IllustrationI HAVE TO PUSH HARDER ON THE BRAKE PEDAL TO BRAKE ON TIME OR BRAKE AT ALL. TO NOT REAR END THE VEHICLE IN FRONT OF ME AND CAUSE AN ACCIDENT.
2012 Chevrolet Cruze
Owner reports · Recalls · Investigations
More warning signs than most Cruze years
Owner complaints for the 2012 Chevrolet Cruze are substantially higher than the model-year median of 250.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cruze years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1570–25K
16525–50K
15950–75K
10875–100K
113100–150K
14150K+
716 reports with mileage · 149 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 268 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 196 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
62 crash reports18 fire reports21 injury reports
What owners actually said
865 reportsBURNING OIL SMELL STARTED AFTER AN OIL CHANGE. I HAVE REPLACED THE INTAKE TUBING THAT LEADS IN THE TURBO BECAUSE WHEN I REPLACED THE THROTTLE POSITION SENSOR IN THE TURBO AREA, THERE WAS OIL IN THE TURBO INTAKE. IT HAS LOST SOME POWER SINCE I STARTED EXPERIENCING THE BURNING SMELL. IT NOW SMELLS LIKE PLASTIC BURNING SINCE REP…
Read full complaint
BURNING OIL SMELL STARTED AFTER AN OIL CHANGE. I HAVE REPLACED THE INTAKE TUBING THAT LEADS IN THE TURBO BECAUSE WHEN I REPLACED THE THROTTLE POSITION SENSOR IN THE TURBO AREA, THERE WAS OIL IN THE TURBO INTAKE. IT HAS LOST SOME POWER SINCE I STARTED EXPERIENCING THE BURNING SMELL. IT NOW SMELLS LIKE PLASTIC BURNING SINCE REPLACING THE INTAKE TUBING/GASKET.
EVEN AFTER FREE REPAIR DUE TO BEING COVERED UNDER WARRANTY, THE NEW PCV VALVE AND COVER ARE LEAKING AGAIN. ENGINE IDLES ROUGHLY, BOTH IN PARK AND IN DRIVE. THIS IS A KNOWN ISSUE WITH CHEVROLET CRUZE, BUT MY VIN IS NOT PART OF THE RECALL. MAIN ERROR CODE P0171- BANK 1 SYSTEM TOO LEAN- IS BEING PICKED UP (CHECK ENGINE LIGHT CAME …
Read full complaint
EVEN AFTER FREE REPAIR DUE TO BEING COVERED UNDER WARRANTY, THE NEW PCV VALVE AND COVER ARE LEAKING AGAIN. ENGINE IDLES ROUGHLY, BOTH IN PARK AND IN DRIVE. THIS IS A KNOWN ISSUE WITH CHEVROLET CRUZE, BUT MY VIN IS NOT PART OF THE RECALL. MAIN ERROR CODE P0171- BANK 1 SYSTEM TOO LEAN- IS BEING PICKED UP (CHECK ENGINE LIGHT CAME ON YESTERDAY MORNING (APRIL 10, 2018)), ALONG WITH ERROR CODES: P0106, P015B, P0236, P0237, P1101, P112D.
WHEN EXITING THE FREEWAY COMING TO A STOP MY CAR COMPLETLY SHUTS OFF. HAVING TO PUT IT IN PARK TO RESTART
ENGINE COOLANT STENCH AND LOSS OF COOLANT SINCE DAY ONE! I NOW HAVE JUST OVER 45,600 MILES AND PER THE DEALER A NEED A TEMP SENSOR HOUSING AND THERMOSTAT. WHILE DRIVING I GOT A MESSAGE ON THE DASH READING "AC OFF DUE TO HIGH ENGINE TEMP" AND THE COOLANT TEMP READ - - - AND THE NEEDLE ON THE TEMP GAUGE DROPPED TO LOW FROM A PRI…
Read full complaint
ENGINE COOLANT STENCH AND LOSS OF COOLANT SINCE DAY ONE! I NOW HAVE JUST OVER 45,600 MILES AND PER THE DEALER A NEED A TEMP SENSOR HOUSING AND THERMOSTAT. WHILE DRIVING I GOT A MESSAGE ON THE DASH READING "AC OFF DUE TO HIGH ENGINE TEMP" AND THE COOLANT TEMP READ - - - AND THE NEEDLE ON THE TEMP GAUGE DROPPED TO LOW FROM A PRIOR MIDWAY POINT AND COOLANT TEMP OF 218 DEGREES. BACK IN 2014 I SUDDENLY HAD BLACK SMOKE COMING FROM TAILPIPE AND THE "DEALER REPLACED THE WATER PUMP ASSEMBLY WITH NEW BASE AND THERMOSTAT." I ALSO HAD A "SERVICE STABILITRAC" NOTICE AND SUDDEN LOSS OF POWER WHILE DRIVING BACK IN 2015 AND THE DEALER SAID THEY COULDN'T DUPLICATE THE ISSUE BUT THAT I NEEDED A NEW COIL PACK WHICH I HAD TO PAY FOR AND REPAIR ON MY OWN EVEN THOUGH CAR WAS STILL UNDER WARRANTY!! THIS VEHICLE HAS SMELLED LIKE ANTIFREEZE SINCE THE DAY I BOUGHT IT, BRAND NEW, FROM THE DEALER THAT WAS PERFORMING ALL THE SERVICES. IN ADDITION, THE BACK WINDOW LEAKED FROM DAY ONE AND I HAD 2" OF STANDING WATER IN MY TRUNK AND I HAD TO PAY, OUT OF MY OWN POCKET!!, TO REPLACE THE REAR WINDOW = TWICE!!! THIS CAR IS A PIECE OF JUNK AND HAS BEEN NOTHING BUT PROBLEMS AND THE DEALER HAS FORCED ME TO DO REPAIRS THAT SHOULD HAVE BEEN COVERED BY THE WARRANTY. I AM SICK AND TIRED OF THE STENCH OF ANTIFREEZE AND THE FACT THAT I NOW HAVE TO REPAIR THE THERMOSTAT HOUSING AND THERMOSTAT DUE TO ENGINE OVERHEATING!!!
OVERHEATING. LOUD NOISE IN ENGINE WITH LOSS OF POWER THAT WE DETERMINED TO BE THE TURBO. CARS BREAKS HAVE BEEN CHANGED SEVERAL TIMES SINCE PURCHASE. CONSISTENT WARNING LIGHTS ON DASH. THE CAR HAS A VERY LOUD RATTLING SOUND WHEN DRIVING. IT ISN'T AS LOUND WHEN SITTING STILL AT A REDLIGHT.
2012 CRUZE LT. THE THIRD TURBO WAS INSTALLED 2 DAYS BEFORE EXTENDED WARRANTY EXPIRED. IT HAS 56668 MILES NOW. I SPENT 4 HOURS PUTTING GLUE PUTTY IN THE CRACKS ON THE BOTTOM INTAKE MANIFOLD, TO PLENUM JUNCTION CORNERS OF CYLINDERS 2 AND 4 BECAUSE OF THE GM PLASTIC [XXX], CURING THE LOW BOOST AND LEAN MIXTURE CODES AT IDLE, ON EAS…
Read full complaint
2012 CRUZE LT. THE THIRD TURBO WAS INSTALLED 2 DAYS BEFORE EXTENDED WARRANTY EXPIRED. IT HAS 56668 MILES NOW. I SPENT 4 HOURS PUTTING GLUE PUTTY IN THE CRACKS ON THE BOTTOM INTAKE MANIFOLD, TO PLENUM JUNCTION CORNERS OF CYLINDERS 2 AND 4 BECAUSE OF THE GM PLASTIC [XXX], CURING THE LOW BOOST AND LEAN MIXTURE CODES AT IDLE, ON EASTER. THE FIRST MONTH I HAD THE CAR THE TRANSMISSION WOULD START IN FIRST SKIP SECOND GEAR REV UP THEN CHIRP THE TIRES UNTIL IT WARMED UP, AND WAS FIXED BY A PROGRAM CHANGE TO A LESSER VERSION AND NOW AT THE HIGHER MILEAGE IT WAITS BEFORE IT ENGAGES FIRST AT ALL. ANOTHER NEAT THING IS TO TURN LEFT AT 5MPH HARD AND FEEL THE CAR DO A JIG TO THE RIGHT FOR AN INSTANT BEFORE CONTINUING ON WITH THE TURN. LASTLY, THE WATER PUMP WAS REPLACED ALONG WITH A CRACKED WATER OUTLET BUT NOT THE ROTTED RECIRCULATION OVERFLOW HOSE THAT BROKE AT 4 AM TO MY FISHING HOLE IN SEPTEMBER. I CAN SAY THAT THE 2017 CRUZE MUST BE BETTER BECAUSE THE DUMDUMS PAID BY THE GM INSURANCE COMPANY TO CHANGE OIL PUT MORE NEW OIL IN THE MOTOR WITHOUT DRAINING IT FIRST. NO SERIOUS ISSUES FOR A WHOLE WEEK I MIGHT BE ABLE TO DRIVE IT BY MAY IT'S BEEN 5 MONTHS SINCE THEN. FYI THE DEALERSHIP WHO PERFORMED THIS FANCY WORK IS NOT IN RIVERTON EITHER.
2012 CRUZ NEW FROM THE DEALER AND NEVER HAD AN ISSUE WITH MY CAR OTHER THAN A WATER PUMP ONLY REG MAT ALWAYS PRAISED HOW GREAT MY CAR WAS AND IT IS THE FIRST NEW CAR I EVER BOUGHT. MY CAR HAS 69K MILES ON IT AND MY WARRANTY WAS 5YRS 100K MY WARRANTY WAS JUST UP THIS PAST OCT AND SUNDAY MY CAR WOULDN'T ACCELERATE OR SHIFT AND SOU…
Read full complaint
2012 CRUZ NEW FROM THE DEALER AND NEVER HAD AN ISSUE WITH MY CAR OTHER THAN A WATER PUMP ONLY REG MAT ALWAYS PRAISED HOW GREAT MY CAR WAS AND IT IS THE FIRST NEW CAR I EVER BOUGHT. MY CAR HAS 69K MILES ON IT AND MY WARRANTY WAS 5YRS 100K MY WARRANTY WAS JUST UP THIS PAST OCT AND SUNDAY MY CAR WOULDN'T ACCELERATE OR SHIFT AND SOUNDED HORRIBLE IN REVERSE. I HAD MY CAR TOWED TO MY WORK FOR DIAGNOSTICS AND THERE WERE ISSUES WITH THE TRANS SO WE TRIED TO DRIVE IT TO THE DEALER AND IT DIDNT MAKE IT SO YET ANOTHER TOW. THE DEALER HAD TO DIAGNOSE THE CAR WHICH WAS $125.00 I GOT A CALL LATE AFTERNOON THE NEXT DAY AND WAS TOLD THE 3T AND 5T WAVE / CLUTCH PLATES BROKE IN MY CAR AND THEY WOULD NEED TO REPLACE THEM AS WELL AS THE CLUTCH, PISTON, SEALS, ECT AND THE COST WOULD BE $3100.00 PLEASE ALSO KEEP IN MIND I OWE $900 ON THE CAR, THE SERVICE DEPT SAID WE HOPE GM WILL PAY FOR MAJORITY OR MOST OF THE COST BC THIS SHOULDN'T HAVE HAPPENED. I WAS TOLD THAT THEY WOULD ONLY COVER 30% SO OUT OF POCKET ABOUT $2200 I SAID THAT IF ITS SOMETHING THAT SHOULDN'T HAVE HAPPENED WHY WOULD I HAVE TO PAY SO MUCH I KNOW I'M 5 MONTHS OUT WARRANTY BUT IM STILL UNDER 100K MILES I CALLED GM AND ASKED ABOUT GOOD FAITH WARRANTY AND STATED MY SITUATION. TWO DAYS LATER THEY AND I WAS TOLD THAT THEY WILL NOT HELP ANYMORE WITH THE COST, BC OF THE YR WARRANTY, IVE ONLY BOUGHT ONE CAR FROM THE DEALER, AND I DID NOT TAKE MY CAR TO THE DEALER FOR ROUTINE MAT.... I TOLD THE REP THAT MY DAD WHO IS A MECHANIC DID MY OIL OR MY WORK BC I WORK AT A REPAIR SHOP AND IF YOU WERE ME YOU WOULD DO THE SAME AND THIS REP TOLD ME " I DON'T GO TO THE DEALER I GO TO WALMART!" I ALSO ASKED ABOUT GOODFAITHWARRANTY AND SHE STATED "WE DONT DO THAT ON OUR VEHICLES" NEEDLESS TO SAY I AM VERY DISAPPOINTED ALL AROUND TRANS DONT GO OUT ON CARS WITH 69K MILES REPAIRS WERE $2610.00 AND AN ADDITIONAL $331.00 FOR DIAG AND TOWING.
AS I WAS DRIVING MY RADIO STARTED GOING ON AND OFF THEN CAR COMPLETELY SHUT OFF STEERING WHILE WENT STIFF TO THE LEFT AND LOCKED AS I WAS ON THE ROAD SCARED THE LIVING SPIRIT OUT OF ME WAS THE SCARIEST EXPERIENCES LUCKLY I WAS ALONE WITHOUT MY KIDS BECAUSE THAT COULD OF BEEN A FATAL ACCIDENT. IN WAS VERY LUCKY IT WAS NOT A BUSY…
Read full complaint
AS I WAS DRIVING MY RADIO STARTED GOING ON AND OFF THEN CAR COMPLETELY SHUT OFF STEERING WHILE WENT STIFF TO THE LEFT AND LOCKED AS I WAS ON THE ROAD SCARED THE LIVING SPIRIT OUT OF ME WAS THE SCARIEST EXPERIENCES LUCKLY I WAS ALONE WITHOUT MY KIDS BECAUSE THAT COULD OF BEEN A FATAL ACCIDENT. IN WAS VERY LUCKY IT WAS NOT A BUSY MORNING THE FIRST TIME IT HAPPEN AND I WAS ABLE TO KEEP TO LEFT UNTIL CAR CAME TO A STOP AT THE CURVE. THIS HAS HAPPEN TO ME MORE THAN ONCE THAT I STOPPED DRIVING CAR STOPPED PAYING IT BECAUSE IT WAS A LEMON SO MANY THINGS WENT WRONG 3MNTHS AFTER BUYING CAR AT USED DEALERS I FELT CHEATED AND STUCK I EVEN LOST MY JOB BECAUSE I WASNT ABLE TO GET TO WORK ON TIME OR AT ALL AT TIMES BECAUSE OF CAR PROBLEMS
THREE TRANSMISSION FAILURES IN 5-1/2 YEARS, WITH TOTAL MILEAGE APPROXIMATELY 45,000..ALL THREE FAILURES OCCURRED ON INTERSTATES, RESULTING IN LOSS OF POWER & DRIVABILITY CAUSING IMMEDIATE AND SEVERE DANGER OF HIGH-SPEED COLLISION FORM OTHER TRAFFIC. FIRST FAILURE IN APRIL 2013 AFTER 6 MONTHS OF OWNERSHIP, UNDER 1,500 MILES. CLUT…
Read full complaint
THREE TRANSMISSION FAILURES IN 5-1/2 YEARS, WITH TOTAL MILEAGE APPROXIMATELY 45,000..ALL THREE FAILURES OCCURRED ON INTERSTATES, RESULTING IN LOSS OF POWER & DRIVABILITY CAUSING IMMEDIATE AND SEVERE DANGER OF HIGH-SPEED COLLISION FORM OTHER TRAFFIC. FIRST FAILURE IN APRIL 2013 AFTER 6 MONTHS OF OWNERSHIP, UNDER 1,500 MILES. CLUTCH PLATE DISINTEGRATED. PROBLEM WAS DETERMINED TO BE A FACTORY DEFECT OF THE TRANSMISSIOM; CAR WAS REPAIRED BY GM (NOT REPLACED). IN MAY 2014 COMPLAINED TO DEALER (HAWK CHEVROLET OF BRIDGEVIEW) OF PROBLEMS WITH CLUTCH - THAT IT WAS FALLING TO THE FLOOR, THERE WAS DIFFICULTY SHIFTING. DEALER CLAIMED TO BE UNABLE TO FIND ANY PROBLEM. COMPLAIMED OF SAME PROBLEM IN OCTOBER 2014 (GM CASE 71-1379518666); AGAIN DEALER "UNABLE TO FIND A PROBLEM". 2ND FAILURE OCCURRED AUGUST 2015; CLUTCH PLATE WAS STUCK TO TRANSAXLE. MILEAGE WAS 14,500. GM CASE #8-1545250753. GM TRIED TO ATTRIBUTE FAILURE TO "NORMAL WEAR". ULTIMATE COVERED THE REPAIR BUT REFUSED TO ADMIT ANY DEFECT. 3RD FAILURE OCCURRED MARCH 9, 2018. AGAIN, CLUTCH PEDAL FELL TO FLOOR AND CAR BECAME UNDRIVABLE. CAR WAS TOWED TO DEALER. GM CASE #8-4000371239.
Official recalls
716V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V300000 · Air Bags
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
13V360000 · Service Brakes, Hydraulic:power Assist
Aug 15, 2013
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
13V023000 · Air Bags
Jan 24, 2013
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
12V522000 · Air Bags
Oct 31, 2012
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
12V288000 · Engine And Engine Cooling
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
12V289000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.