NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
268 reportsClear category filter19,000 miles · Jun 5, 2014
Air BagsEngineLatches/locks/linkagesCrash
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKES FAILED. THE VEHICLE DID NOT STOP WHEN THE BRAKE PEDAL WAS FULLY APPLIED, CAUSING THE CONTACT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. T…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKES FAILED. THE VEHICLE DID NOT STOP WHEN THE BRAKE PEDAL WAS FULLY APPLIED, CAUSING THE CONTACT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE VEHICLE WAS TAKEN TO THE DEALER BUT NO DIAGNOSES WAS PROVIDED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 13V36000(SERVICE BRAKES, HYDRAULIC) BUT DID NOT CONFIRM IF THE VEHICLE WAS INCLUDED IN THE RECALL. THIS FAILURE PERSISTED INTERMITTENTLY OVER A PERIOD OF ONE YEAR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 19,000. UPDATED 8/19/14*CN THE CONSUMER STATED THE VEHICLE'S TRUNK EXTERIOR MANUAL LATCH WOULD NOT OPEN THE TRUNK AND THE STEERING WHEEL AIR BAG IS ON RECALL. WHILE DRIVING, THE VEHICLE WOULD HESITATE AND LURCH. UPDATED 08/28/2014 *JS
NHTSA ODI #10596304
40 miles · Jun 5, 2014
EnginePower Train
I RECEIVED MY CHEVY CRUZE LS IN AUGUST OF 2012 AFTER HAVING IT FOR A WEEK I STARTED TO NOTICE ISSUES WITH THE TRANSMISSION. I DROVE IT UP NORTH AND AFTER BEING ON THE FREEWAY GOING A CONSTANT SPEED OF 75 MPH, WHEN FORCED TO SLOW DOWN DUE TO TRAFFIC THE CAR COULD NOT FIGURE OUT WHAT I WAS TRYING TO DO AND JUST HAD A MIND OF ITS O…
Read full complaint
I RECEIVED MY CHEVY CRUZE LS IN AUGUST OF 2012 AFTER HAVING IT FOR A WEEK I STARTED TO NOTICE ISSUES WITH THE TRANSMISSION. I DROVE IT UP NORTH AND AFTER BEING ON THE FREEWAY GOING A CONSTANT SPEED OF 75 MPH, WHEN FORCED TO SLOW DOWN DUE TO TRAFFIC THE CAR COULD NOT FIGURE OUT WHAT I WAS TRYING TO DO AND JUST HAD A MIND OF ITS OWN. THE RPMS WOULD SHOOT UP VERY HIGH AND THE CAR WOULD STRUGGLE TO ACCELERATE (ALMOST AS IF IT WERE STUCK IN NEUTRAL) AND EVENTUALLY IT WOULD JERK FORWARD VERY HARD AND THEN ACCELERATE. THIS HAPPENS EVERY TIME I GET ON THE FREEWAY NOW AND HAVE TO SLOW DOWN BECAUSE OF TRAFFIC OR SLOW DOWN TO GET OFF AT THE EXIT (AND CONTINUES WELL AFTER BEING OFF THE FREEWAY). I AM LUCKY I HAVEN'T BEEN REAR ENDED AND SEVERELY INJURED OR KILLED. I'VE HAD THE CAR FOR ALMOST TWO YEARS NOW AND ITS ONLY GOTTEN WORSE, IT NOW DOES THE SAME THING WHEN DRIVING DOWN THE STREET AT 30 MPH, IT WILL BE GOING ALONG JUST FINE THEN ALL OF A SUDDEN THE ENGINE REVS AS IF IT WERE SHIFTED INTO NEUTRAL AND THEN CATCHES ITSELF AND JERKS REALLY HARD AND IS FINE AGAIN. ALSO WHEN SLOWING DOWN IT SEEMS TO DOWNSHIFT TOO QUICKLY ALMOST COMING TO A COMPLETE STOP ON ITS OWN, WHICH IS WHY I AM AFRAID OF BEING REAR ENDED. I HAVE TAKEN THE CAR IN TO 5 DIFFERENT DEALERSHIPS AND AM TOLD EVERY TIME THAT EITHER THEY DON'T SEE THE PROBLEM AND I DON'T KNOW WHAT I'M TALKING ABOUT OR THEY CAN SEE THERE'S A PROBLEM BUT THERE'S NOTHING THEY CAN DO ABOUT IT. I'M VERY DISAPPOINTED IN THE QUALITY OF THIS CAR, I'VE ALSO HAD ISSUES WITH THE RADIO AND MY USB CORD NOT CONNECTING TO MY PHONE AND EVEN WHEN IT DOES CONNECT THE SONGS COME THROUGH WITH LOTS OF STATIC. I HAVE TRIED DIFFERENT CORDS, DIFFERENT PHONES AND MULTIPLE IPODS AND IT KEEPS HAPPENING. I FEEL TOTALLY HELPLESS AND AM SICK OF FEELING UNSAFE IN MY CAR. MY FAMILY HAS ALWAYS BOUGHT GM CARS, THIS IS MY SECOND CHEVY AND MY LAST!! *TR
NHTSA ODI #10596290
25,000 miles · Jun 4, 2014
Engine
FAILURE OF WATER PUMP. ON THE MORNING AFTER NORMAL WORK COMMUTE OF 60 MILES, FOUND SPILLED COOLANT UNDER VEHICLE. GM SERVICE REPLACED THE WATER PUMP UNDER WARRANTY. VEHICLE ONLY HAD 25K MILES AND THE WATER PUMP FAILED-UNACCEPTABLE. *TR
NHTSA ODI #10596245
28,000 miles · May 30, 2014
EngineCrash
TRYING TO MAKE A LEFT HAND TURN INTO A GAS STATION, AND HAD VERY LITTLE POWER TO COMPLETE TURN,SO I TRIED TO STOP SHORT, AND ONCOMING CAR HIT ME....WHEN IN REPAIR SHOP, THE DEALER INFORMED ME THE TURBOCHARGER WAS BROKEN......AND SAW THE TURBO PART BROKEN THE SAME WAY! *TR
NHTSA ODI #10595206
12,000 miles · May 24, 2014
EngineFuel/propulsion SystemPower Train
THIS CAR HAS HAD SEVERAL PROBLEMS. THEY HAVE HAD TO REPLACE A VACUUM PUMP, THE ENGINE SHIELD RECALL, THE BRAKES STICK, THERE IS A HORRIBLE SMELL OF HOT TRANSMISSION FLUID CONSTANTLY, THE TRANSMISSION COOLANT LINES HAVE BEEN REPLACED, A PUMP ABOVE THE FUEL TANK HAS BEEN REPLACED, THE CAR SURGES AND CAUSES THE RPM GAUGE TO BOUNCE…
Read full complaint
THIS CAR HAS HAD SEVERAL PROBLEMS. THEY HAVE HAD TO REPLACE A VACUUM PUMP, THE ENGINE SHIELD RECALL, THE BRAKES STICK, THERE IS A HORRIBLE SMELL OF HOT TRANSMISSION FLUID CONSTANTLY, THE TRANSMISSION COOLANT LINES HAVE BEEN REPLACED, A PUMP ABOVE THE FUEL TANK HAS BEEN REPLACED, THE CAR SURGES AND CAUSES THE RPM GAUGE TO BOUNCE, THE AXLES HAVE HAD LEAKS FIXED, THE EXTERIOR TRUNK BUTTON DOESN'T WORK, DRIVING DOWN THE ROAD IT SOUNDS LIKE A PLASTIC BOTTLE IS STUCK INSIDE THE PASSENGER SIDE FRONT DOOR, SOME TIMES AFTER PUTTING THE KEY IN THE IGNITION IT WON'T TURN, THE SUSPENSION SYSTEM POPS AND CRACKS, THE AXLE SQUEALS, SHIFTS AT INAPPROPRIATE TIMES OR NOT WHEN IT IS SUPPOSED TO, THE BACK UP SENSOR WILL BEEP WHEN NOTHING IS THERE SOME TIMES, DOESN'T FEEL LIKE THERE IS ANY PRESSURE BEHIND THE BRAKES SOME TIMES, AND SMOKE ROW OUT FROM UNDER THE HOOD WHEN STOPPED AT STOP LIGHTS SOME TIMES. I THINK THAT IS EVERY THING BUT IT HAS BEEN A CONSTANT NIGHTMARE. I AM GUESSING ON MILES AND DATES, BUT IT WAS NOT VERY LONG AFTER I GOT IT BRAND NEW THAT IT STARTED HAVING PROBLEMS. WHEN I STARTED HAVING SHIFTING AND LEAKS IN THE TRANSMISSION, THE DEALERSHIP COULDN'T FIGURE OUT WHAT WAS WRONG, I HAD TO POINT OUT THE LEAK MYSELF AND THEN HE SAID HE WOULD GET THE PARTS ORDERED AND THEY WOULD BE IN WITHIN 3 DAYS. 2 WEEKS LATER I CALLED GM, THEN IT WAS WITHIN A WEEK I WAS CONTACTED BY THE DEALER THAT THEY HAD THE PARTS, AFTER GM SAID SOMEONE WOULD CONTACT ME WITHIN 48 HOURS. THIS HAS BEEN SUCH A HASSLE I AM NOW VEHICLE SHOPPING AND WILL NOT PURCHASE ANOTHER CHEVROLET. *TR
NHTSA ODI #10593845
75,500 miles · May 21, 2014
Electrical SystemEngine
RADIO FLASHED ON AND OFF AND ALL BRAKE LIGHTS ON DASH WOULD LIGHT UP. SERVICE STABILITY CONTROL NOTICE WOULD APPEAR. THEN IT WOULD GO AWAY AND REAPPEAR. DID THIS FOR AN ENTIRE HOUR AND A HALF RIDE ON HIGHWAY. RADIO ON RADIO OFF DASHBOARD LIGHTS ON AND OFF. BLINKER NO LONGER CLICKED WHEN USED... DISCONCERTING TO DRIVE A CAR WITH …
Read full complaint
RADIO FLASHED ON AND OFF AND ALL BRAKE LIGHTS ON DASH WOULD LIGHT UP. SERVICE STABILITY CONTROL NOTICE WOULD APPEAR. THEN IT WOULD GO AWAY AND REAPPEAR. DID THIS FOR AN ENTIRE HOUR AND A HALF RIDE ON HIGHWAY. RADIO ON RADIO OFF DASHBOARD LIGHTS ON AND OFF. BLINKER NO LONGER CLICKED WHEN USED... DISCONCERTING TO DRIVE A CAR WITH SUCH PROBLEMS. A WEEK EARLIER I HAD CAR ISSUES COVERED UNDER POWER TRAN WARRANTY... AND NOW THIS...ALL AFTER A MASSIVE RECALL ANNOUNCED. THINK GM NEEDS TO RE LOOK AT ALL OF THEIR CARS... *TR
NHTSA ODI #10593141
58,000 miles · May 16, 2014
EngineFuel System, Gasoline
DURING ACCELERATION I SMELL GAS, OIL BURNING, EXHAUST FUELS IN MY CAR. I HAVE TAKEN IT TO THE DEALER WHO KEEPS STATING IT RUNNING LIKE IT SHOULD. NOW I BELIEVE MY WARRANTY IS OVER AND MY NEW CAR FUNCTIONS LIKE ITS 20 YEARS OLD. I CAN'T GET THEM TO BELIEVE ME AND I DON'T BELIEVE THEY EVEN BOTHER TEST DRIVING IT. I MENTIONED TH…
Read full complaint
DURING ACCELERATION I SMELL GAS, OIL BURNING, EXHAUST FUELS IN MY CAR. I HAVE TAKEN IT TO THE DEALER WHO KEEPS STATING IT RUNNING LIKE IT SHOULD. NOW I BELIEVE MY WARRANTY IS OVER AND MY NEW CAR FUNCTIONS LIKE ITS 20 YEARS OLD. I CAN'T GET THEM TO BELIEVE ME AND I DON'T BELIEVE THEY EVEN BOTHER TEST DRIVING IT. I MENTIONED THE SMELL WHEN I BROUGHT MY CAR IN FOR THEM TO REPLACE MY TURBO CHARGER THAT MALFUNCTIONED. EVER AFTER. *TR
NHTSA ODI #10588935
13,000 miles · Apr 28, 2014
Engine
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, SHE NOTICED THAT OIL LEAKED FROM THE ENGINE AND ONTO THE GROUND. THE FAILURE OCCURRED AFTER AN OIL CHANGE WAS PERFORMED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 12V288000 (ENGINE AND ENGINE COOLING) BUT THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, SHE NOTICED THAT OIL LEAKED FROM THE ENGINE AND ONTO THE GROUND. THE FAILURE OCCURRED AFTER AN OIL CHANGE WAS PERFORMED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 12V288000 (ENGINE AND ENGINE COOLING) BUT THE FAILURE PERSISTED AFTER THE RECALL REMEDY WAS PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 13,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10585191
43,000 miles · Apr 3, 2014
EngineStructureFire
[XXX] VIN MY CAR WAS TAKEN TO DEALERSHIP BECAUSE IT STARTED MAKING A SOUND LIKE THE MOTOR WAS TICKING AND HAD BEEN OVERFILLED WITH OIL ABOUT 6 MONTHS BEFORE BY THE DEALERSHIP. THE SERVICEMAN WAITED UNTIL NEXT DAY TO DRIVE THE CAR. WHILE BEING TEST DROVE BY THE SERVICE MAN IT CAUGHT ON FIRE AND BURNED THE WHOLE MOTOR AND OUTSIDE …
Read full complaint
[XXX] VIN MY CAR WAS TAKEN TO DEALERSHIP BECAUSE IT STARTED MAKING A SOUND LIKE THE MOTOR WAS TICKING AND HAD BEEN OVERFILLED WITH OIL ABOUT 6 MONTHS BEFORE BY THE DEALERSHIP. THE SERVICEMAN WAITED UNTIL NEXT DAY TO DRIVE THE CAR. WHILE BEING TEST DROVE BY THE SERVICE MAN IT CAUGHT ON FIRE AND BURNED THE WHOLE MOTOR AND OUTSIDE OF THE CAR UP. ALL PLASTIC WAS COMPLETELY BURNED. MY INSURANCE MAN WHO WENT TO LOOK AT THE CAR SAID HE COULD NOT TELL IF THE PLASTIC SHIELD ON THE BOTTOM HAD OIL ON IT OR NOT BUT THEY COULD FURTHER INVESTIGATE AND WOULD BE ABLE TO FIND OUT. NOW I HAD INSURANCE FULL COVERAGE ON THE CAR AND I BOUGHT GAP FROM THE DEALERSHIP WHEN I PURCHASED THE CAR. I AM PAYING A 6.25 INTEREST RATE ON THE CAR WHICH CAME TO 22,740.00 PLUS 3,000.00 DOWN WHEN PURCHASED AND BEEN PAYING FOR 1 YEAR. PAID FOR EXTENDED WARRANTY AND GAP. I HAVE WAITED OVER A MONTH FOR GM TO INVESTIGATE THIS AND OF TODAY'S DATE THE DEALERSHIP SAYS THEY HAVE NOT COME TO DO THEIR JOB. I AM 64 YEARS OLD AND NEVER DREAMED THAT A LARGE DEALERSHIP COULD OR WOULD DO SOMEONE LIKE THEY HAVE DONE ME. THERE WAS VERY LARGE RECALL ON 2012 CARS AND I DON'T KNOW IF MINE WAS EVER FIXED BECAUSE I DIDN'T KNOW ABOUT THE RECALL UNTIL THIS HAPPENED. I JUST WANT MY MONEY BACK FOR THE DOWN PAYMENT SO I CAN BUY ANOTHER CAR AND FOR MY CAR TO BE PAID OFF BY THE DEALERSHIP BECAUSE THEY ARE THE ONES WHO OVER FILLED THE CAR IN THE FIRST PLACE. THE DEALERSHIP SHOULD BE RESPONSIBLE FOR THE CAR IT WAS IN THERE PLACE THERE SERVICE MEN WAS DRIVING IT WHEN IT CAUGHT ON FIRE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10577268
47,000 miles · Mar 20, 2014
EngineFire
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, A FIRE STARTED IN THE ENGINE COMPARTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 47,000.
NHTSA ODI #10573739
Official recalls
7Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
Aug 15, 2013
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
Jan 24, 2013
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 31, 2012
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
Illustration