NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
34 reportsClear category filter117,000 miles · Aug 28, 2026
Engine And Engine Cooling
The contact owns a 2011 Chevrolet Equinox. The contact stated that while the mother was driving, the vehicle suddenly stalled. The vehicle was towed to the residence and was later diagnosed by an independent mechanic, who discovered metal shavings in the engine oil pan and informed the contact that the engine had seized and need…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that while the mother was driving, the vehicle suddenly stalled. The vehicle was towed to the residence and was later diagnosed by an independent mechanic, who discovered metal shavings in the engine oil pan and informed the contact that the engine had seized and needed to be replaced. The contact stated that prior to the engine failure, the vehicle experienced excessive oil consumption over a 14-month period. The local dealer was notified of the failure, but no assistance was provided. The manufacturer was not notified of the failure. The failure mileage was 117,000.
NHTSA ODI #11760362
165,000 miles · Jan 20, 2026
Engine And Engine Cooling
The contact owns a 2011 Chevrolet Equinox. The contact stated that the vehicle was consuming an excessive amount of engine oil. While driving at various speeds, there was a misfire coming from the engine while attempting to accelerate. The failure occurred while attempting to accelerate from a stop. There was no warning light il…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that the vehicle was consuming an excessive amount of engine oil. While driving at various speeds, there was a misfire coming from the engine while attempting to accelerate. The failure occurred while attempting to accelerate from a stop. There was no warning light illuminated. The vehicle was taken to a certified mechanic, who diagnosed that a shaft inside the engine had failed, and the engine needed to be replaced. The engine was replaced with a rebuilt engine; however, the failure reoccurred approximately 4 months after the engine was replaced. The vehicle was returned to the mechanic, who diagnosed and determined that the same failure had reoccurred. The engine valves and exhaust were cleaned; however, the failure persisted. The contact stated that smoke was entering the cabin of the vehicle and out of the exhaust pipe while the heater was activated. The vehicle was returned to the mechanic, who then diagnosed that the engine needed to be replaced another time. The vehicle was repaired again. The manufacturer was not informed of the failure. The failure mileage was approximately 165,000.
NHTSA ODI #11712022
150,000 miles · May 1, 2023
Engine And Engine Cooling
The contact owns a 2011 Chevrolet Equinox. The contact stated that while coming to a complete stop, the vehicle lost motive power. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed the vehicle with a catalytic converter failure. The vehicle was not repaired. The manu…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that while coming to a complete stop, the vehicle lost motive power. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed the vehicle with a catalytic converter failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
NHTSA ODI #11519885
107,000 miles · Feb 9, 2022
Engine And Engine Cooling
The contact owns a 2011 Chevrolet Equinox. The contact stated that while the vehicle was parked outside of the dealership, the contact heard an abnormal ticking sound coming from under the front hood of the vehicle. The contact notified the dealer of the issue and was informed that the noise would go eventually cease after drivi…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that while the vehicle was parked outside of the dealership, the contact heard an abnormal ticking sound coming from under the front hood of the vehicle. The contact notified the dealer of the issue and was informed that the noise would go eventually cease after driving the vehicle for a while. The issue persisted and the vehicle was taken back to the dealer. The vehicle was inspected and the contact was informed that the timing chain and assembly needed to be replaced. The vehicle was repaired. The contact stated that a year later while driving at an undisclosed speed, the failure recurred and the vehicle shuddered and lost motive power. There was no warning light illuminated. The vehicle was first towed to the residence and then towed to the dealer to be diagnosed. The contact was informed that the failure was caused by excessive oil consumption related to the timing chain assembly repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 107,000.
NHTSA ODI #11451183
110,000 miles · Jun 3, 2021
Engine And Engine Cooling
The contact owns a 2011 Chevrolet Equinox. The contact stated that the vehicle had been diagnosed with excessive oil consumption by an independent mechanic. The contact stated that while driving at various speeds, the vehicle stalled without warning while depressing the accelerator pedal. The manufacturer was notified of the fai…
Read full complaint
The contact owns a 2011 Chevrolet Equinox. The contact stated that the vehicle had been diagnosed with excessive oil consumption by an independent mechanic. The contact stated that while driving at various speeds, the vehicle stalled without warning while depressing the accelerator pedal. The manufacturer was notified of the failure and informed him that the failure was a known issue however, the warranty on the vehicle had expired. The contact was then transferred to the NHTSA by the manufacturer. The vehicle was not repaired. The failure mileage was approximately 110,000
NHTSA ODI #11419542
58,000 miles · Jan 11, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING 40 MPH, THE PCV FAILED AND CAUSED THE REAR SEAL TO BLOW OUT. THE VEHICLE HAD TO BE TOWED. THE DEALER (PADDOCK CHEVROLET, 3232 DELAWARE AVE, KENMORE, NY 14217) STATED THAT THE REAR SEAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPLACED. THE MANUFACTURER WAS ALSO CONTA…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING 40 MPH, THE PCV FAILED AND CAUSED THE REAR SEAL TO BLOW OUT. THE VEHICLE HAD TO BE TOWED. THE DEALER (PADDOCK CHEVROLET, 3232 DELAWARE AVE, KENMORE, NY 14217) STATED THAT THE REAR SEAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPLACED. THE MANUFACTURER WAS ALSO CONTACTED AND WAS UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 58,000. *TT *TR
NHTSA ODI #11062195
93,000 miles · Dec 27, 2017
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED. THE FAILURE WAS INTERMITTENT. FRIENDLY CHEVROLET IN SPRINGFIELD, ILLINOIS WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED. THE FAILURE WAS INTERMITTENT. FRIENDLY CHEVROLET IN SPRINGFIELD, ILLINOIS WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.
NHTSA ODI #11056956
133,000 miles · Dec 7, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER LATER, BUT WAS NOT DIAGNOSED OR RE…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER LATER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000. UPDATED 01/26/2017*CT *CN
NHTSA ODI #10933772
28,000 miles · Sep 20, 2013
Engine And Engine CoolingPower Train
RECEIVED NOTICE FROM CHEVROLET 2.4L ENGINE MAY CONTAIN 2 PARTS SUBJECT TO PREMATURE FAILURE DUE TO WEAR. FAILURE OF EITHER PART HAS POTENTIAL TO RENDER VEHICLE INOPERABLE AND CAUSE MAJOR ENGINE DAMAGE. CHEVROLET'S PROPOSED FIX IS FOR OWNER TO DRIVE VEHICLE TO FAILURE AND THEN DELIVER IT TO A DEALER AND THEY WILL REPAIR AT NO CHA…
Read full complaint
RECEIVED NOTICE FROM CHEVROLET 2.4L ENGINE MAY CONTAIN 2 PARTS SUBJECT TO PREMATURE FAILURE DUE TO WEAR. FAILURE OF EITHER PART HAS POTENTIAL TO RENDER VEHICLE INOPERABLE AND CAUSE MAJOR ENGINE DAMAGE. CHEVROLET'S PROPOSED FIX IS FOR OWNER TO DRIVE VEHICLE TO FAILURE AND THEN DELIVER IT TO A DEALER AND THEY WILL REPAIR AT NO CHARGE. OWNERS SHOULD NOT BE SUBJECTED TO THE PERSONAL SAFETY RISK OF BEING STRANDED ON THE SIDE OF THE ROAD LATE AT NIGHT OR ON SOME DESERTED HIGHWAY. CHEVROLET'S PROPOSED SOLUTION IS TOTALLY UNACCEPTABLE; THE DEFECTIVE PARTS SHOULD BE REPLACED BEFORE SOMEONE IS HURT WHILE WAITING FOR HELP. *TR
NHTSA ODI #10544609
16,000 miles · Jul 2, 2013
Engine And Engine CoolingStructure
LET ME TAKE 5 MINUTES OF YOUR TIME TO TELL YOU A STORY THAT MIGHT BE ALSO EXPERIENCED BY OTHER EQUINOX DRIVERS. ABOUT 18 MONTHS AGO, EVERY TIME I WOULD GET INTO MY WIFE'S EQUINOX, WHICH IS UNDER MY NAME, I WOULD START A FIGHT WITH HER, BECAUSE THE CAR WOULD SMELL HUMID AND WILL PROMPT ASTHMA ATTACKS. ESPECIALLY WHEN SHE WOULD …
Read full complaint
LET ME TAKE 5 MINUTES OF YOUR TIME TO TELL YOU A STORY THAT MIGHT BE ALSO EXPERIENCED BY OTHER EQUINOX DRIVERS. ABOUT 18 MONTHS AGO, EVERY TIME I WOULD GET INTO MY WIFE'S EQUINOX, WHICH IS UNDER MY NAME, I WOULD START A FIGHT WITH HER, BECAUSE THE CAR WOULD SMELL HUMID AND WILL PROMPT ASTHMA ATTACKS. ESPECIALLY WHEN SHE WOULD PICK ME UP FROM THE AIRPORT, THE CAR WOULD SMELL LIKE AN OLD WET-RUG. I WOULD TURN THE AIR CONDITIONER HIGHER AND THE SMALL WOULD BE WORST, SO I WOULD GET MAD AT HER AND ASKED HER TO SEND THE CAR TO THE CLEANING AND ALSO ASKED THE ORALLY CHEVROLET TO CHANGE THE AIR FILTERS. FOR 18 MONTHS MY WIFE AND KIDS WOULD SMELL THE SAME CHEMICAL, NOT KNOWING THAT IT WAS CAUSED BY A LEAK FROM THE AIR COMPRESSOR, WHICH WAS LETTING POISON FREON GAS INTO THE SUV. PLUS I WOULD GET SO ANGRY AT MY WIFE FOR THE HUMID SMELL NOT KNOWING THAT IT WAS NOT HER FAULT. I HARDLY WOULD DRIVE THE EQUINOX, BECAUSE THE MOMENT I WOULD TURN THE AIR, I WOULD STOP BREATHING AS THE GAS WILL SPARK AN ASTHMA ATTACK. FINALLY, OUR AIR-SYSTEM STOPPED WORKING AND WE TOOK THE SUV TO THE SHOP WHERE THE CONDENSER HAS BEEN REPLACE AND THE SMELL AS AN OLD-RUG AND ASTHMA ATTACKS ARE NOT GONE. MY WORRY, FOR 18 MONTHS, MY KIDS AND WIFE GO TO BREATHE FREON A HIGHLY TOXIC GAS, WHICH GAVE ME ASTHMA ATTACKS. I WOULD LIKE IF MORE DRIVERS ARE SENDING COMPLAINTS ABOUT FREON GETTING INSIDE THEIR EQUINOX. THIS IS A HEALTH ISSUE THAT SHOULD NOT HAPPENED TO CONSUMERS. *TR
NHTSA ODI #10522865
Official recalls
3Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Dec 15, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC SRX, CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES. THE DRIVER AND /OR FRONT PASSENGER SAFETY BELT BUCKLE ANCHOR MAY FRACTURE AND SEPARATE NEAR THE SEAT ATTACHMENT IN A VEHICLE CRASH.
Consequence & remedy
Consequence: THE SAFETY BELT SYSTEM MAY NOT RESTRAIN THE OCCUPANT(S) AS DESIGNED AND COULD INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL MODIFY THE PASSENGER AND/OR THE DRIVER SAFETY BELT BUCKLES AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 18, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration