I GOT IN THE CAR PUT MY SEAT BELT ON LEFT MY HOUSE TO GO TO THE GROCERY STORE AND I HEARD A DING SOUND LIKE I HAD NOT CLICKED MY SEAT BELT IN. I THOUGHT THIS IS ODD I TRIED TO UNLOCK IT BY PUSHING ON THE BUTTON BUT IT WOULD NOT POP OUT I HAD A TOENAIL CLIPPER IN MY PURSE AND WHEN I GOT TO THE GROCERY I HAD TO WIGGLE IT AROUND TO…
Read full complaint
I GOT IN THE CAR PUT MY SEAT BELT ON LEFT MY HOUSE TO GO TO THE GROCERY STORE AND I HEARD A DING SOUND LIKE I HAD NOT CLICKED MY SEAT BELT IN. I THOUGHT THIS IS ODD I TRIED TO UNLOCK IT BY PUSHING ON THE BUTTON BUT IT WOULD NOT POP OUT I HAD A TOENAIL CLIPPER IN MY PURSE AND WHEN I GOT TO THE GROCERY I HAD TO WIGGLE IT AROUND TO FREE MYSELF OF THE SEAT BELT DUE TO IT BEING STUCK IT FINALLY POPPED OUT NOW I CAN NOT WEAR MY BELT BECAUSE IT WILL NOT GO BACK IN . I HAVE NEVER HAD ANY PROBLEMS NOR BEEN IN ANY ACCIDENTS SO I'M CONFUSED AS TO WHAT IS WRONG WITH IT. I WAS ON A CITY STREET SITTING AT A RED LIGHT WHEN THE SENSOR FOR THE SEAT BELT WENT OFF
NHTSA ODI #11316941
Mileage unknown · Nov 12, 2018
Electrical SystemEngineSeat Belts
THIS VEHICLE (CHEVY CRUZE 2012) IS THE WORST VEHICLE MADE POSSIBLE. THERE IS OIL LEAKS THAT HAVE BEEN FIXED THAT OCCUR AGAIN . THERE IS A COOLANT LEAK THAT WAS FIXED BY THE RADIATOR CONNECTOR. 15 MINUTES LATER OF DRIVING THE VEHICLE 2 MORE HOSES POPPED AND CAUSED THE COOLANT TO LEAK AGAIN. THE RADIATOR WENT BAD AND WAS CHANGED T…
Read full complaint
THIS VEHICLE (CHEVY CRUZE 2012) IS THE WORST VEHICLE MADE POSSIBLE. THERE IS OIL LEAKS THAT HAVE BEEN FIXED THAT OCCUR AGAIN . THERE IS A COOLANT LEAK THAT WAS FIXED BY THE RADIATOR CONNECTOR. 15 MINUTES LATER OF DRIVING THE VEHICLE 2 MORE HOSES POPPED AND CAUSED THE COOLANT TO LEAK AGAIN. THE RADIATOR WENT BAD AND WAS CHANGED THE VEHICLE STILL OVER HEATED . THE THERMOSTAT WAS CHANGED AND THE VEHICLE WAS FINE FOR 2 DAYS. I GO TO START THE VEHICLE AND IT DOESN'T WANT TO TURN OVER . COME TO FIND OUT AT THE SAME MECHANIC THAT I HAD THE THERMOSTAT CHANGED APPARENTLY SAID THE HEAD GASKET WAS BLOWN . THEN SAYS THERE'S SOMETHING WRONG WITH THE CYLINDER HEADS . SO ALL IN ALL . THIS VEHICLE HAS HAD OIL LEAKS , COOLANT LEAKS , ENGINE LIGHTS , RADIATOR ISSUES , CYLINDERR HEAD PROBLEMS , MISFIRING AND NOW A HEAD GASKET PROBLEM . THIS BRINGS A SAFETY ISSUE TO ME THAT WHILE I AM DRIVING MY CAR IS MISFIRING ON ME IN THE MIDDLE OF THE ROAD WHILE THERE IS TRAFFIC GOING ON AND TONS OF PEOPLE ON THE ROAD . I COULD POTENTIALLY BE DRIVING THIS VEHICLE AND BECAUSE OF ALL OF THIS ELECTRICAL ISSUES THAT GM IS NOT CAPABLE OF MANUFACTURING CORRECTLY ON THESE VEHICLES (CHEVY CRUZE) MY CAR COULD OF BLEW UP WHILE DRIVING IT. I HAVE MY NIECES AND NEPHEWS IN THE CAR WHILE THE CAR SHAKES OUT OF NOWHERE WHICH COULD OF PUT THERE LIFE IN DANGER . CHEVY IS NO HELP WHAT SO EVER THEY ONLY WANT TO CHARGE TO EVEN LOOK AT A CAR THEY MANUFACTURED!!!! I ASK FOR HELP FROM THEM AND THEY SEEM SO CAREFREE . MY LIFE IS IN DANGER AND NO ONE CARES!! SOMEONE WILL DIE BY GM HANDS IF THIS ISSUE CANNOT BE CORRECTLY FIXED ON THESE VEHICLES . YOU GUYS ARE SELLING CARS THAT CAN KILL SOMEONE AND ONCE YOU GUYS ARE NOTIFIED OF THIS NO ONE CARES . ONCE THERE IS A LAWSUIT UNDER YOUR COMPANY THEN MAYBE YOU GUYS WILL TAKE THIS SERIOUS .
NHTSA ODI #11150899
76,000 miles · May 24, 2016
Seat Belts
DROVE TO MY AUNTS HOUSE AND UNBUCKLED MY SEAT BELT. WENT INSIDE FOR A BRIEF SECOND WHILE CAR WAS RUNNING. GOT BACK INTO MY CAR AND TRIED TO PUT MY SEAT BELT ON AND IT WOULD NOT LATCH. TRIED VARIOUS TIMES. WHEN I RETURNED HOME I TRIED IT AGAIN AND IT LATCHED.
NHTSA ODI #10870696
Mileage unknown · Oct 13, 2015
Seat BeltsInjury
A SEATBELT GOT WRAPPED AROUND MY 2 YEAR OLDS NECK AND WOULD NOT LOOSEN AND WE HAD TO CUT THE SEATBELT BECAUSE IT WAS CHOKING HER... IT HAPPENED WHEN I WAS DRIVING DOWN THE ROAD AND LUCKILY MY AUNTS HOUSE WAS CLOSE AND I WAS ABLE TO RUN IN THE HOUSE AND GET SCISSORS TO CUT IT OFF HER.
NHTSA ODI #10781844
2,000 miles · May 10, 2012
Air BagsSeat BeltsCrash
I WAS INVOLVED IN A COLLISION ON MAY 5, 2012 IN WHICH I COLLIDED INTO THE SIDE OF ANOTHER VEHICLE WITH THE FRONT END OF MY CAR. MY CAR IS BRAND NEW, LESS THAN A MONTH OLD HOWEVER, THE SEAT BELTS DID NOT HOLD AND THE AIR BAGS DID NOT DEPLOY DURING THE CRASH. I WAS TRAVELING AT APPROXIMATELY 30-35 MPH AT THE TIME OF THE CRASH. TH…
Read full complaint
I WAS INVOLVED IN A COLLISION ON MAY 5, 2012 IN WHICH I COLLIDED INTO THE SIDE OF ANOTHER VEHICLE WITH THE FRONT END OF MY CAR. MY CAR IS BRAND NEW, LESS THAN A MONTH OLD HOWEVER, THE SEAT BELTS DID NOT HOLD AND THE AIR BAGS DID NOT DEPLOY DURING THE CRASH. I WAS TRAVELING AT APPROXIMATELY 30-35 MPH AT THE TIME OF THE CRASH. THE COLLISION WAS BAD ENOUGH THAT MY CAR WAS NO LONGER DRIVABLE AFTER THE COLLISION. I JUST BOUGHT THIS CAR WHICH IS A 2012 CHEVROLET CRUZE AND AM NOW AFRAID TO KEEP IT NOT KNOWING WHY THE SAFETY EQUIPMENT DIDN'T WORK. ALSO, I HAD ACTIVATED MY "ON STAR" SERVICE BUT THAT DIDN'T WORK EITHER. I WOULD LIKE FOR SOMEONE TO INSPECT MY CAR BEFORE THE REPAIRS ARE STARTED. PLEASE LET ME KNOW WHERE TO GO FROM HERE. *TR
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
2012 Chevrolet Cruze Problems, Complaints & Recalls | Skip That Year
Illustration