NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
142 reportsClear category filter116,000 miles · May 28, 2019
Service Brakes
WHEN I USE THE BRAKES AND THE AIR IS ON THE CAR WILL NOT STOP LIKE IT SHOULD. IT KEEPS MOVING. I LOOKED THIS UP AND IT SHOWS THERE IS A RECALL ON THE BRAKE BOOSTER VACUUM PIPE BUT BECAUSE MY VIN NUMBER DOESN'T MATCH WHAT YOU HAVE PREDETERMINED THAT WILL HAVE FAULTY PARTS CHEVY SAYS MY CAR DOESN'T HAVE A RECALL. HOW EXACTLY DO YO…
Read full complaint
WHEN I USE THE BRAKES AND THE AIR IS ON THE CAR WILL NOT STOP LIKE IT SHOULD. IT KEEPS MOVING. I LOOKED THIS UP AND IT SHOWS THERE IS A RECALL ON THE BRAKE BOOSTER VACUUM PIPE BUT BECAUSE MY VIN NUMBER DOESN'T MATCH WHAT YOU HAVE PREDETERMINED THAT WILL HAVE FAULTY PARTS CHEVY SAYS MY CAR DOESN'T HAVE A RECALL. HOW EXACTLY DO YOU PREDICT WHAT CARS WILL HAVE FAULTY PARTS?
NHTSA ODI #11210493
40,210 miles · May 7, 2019
Service Brakes
VACUUM ASSIST FOR POWER BRAKES SOMETIMES DOES NOT WORK. YOU MUST PUSH AS HARD AS YOU CAN ON BRAKE PEDAL TO GET THE CAR TO STOP. SOME CHEVY CRUSE WERE RECALLED FOR THIS PROBLEM BUT MINE WAS NOT. THIS IS A VERY DANGEROUS PROBLEM THAT CAN CAUSE A SERIOUS ACCIDENT IN AN EMERGENCY BRAKING SITUATION.
NHTSA ODI #11206071
80,000 miles · Apr 8, 2019
Service Brakes
THE VEHICLE WAS IN MOTION GOING 55 MPH ON THE TURNPIKE AND TRAFFIC AHEAD WAS SLOWING DOWN. THE BRAKE WAS APPLIED AND IT FAILED TO WORK. MY SON, THE DRIVER, PUSHED THE BRAKE AGAIN AND IT STILL WAS NOT BRAKING. OUT OF DESPERATION, HE PUSHED THE BRAKE AS FAR AS IT COULD GO AND THE VEHICLE SWERVED TOWARD THE MEDIAN. HE TURNED THE ST…
Read full complaint
THE VEHICLE WAS IN MOTION GOING 55 MPH ON THE TURNPIKE AND TRAFFIC AHEAD WAS SLOWING DOWN. THE BRAKE WAS APPLIED AND IT FAILED TO WORK. MY SON, THE DRIVER, PUSHED THE BRAKE AGAIN AND IT STILL WAS NOT BRAKING. OUT OF DESPERATION, HE PUSHED THE BRAKE AS FAR AS IT COULD GO AND THE VEHICLE SWERVED TOWARD THE MEDIAN. HE TURNED THE STEERING WHEEL AND THEN IT SWERVED TOWARD THE SHOULDER. THIS ACTION MADE THE VEHICLE SLOW DOWN, BUT THE BRAKES STILL DID NOT WORK.THERE WERE NO OTHER VEHICLES INVOLVED, BUT HE WAS VERY CLOSE TO CRASHING INTO ANOTHER VEHICLE. I CHECKED TO SEE IF THERE WERE ANY RECALLS OR SAFETY ISSUES FOR THE 2012 CHEVROLET CRUZE. THERE WAS ONE RECALL THAT DESCRIBED WHAT HE EXPERIENCED, BUT THE RECALL WAS NOT FOR THE ENGINE TYPE OF MY CRUZE. IT WAS BULLETIN #12213-BRAKE VACUUM MICRO SWITCH. HE HAS AN APPOINTMENT WITH THE CHEVROLET DEALER TO CHECK OUT THE VEHICLE. BY THE WAY, THE VEHICLE PASSED STATE INSPECTION LESS THAN A MONTH AGO. FRANKLY, I AM AFRAID TO HAVE HIM DRIVE THE VEHICLE.
NHTSA ODI #11194780
103,000 miles · Feb 3, 2019
EngineService BrakesVehicle Speed Control
MY BRAKES KEEP GOING "HARD" AND NOT FUNCTIONING PROPERLY. ABOUT A YEAR AGO I HAD MY MASTER CYLANDER, BRAKE BOOSTER, MICROSWITCH IN THE BRAKE VACUUM LINE, MAF SENSOR AND AIR INTAKE HOSE REPLACED BECAUSE THE MECHANIC SAID THOSE WERE THE ISSUES, I WENT 2 WEEKS WITHOUT MY VEHICLE, INCLUDING BREAKING DOWN FOR MULTIPLE DAYS OUT OF STA…
Read full complaint
MY BRAKES KEEP GOING "HARD" AND NOT FUNCTIONING PROPERLY. ABOUT A YEAR AGO I HAD MY MASTER CYLANDER, BRAKE BOOSTER, MICROSWITCH IN THE BRAKE VACUUM LINE, MAF SENSOR AND AIR INTAKE HOSE REPLACED BECAUSE THE MECHANIC SAID THOSE WERE THE ISSUES, I WENT 2 WEEKS WITHOUT MY VEHICLE, INCLUDING BREAKING DOWN FOR MULTIPLE DAYS OUT OF STATE. NOW HERE I AM WITH THE SAME ISSUES. BEFORE I HAD THEM REPLACED I WAS TOLD THAT THE MICROSWITCH IN THE BRAKE SYSTEM WAS ALREADY RECALLED AND REPLACED. BUT SINCE THEN IT HAS FAILED AGAIN. I WAS TOLD BY CHEVY THAT THEY ONLY DO THE RECALL ONCE, BUT IF THEY ARE REPLACING IT WITH A FAULTY PART SHOULDN'T THAT BE RECALLED AGAIN? I HAVE TWO TODDLERS IN MY VEHICLE REGULARLY AND LOSING THE POWER BRAKES COULD END VERY BAD. THE POWER BRAKES FAIL ALMOST EVERY DAY, USUALLY THE FIRST TIME I HIT THE BRAKES AFTER STARTING TO VEHICLE. WITCH MAKE ME THINK THAT ITS GOING TO COMPLETELY FAIL AGAIN SOON.
NHTSA ODI #11173805
145,000 miles · Dec 18, 2018
Service BrakesCrash
WHEN THE TEMPERATURE DROPS BELOW 20 DEGREES F MY ABS AND TRACTION CONTROL LIGHTS COME ON CONSTANTLY AND IT SAYS SERVICE ABS SYSTEM AND SERVICE STABILITRAK SYSTEM. WHENEVER THIS OCCURS MY LEFT REAR E-BRAKE LOCKS UP AS THOUGH IT IS FROZEN. THIS HAS CAUSED ME TO SLIDE OFF THE ROAD MULTIPLE TIMES.
NHTSA ODI #11162300
130,000 miles · Nov 9, 2018
Service Brakes
AS I'M DRIVING IN THE CITY OF ATLANTA GEORGIA MY CAR CHEVY CRUZE 2012 HAS MANY ISSUES AS THE CAR BEING IN MOTION AS I PRESS THE BRAKES TO COME TO A STOP THE BRAKES PRESSURE GETS AND DO NOT STOP I FOUND OUT DID I HAVE TO TAP ON THE GAS AGAIN AND THEN PRESS THE BRAKE TO GET IT TO COMPLY SORT OF SCARY ALMOST CAUSING A WRECK EVERY T…
Read full complaint
AS I'M DRIVING IN THE CITY OF ATLANTA GEORGIA MY CAR CHEVY CRUZE 2012 HAS MANY ISSUES AS THE CAR BEING IN MOTION AS I PRESS THE BRAKES TO COME TO A STOP THE BRAKES PRESSURE GETS AND DO NOT STOP I FOUND OUT DID I HAVE TO TAP ON THE GAS AGAIN AND THEN PRESS THE BRAKE TO GET IT TO COMPLY SORT OF SCARY ALMOST CAUSING A WRECK EVERY TIME
NHTSA ODI #11150359
Mileage unknown · Sep 20, 2018
Service Brakes
2012 CHEVROLET CRUZE. CONSUMER WRITES IN REGARDS TO BRAKE SYSTEM FAILURE *AS THE CONSUMER STATED THE BRAKE SYSTEM CONTINUED TO FAIL WHEN DRIVING IN REVERSE.*JS
NHTSA ODI #11131210
65,000 miles · Sep 12, 2018
Service Brakes
TAKATA RECALL ON OR ABOUT JULY 2016 I NOTICED WHEN I PUT MY CAR IN REVERSE I TRIED TO BRAKE AND MY CAR WOULD STAY IN MOVEMENT AND REQUIRE ME TO SLAM DOWN ON THE BRAKE PEDAL. EVER SINCE THE FIRST TIME I NOTICED IT, IT HAS GOTTEN WORSE. THE BRAKE PEDAL GETS HARD AND MY CAR KEEPS ROLLING WHEN I'M IN REVERSE AND DRIVING FORWARD. IT…
Read full complaint
TAKATA RECALL ON OR ABOUT JULY 2016 I NOTICED WHEN I PUT MY CAR IN REVERSE I TRIED TO BRAKE AND MY CAR WOULD STAY IN MOVEMENT AND REQUIRE ME TO SLAM DOWN ON THE BRAKE PEDAL. EVER SINCE THE FIRST TIME I NOTICED IT, IT HAS GOTTEN WORSE. THE BRAKE PEDAL GETS HARD AND MY CAR KEEPS ROLLING WHEN I'M IN REVERSE AND DRIVING FORWARD. IT HAPPENS FREQUENTLY BUT SOMETIMES WILL GO AWAY. I THOUGHT IT COULD BE A RESULT OF MY ENGINE NOT REACHING THE RIGHT TEMPERATURE BUT IT HAS HAPPENED MIDWAY THROUGH MY COMMUTES. I'VE BEEN TOLD THAT THERE ARE NO RECALLS FOR MY CAR BUT I FEEL THIS IS A HUGE SAFETY PROBLEM, I TRIED TO PARALLEL PARK THE OTHER DAY AND COULDN'T DO IT BECAUSE MY CAR KEPT ROLLING AROUND. THIS HAS HAPPENED ON CITY STREETS, I HAVE NOT NOTICED IT WHEN IM ON THE HIGHWAY.
NHTSA ODI #11129148
118,000 miles · Aug 1, 2018
Service Brakes
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. WHILE DRIVING 10 MPH, THE BRAKES FAILED TO STOP THE VEHICLE. THE CONTACT HAD TO EXERT EXTRA FORCE TO DEPRESS THE BRAKE PEDAL UNTIL THE VEHICLE CAME TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO BEDARD BROS. AUTO SALES (391 S STATE RD, CHESHIRE, MA 01225, (413) 743-0014) AND WAS INFORME…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. WHILE DRIVING 10 MPH, THE BRAKES FAILED TO STOP THE VEHICLE. THE CONTACT HAD TO EXERT EXTRA FORCE TO DEPRESS THE BRAKE PEDAL UNTIL THE VEHICLE CAME TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO BEDARD BROS. AUTO SALES (391 S STATE RD, CHESHIRE, MA 01225, (413) 743-0014) AND WAS INFORMED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 13V360000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DIAGNOSIS WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.
NHTSA ODI #11115162
Mileage unknown · Jul 27, 2018
Electrical SystemEngineService Brakes
BELT TENSIONER BOLT CAME OUT AND IS NOW STUCK IN A SPRING IN THE ENGINE..THE LIGHT ON MY RADIO FADES IN AND OUT.. ROTOR ON DRIVERS SIDE HAD DEFORMITY TO IT .STILL HAVE THE ROTOR AND THE SPRING IS STILL STUCK IN ENGINE I CAN'T AFFORD TO GET IT FIXED
NHTSA ODI #11114036
Official recalls
7Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
Aug 15, 2013
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
Jan 24, 2013
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 31, 2012
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
Illustration