 *CN
NHTSA ODI #10510514
6,590 miles · Jan 9, 2012
Engine And Engine CoolingFuel System, Gasoline
CONCERNING 2011 CHEVY EQUINOX 4CYL, ON STARTUP, THERE WILL BE A LOUD KNOCKING NOISE, SOUNDS AS IF THERE IS NO OIL IN THE ENGINE, SOUND LASTS FROM 1-5 SECONDS THEN GOES AWAY. MOST OF THE TIMES IT WILL DO IT ON FIRST START-UP OF THE DAY BUT THERE HAVE BEEN A FEW TIMES WHERE IT HAS DONE IT MULTIPLE TIMES IN THE SAME DAY. CAR HAS BE…
Read full complaint
CONCERNING 2011 CHEVY EQUINOX 4CYL, ON STARTUP, THERE WILL BE A LOUD KNOCKING NOISE, SOUNDS AS IF THERE IS NO OIL IN THE ENGINE, SOUND LASTS FROM 1-5 SECONDS THEN GOES AWAY. MOST OF THE TIMES IT WILL DO IT ON FIRST START-UP OF THE DAY BUT THERE HAVE BEEN A FEW TIMES WHERE IT HAS DONE IT MULTIPLE TIMES IN THE SAME DAY. CAR HAS BEEN IN THE SHOP 4 TIMES FOR THE SAME ISSUE, THEY HAVE REPLACED THE CAM ACTUATOR AND SOLENOID, WHICH I HAD TO BRING BACK AGAIN (#5) BECAUSE THE GASKET WAS SEATED INCORRECTLY AND WAS LEAKING OIL ON MY DRIVEWAY. SERVICE ACCOUNT MANAGER HAS HEARD THE NOISE THE FIRST TIME I BOUGHT IT IN AND THE LAST TIME IT WAS IN, BOTH TIMES THE SOUND LASTED ABOUT 1 SECOND, BUT IT WAS ENOUGH THAT BOTH OF US HEARD IT, NOT AS LONG AS THE TIMES WHEN STARTING AT HOME, PROBABLY BECAUSE THOSE WERE ON FIRST START-UP OF THE DAY WHEREAS THE TIMES AT THE DEALERSHIP IT WAS EITHER ALREADY RUNNING OR WAS STARTED A FEW TIMES THAT DAY. THEY ALSO REPLACED A HIGH PRESSURE PUMP INSULATOR COVER FOR A TICKING NOISE THAT HAD NOTHING TO DO WITH THE KNOCKING NOISE. ALSO HAVE MENTIONED TO THEM THAT WHILE ACCELERATING (FROM DEAD STOP AT TRAFFIC LIGHT, GOING UP ON-RAMPS TO HIGHWAYS AND MERGING INTO HIGH-SPEED TRAFFIC), THE RPM'S WILL DROP DOWN TO ZERO AND CAR ALMOST STALLS THEN IT KICKS BACK INTO GEAR (UP TO 6500 RPMS), THIS HAS HAPPENED AT LEAST 5 TIMES, AND THEY COULDN'T DUPLICATE THAT PROBLEM EITHER. I HAVE TRIED ALL 3 GRADES OF GASOLINE AND ISSUES WERE PRESENT WITH ALL 3. AT THIS POINT IT HAS ALREADY BEEN IN 4 TIMES FOR THE SAME ISSUE AND I FEEL AS THOUGH ONE DAY THE ENGINE WILL HAVE MORE SERIOUS ISSUES BECAUSE OF THESE ISSUES.
NHTSA ODI #10443129
6,888 miles · Oct 18, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
I WAS DRIVING MY EQUINOX OUT OF A PARKING LOT AND IT STALLED, I RESTARTED IT, DROVE IT UP THE ROAD AND WAS GOING ABOUT 30 MPH AND IT STALLED AGAIN, I TURNED AROUND BACK TO THE PARKING LOT AND IT HAPPENED 2 MORE TIMES. I HAVE ALSO BE GETTING VERY POOR GAS MILEAGE (15-18MPH). THE CAR WAS TOWED TO THE DEALER AND THEY SAID THEY RESE…
Read full complaint
I WAS DRIVING MY EQUINOX OUT OF A PARKING LOT AND IT STALLED, I RESTARTED IT, DROVE IT UP THE ROAD AND WAS GOING ABOUT 30 MPH AND IT STALLED AGAIN, I TURNED AROUND BACK TO THE PARKING LOT AND IT HAPPENED 2 MORE TIMES. I HAVE ALSO BE GETTING VERY POOR GAS MILEAGE (15-18MPH). THE CAR WAS TOWED TO THE DEALER AND THEY SAID THEY RESET THE ELECTRICAL CONTROL MODULE BECAUSE IT HAD ERRORS ON IT. THIS HAS THUS FAR RESOLVED THE CAR FROM STALLING BUT HAS NOT IMPROVED THE GAS MILEAGE. *TR
NHTSA ODI #10430729
Official recalls
3Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Dec 15, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC SRX, CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES. THE DRIVER AND /OR FRONT PASSENGER SAFETY BELT BUCKLE ANCHOR MAY FRACTURE AND SEPARATE NEAR THE SEAT ATTACHMENT IN A VEHICLE CRASH.
Consequence & remedy
Consequence: THE SAFETY BELT SYSTEM MAY NOT RESTRAIN THE OCCUPANT(S) AS DESIGNED AND COULD INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL MODIFY THE PASSENGER AND/OR THE DRIVER SAFETY BELT BUCKLES AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 18, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration