Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1500–25K
10225–50K
13450–75K
8275–100K
91100–150K
21150K+
580 reports with mileage · 152 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 257 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports20 fire reports30 injury reports
What owners actually said
732 reports
73,000 miles · Jun 29, 2016
Service Brakes
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUZE. WHILE DRIVING 15 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED AND THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER CONTINUALLY DEPRESSING THE BRAKE PEDAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSU…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUZE. WHILE DRIVING 15 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED AND THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER CONTINUALLY DEPRESSING THE BRAKE PEDAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 73,000.
NHTSA ODI #10881614
57,554 miles · Jun 17, 2016
Unknown Or Other
AFTER HAVING OTHER RECALLS WITH THIS VEHICLE, NOW THERE IS A TRANSMISSION FLUID LEAK DIRECTLY AFTER THE WARRANTY EXPIRED. THIS WAS DISCOVERED AT THE DEALERSHIP WHEN "CHECK ENGINE" LIGHT WAS ON DUE TO EVAP VENT VALVE NEEDING REPLACED. SHOTTENKIRK CHEVROLET STATED THE TRANSMISSION FLUID LEAK REPAIR WILL COST $1,380.00
NHTSA ODI #10874825
45,000 miles · Jun 16, 2016
StructureUnknown Or OtherInjury
THE CHROME PLATING ON BOTH THE FRONT DRIVER AND PASSENGER INTERIOR DOOR HANDLES STARTED TO PEEL OFF WHICH CREATED SHARP EDGES ON THE HANDLES IN WHICH I AND OTHERS HAVE CUT OURSELVES ON. I HAD TO CHIP SOME OF THE CHROME PLATING OFF AND WRAP THE HANDLES WITH TAPE TO PREVENT MYSELF AND MY KIDS FROM GETTING CUT ON THE PEELING CHROME…
Read full complaint
THE CHROME PLATING ON BOTH THE FRONT DRIVER AND PASSENGER INTERIOR DOOR HANDLES STARTED TO PEEL OFF WHICH CREATED SHARP EDGES ON THE HANDLES IN WHICH I AND OTHERS HAVE CUT OURSELVES ON. I HAD TO CHIP SOME OF THE CHROME PLATING OFF AND WRAP THE HANDLES WITH TAPE TO PREVENT MYSELF AND MY KIDS FROM GETTING CUT ON THE PEELING CHROME FINISH.
NHTSA ODI #10874606
Mileage unknown · Jun 12, 2016
Unknown Or Other
TRANSMISSION PROBLEMS.
NHTSA ODI #10873781
92,000 miles · Jun 6, 2016
Power Train
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUIZE. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHIFTED FROM SIXTH GEAR TO FIRST. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT HAD TO PULL OVER IN A PARKING LOT AND THE VEHICLE RESTARTED NORMALLY AFTER 20 MINUTES. THE FAILURE RECURRED AND WOULD NOT CHANGE GEARS. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUIZE. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHIFTED FROM SIXTH GEAR TO FIRST. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT HAD TO PULL OVER IN A PARKING LOT AND THE VEHICLE RESTARTED NORMALLY AFTER 20 MINUTES. THE FAILURE RECURRED AND WOULD NOT CHANGE GEARS. THE VEHICLE WAS NEVER TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 92,000. UPDATED 08/02/16*LJ THE CONSUMER STATED THE VEHICLE LOCKED UP AND WENT INTO FIRST GEAR. UPDATED 08/15/16.*JB
NHTSA ODI #10872810
15 miles · Jun 2, 2016
Power TrainService Brakes
WHEN AT A STOP AND WHEN I GO TO TAKE OFF CAR ROLLS BACKWARD. THIS CAR HAS A AUTOMATIC TRANS, BUT ACT LIKE A STICK TRANS, I BOUGHT THIS CAR NEW OFF LOT. AND FIRST BRAKES KEEP LOCKING UP LIKE SOMETHING IS IN IT. BUT IF I ROLL BACKWARD IT DISENGAGES . I'VE TAKEN IT TO THE DEALER A COUPLE OF TIMES DUE TO THIS ISSUE AND THEY ALSO HE…
Read full complaint
WHEN AT A STOP AND WHEN I GO TO TAKE OFF CAR ROLLS BACKWARD. THIS CAR HAS A AUTOMATIC TRANS, BUT ACT LIKE A STICK TRANS, I BOUGHT THIS CAR NEW OFF LOT. AND FIRST BRAKES KEEP LOCKING UP LIKE SOMETHING IS IN IT. BUT IF I ROLL BACKWARD IT DISENGAGES . I'VE TAKEN IT TO THE DEALER A COUPLE OF TIMES DUE TO THIS ISSUE AND THEY ALSO HEARD IT BUT NEVER COULD FIND ANYTHING. I REALLY LIKE THIS CAR BUT IT FALLING APART FROM DAY ONE.. I KEEP IT SERVICED LIKE I AM SUPPOSE TO.
NHTSA ODI #10872118
97,000 miles · Jun 2, 2016
Electrical SystemElectronic Stability Control (esc)Steering
LOSS OF POWER STEERING DURING DRIVING, RADIO FLICKERS ON AND OFF WHILE DRIVING, WHILE PRESSING BRAKE WHILE STOPPED THE CAR CONTINUES TO JUMP FORWARD - CITY DRIVING ON HIGHWAY AND STREETS. BEGAN HAPPENING ONE MONTH AFTER I PURCHASED CAR ON 4/3/2016.
NHTSA ODI #10872050
42,500 miles · Jun 1, 2016
Fuel/propulsion System
THESE ARE SOME PHOTOS OF THE DEFECTIVE FUEL LINE FROM PREVIOUS COMPLAINT. THE PART NUMBER OF THE FUEL LINE IS 13269487 AS SHOWN IN ONE OF THE PHOTOS. THE ENTIRE DESCRIPTION IS LISTED IN COMPLAINT, NHTSA ID NUMBER: 10871417
NHTSA ODI #10871902
42,500 miles · May 30, 2016
Fuel/propulsion System
FUEL LINE CONNECTION LEAKS GASOLINE UNDER RIGHT REAR OF CAR EVERY TIME IGNITION KEY IS TURNED ON AND WILL CONTINUE TO LEAK WHEN CAR IS BEING DRIVEN. FAILURE CAN OCCUR FOR NO REASON AT ANY TIME. THE LOCATION OF THE CONNECTOR IS HIGHLY SUSCEPTABLE TO BEING DAMAGED AS IT IS UNPROTECTED AND EXPOSED EXTENDING UNDER THE VEHICLE. THIS …
Read full complaint
FUEL LINE CONNECTION LEAKS GASOLINE UNDER RIGHT REAR OF CAR EVERY TIME IGNITION KEY IS TURNED ON AND WILL CONTINUE TO LEAK WHEN CAR IS BEING DRIVEN. FAILURE CAN OCCUR FOR NO REASON AT ANY TIME. THE LOCATION OF THE CONNECTOR IS HIGHLY SUSCEPTABLE TO BEING DAMAGED AS IT IS UNPROTECTED AND EXPOSED EXTENDING UNDER THE VEHICLE. THIS IS A KNOWN PROBLEM AND NO GM RECALL HAS BEEN ISSUED AND IS A POSSIBLE FIRE HAZZARD.
NHTSA ODI #10871417
70,000 miles · May 19, 2016
Power Train
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUZE. WHILE THE VEHICLE WAS PARKED, THE KEY TURNED, THE RADIO WORKED, AND THE GEAR SHIFTER INDICATOR MOVED UP AND DOWN THE SCALE. THE CHECK ENGINE WARNING INDICATOR ALSO ILLUMINATED. THE VEHICLE FAILED TO START. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DIAGNOSED BY AN I…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET CRUZE. WHILE THE VEHICLE WAS PARKED, THE KEY TURNED, THE RADIO WORKED, AND THE GEAR SHIFTER INDICATOR MOVED UP AND DOWN THE SCALE. THE CHECK ENGINE WARNING INDICATOR ALSO ILLUMINATED. THE VEHICLE FAILED TO START. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE PRINDEL SHIFT LEVELER WAS NOT REFLECTING THE POSITION OF THE GEAR SHIFTER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH APRIL 21, 2011. THE BOLT ATTACHING THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR INPUT SHAFT MAY NOT HAVE BEEN PROPERLY INSTALLED.
Consequence & remedy
Consequence: THIS COULD ALLOW THE SHAFTS TO SEPARATE, RESULTING IN THE LOSS OF STEERING. LOSS OF STEERING CONTROL MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND IF REQUIRED, REPAIR THE INTERMEDIATE SHAFT/STEERING GEAR ASSEMBLY TO ASSURE THE BOLT IS FULLY SEATED AND THE SHAFT PROPERLY ASSEMBLED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 6, 2009, THROUGH APRIL 27, 2011 AND EQUIPPED WITH AN AUTOMATIC TRANSMISSION FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, 'TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT,' AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A TRANSMISSION SHIFT LINKAGE THAT IS NOT PROPERLY INSTALLED. IF THE LINKAGE IS NOT PROPERLY INSTALLED, THE PRNDL SHIFT LEVER MAY NOT ACCURATELY REFLECT THE POSITION OF THE TRANSMISSION GEAR. WITH THIS CONDITION, THE DRIVER COULD MOVE THE SHIFTER TO PARK AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN PARK.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION SHIFT LINKAGE FOR CORRECT INSTALLATION AND ADJUST THE SHIFT LINKAGE SYSTEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.
Consequence & remedy
Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Additional source detail variants (2)
Steering:column
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.
Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Steering
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.
Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
2011 Chevrolet Cruze Problems, Complaints & Recalls | Skip That Year
Illustration