2016 Chevrolet Cruze

The contact owns a 2016 Chevrolet Cruze. The contact stated that while driving at various speeds, an abnormal burning odor was coming from the vehicle. The contact stated that while driving 40 MPH, the temperature gauge indicated that the engine was hot(H). The contact pulled over, added water to the coolant reservoir, and the vehicle returned to normal operation. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 104,000.

My tire pressure sensor keeps coming on even after I had it worked on. 3 of them shows the pressure level but one shows 2 lines but no pressure level but there’s air in the tire. The other problem I’m having is the check engine light is on. Please advise if any issues are recalls or do I need to take my car to a service center. Thank you

The turbo has gone out twice, it was replaced under an extended warranty policy and it has gone out again and is out of warranty, also the plastic intake manifold has gone bad again. also there is a plastic piece that comes off the engine and distributes coolant to the heater core etc...it has gone bad as well and is common on all 1.4 turbos..

I was driving the car, stopped at a light took my foot off the brake started to move and the car completely shut off. No warning lights went on. I had to start the car again. I took the car to a local dealership to be looked at. They pulled the codes, nothing showed up. I did an internet search for a possible cause, sent my search results to the dealership and I asked them to check the fuel system, they found a bad injector. They then cleaned the fuel system and replaced the bad injector.

Purchased a 2016 Chevrolet Cruze on [XXX]. [XXX]. As of July 26th I paid $862 on repairs for the car to be smoking this morning on my way to work [XXX]. In total I’ve spent Almost or close to $2,000 in car repairs. This purchase was for my 17 year old daughter as a graduation present and for college. She was driving and car started to run hot and cut off in a busy intersection. She was unable to take the car to North Carolina. The owner blocked me and the staff haven’t been accommodating since this process. Nor will they look at the car. This has put me in a financial burden and the safety conditions this vehicle is under. And damage this could have cause my daughter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I HAVE A 2016 CHEVROLET CRUZE AND THE TURBOCHARGER INTERCOOLER HOSE BASICALLY BROKE FROM WHERE THE END OF THE HOSE STARTS AND A LITTLE BIT DOWN IN THE MIDDLE AREA OF THE END PART OF THE HOSE. AND THIS CAUSED MY ENGINE'S POWER TO BE REDUCED INMENSLY. TO THE POINT THAT I HAD MY FOOT PRESSING ALL THE WAY DOWN ON THE ACCELERATOR AND IT COULD NOT GO ANY FURTHER DOWN, AND MY CAR WAS MOVING SLOWER THAN A TURTLE, AND THIS IS NOT AN EXAGGERATION! AND ALSO, AT TIMES WHEN I HAVE BEEN AT A RED LIGHT MY CAR TURNS OFF. ONE TIME MY CAR TURNED OFF WHILE I WAS DRIVING ON THE STREET WITH CARS BEHIND ME. LUCKILY, I WAS ABLE TO PULL INTO A SHOPPING CENTER. AND THE AIR CONDITIONER IS ALSO FAILING BECAUSE I KEEP PUTTING FREE ON SO IT CAN BE COLDER AND ALL THAT COMES OUT IS HOT AIR. I DID NOT KNOW THAT THIS INTERCOOLER HOSE WAS A MAJOR PART OF MY VEHICLE'S FUNCTION. ALSO, THE TRACTION LIGHT CAME ON, WHEN I ALREADY HAD IT OFF. IF CHEVROLET CRUZE OWNERS DO NOT KNOW ABOUT THIS ISSUE, THEY NEED TO KNOW. BECAUSE THIS ISSUE COULD EVENTUALLY MESS UP THE ENTIRE MOTOR AND POSSIBLE BLOW IT OUT. WHICH WE ALL KNOW A NEW MOTOR IS VERY EXPENSIVE

Defouw Chevrolet was negligent in performing the proper repairs per a GM service bulletin and special coverage. They refused to provide service, falsely claimed that I refused diagnostic, misdiagnosed the vehicle, replaced the wrong part, and were extremely rude and misogynistic. Additionally, they claim the issues were pre-existing while lacking any evidence. As a result, the vehicle now needs $6,400 in repairs, and neither GM nor Defouw will compensate us. Additionally, we have incurred $1,000 in towing costs, among other expenses.

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving on several occasions at various speeds, the steering wheel pulled to the left forcibly. The contact also stated that the vehicle was oversteered, and the wheel made the vehicle move in a straight line. The vehicle was taken to an independent mechanic where it was diagnosed that the inner tie rod had separated from the steering gear and both inner tie rods and tires needed to be replaced. The contact associated the failure with NHTSA Campaign Number: 15V442000 (Steering). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 61,000.

Component or System Failed/Malfunctioned: The turbocharger has been identified by a GM service center as the component that failed or malfunctioned. It is available for inspection upon request at the service center where the diagnosis was made. Safety Risk: The safety of myself and others was compromised due to the vehicle stalling unexpectedly while driving. This resulted in potential rear-end collisions, as well as the inability to accelerate, posing a risk in traffic situations. Confirmation by Dealer or Independent Service Center: Yes, the issue has been confirmed by a GM service center where the turbocharger was diagnosed as the problem. They provided a repair estimate of $2,170 for the turbocharger replacement. Inspections by Manufacturer, Police, Insurance, etc.: The vehicle has been inspected by a GM service center, but it has not been inspected by police, insurance representatives, or other independent parties beyond the GM service center. Warning Lamps, Messages, Symptoms: Prior to the vehicle stalling, warning messages such as "Service Stabilitrak" appeared on the dashboard. These messages were accompanied by engine shaking, and the car did not respond to acceleration attempts. These symptoms first appeared just before each incident of stalling.

On [XXX], the right front passenger side control arm/ball joint broke as my daughters were driving home. The car was in motion on a major street in Kansas City, KS when the control arm/ball joint broke. My daughter was in the right-hand lane when it broke as the car was in motion. The front of the car forcefully propelled in the air, landed, and jerked my daughter into the side walk. Afterwards, she fought the car over to the left-hand turn lane to stop in a somewhat safer spot on a major street. My oldest daughter driving suffered neck injuries from the seatbelt and my youngest daughter bumped her head. Both were hurt. An independent mechanic diagnosed the issue as well as Hendrick Chevrolet in Shawnee Mission Kansas. The parts are available for inspection. Hendrick Chevrolet failed to properly diagnose this issue when my car was in their care and service department on 06/14/24. I paid for an inspection but Hendrick Chevrolet's technician failed to record play in the broken wheel and if the car was in need of an alignment. This is unacceptable behavior considering the technician had both front tires off to inspect the brakes and was paid to perform a complete inspection on my car as described in Chevy's inspection literature provided by the dealership. He also provided an incorrect brake pad measurement. Through several Chevrolet/Chevy Cruze online forums, Cruze owners have asked several questions and recorded several comments regarding having a broken control arm and having to replace the ball joint bolt. Also, recalls were previously issued with other GM vehicles having a right-front passenger side defective control arm, which potentially could be a GM fabrication issue with control arms. No warning lamps, noises, or messages alerted to this issue. This would have been a fatal incident involving my daughters and other drivers if it occurred on the highway at a higher rate of speed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)