Engine. Review the 257 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports20 fire reports30 injury reports

Power Train complaints

193 reports

Clear category filter

123,000 miles · Jul 6, 2019

Power Train

THE CAR ONLY HAS 123K AND THE TRANSMISSION HAS GONE OUT SINCE DAY ONE THIS CAR HAS HAD ISSUES, INTAKE MANIFOLD REPLACED TWICE

NHTSA ODI #11229790

122,000 miles · Jun 8, 2019

Power TrainUnknown Or Other

Read full complaint

WHILE DRIVING MY 2011 CHEVROLET CRUZE LT WHEN IT GETS T0 BETWEEN 30-40 MPH THE RPMS WILL GO EXTREMELY HIGH THE CHECK ENGINE LIGHT WILL COME ON AND THE CAR WILL SLOW DOWN AS IT IS SLOWING DOWN IT WILL JERK INTO THE LOWER GEARS IF I DON'T PUT THE CAR IN NEUTRAL. SINCE I DON'T HAVE A READER FOR THE CHECK ENGINE LIGHT I HAVE TO PULL OVER AND DISCONNECT MY BATTERY TO GET THAT TO SHUT OFF. I HAVE TO LET MY CAR ENGINE/TRANSMISSION COOL DOWN BEFORE DRIVING AGAIN OTHERWISE I WILL ONLY MAKE IT EIGHTH OF A MILE DOWN THE ROAD AND THE SAME THING HAPPENS. I WANT THIS PROBLEM FIXED. I OFFICIALLY HATE MY CAR BECAUSE OF THIS PROBLEM. MAKES ME NEVER WANT TO BUY A CHEVROLET AGAIN. I HAVE SEEN MAY COMPLAINTS OF THIS HAPPENING TO THIS YEAR OF CAR. THIS SHOULD BE RECALLED AND FIXED FREE OF CHARGE.

NHTSA ODI #11218717

70,000 miles · May 21, 2019

Electrical SystemEnginePower Train

Read full complaint

ENGINE LIGHT COMES ON AND CAR WILL SLOW DOWN AND BARELY TAKE OFF. ENGINE IS RESPONDING TO GAS PEDAL BUT NO POWER IN LOW GEAR SO TAKES OFF VERY SLOW NEARLY RESULTING IN WRECK. TWO SHOPS, INCLUDING TRANSMISSION SHOP, STATE ITS ELECTRONIC PROBLEM INCLUDING 'LACK OF COMMUNICATION'. IT HAPPENS FROM BEING STATIONARY OR IN PROCESS OF DRIVING WHEN IT LOSES POWER SUDDENLY. WHEN ENGINE LIGHT GOES OFF IT RUNS OK. DANGEROUS TO DRIVE AS NEVER KNOW WHEN IT'LL ACT UP. STARTED ABOUT SIX MONTHS AGO, AND IS INTERMITTENT.

NHTSA ODI #11209022

Mileage unknown · Apr 23, 2019

Power Train

TRANSMISSION ISSUES IN THESE CARS AND GENERAL MOTORS ONLY MADE THEM FOR ONE YOUR KNOWINGLY THERE WAS AN ISSUE AND DON'T WANT TO RECALL THE ISSUE. THESE TRANSMISSIONS ARE SUPER EXPENSIVE DUE TO ONLY BEING MADE FOR ONE YEAR.

NHTSA ODI #11203028

63,000 miles · Apr 22, 2019

Electronic Stability Control (esc)EnginePower Train

Read full complaint

CAR SEEMS TO STALL WHILE DRIVING (RECURRENT/ CONSTANT PROBLEM FOR 4 MONTHS: CAR HAS < 65K MILES). ENGINE/ LOSS OF STABILITRACK LIGHTS COME ON AND ENGINE REVS HIGH WITHOUT SPEED. LIGHTS ON RADIO BLINK AND ENGINE/OIL/ COOLANT LEAKS. DESPITE ATTEMPTS TO FIX PROBLEMS, CAR CONTINUES TO STALL OUT, LEAVING DRIVER STRANDED IN ROADWAY. ENGINE REBOOTS ARE TEMPORARY FIX, BUT THE COMPUTER SEEMS TO BE TAKING OUT SYSTEMS 1 BY 1. GM SPECIALIST HAD CAR FOR 2 WEEKS IN JANUARY & COULD NOT SOLVE.

NHTSA ODI #11202971

126,844 miles · Mar 25, 2019

Electronic Stability Control (esc)Power Train

Read full complaint

I WENT AND GOT THIS VEHICLE FROM CHRYSLER DODGE JEEP RAM OF ROME GA AND I WAS DRIVING AND OUT OF NOWHERE THE CAR ACTED LIKE IT DIDN'T WANT TO GO FORWARD IN TRAFFIC AND THE SPEED STAYED ON 0 AND IDLED OUT ON ME. WHEN I TRIED TO TURN RIGHT MY CAR WOULDN'T GO AND SOMEBODY HAD TO PUSH MY VEHICLE. WHEN I TRIED TO DRIVE IT, IT WAS IN DRIVE AND WOULDN'T GO 20 MPH. I GOT THE VEHICLE MARCH 13 AND HAVEN'T HAD IT FOR A MONTH AND EXPERIENCED THIS.IT WAS A VERY SCARY SITUATION AND I FELT LIKE I COULD HAVE LOST MY LIFE. I WAS TRYING TO TURN AND PUT OF NOWHERE IT WOULDN'T GO OVER 20 MPH.MOST SCARIEST SIRTIATION EVRER..

NHTSA ODI #11191240

91,000 miles · Feb 13, 2019

Power TrainUnknown Or Other

I DROVE MY 2011 CHEVROLET CRUZE TO WORK WITHOUT ISSUE. UPON LEAVING I STARTED MY MY VEHICLE, PUT IT IN REVERSE AND BACKED OUT OF MY PARKING SPOT BUT IT WOULD NOT DRIVE FORWARD. I HAD THE VEHICLE TOWED TO MY HOME. THE NEXT DAY IT WOULD NOT START UP ENTIRELY.

NHTSA ODI #11179832

88,000 miles · Sep 14, 2018

Power Train

Read full complaint

IN MAY OF THIS YEAR, AS I TRIED TO BACK OUT OF MY DRIVEWAY, MY CAR WOULD NOT MOVE IN REVERSE. THE CAR WAS RATTLING, THE RPMS WERE GOING UP, BUT THE CAR WOULD NOT GO IN GEAR. MY FAMILY PUSHED MY CAR OUT OF THE DRIVEWAY IN NEUTRAL AND I DROVE IT 2 MILES TO MY MECHANIC. DURING THAT 2 MINUTE DRIVE, THE CAR CONTINUALLY SLIPPED GEARS. FAST FORWARD TO HAVING THE CRUZE TOWED TO A TRANSMISSION SHOP (AFTER NOT HAVING HEARD FROM CHEVROLET AFTER MULTIPLE ATTEMPTS CONTACTING THEM) AND I FIND OUT THE TRANSMISSION IS COMPLETELY BROKE. THE CAR IS OUT OF WARRANTY, AND OF COURSE CHEVROLET LENT NO ASSISTANCE, SO I PAID $3,674 TO HAVE A REMANUFACTURED TRANSMISSION PUT IN WITH A 500,000 MILE WARRANTY. THE TRANSMISSION IN THE CRUZE NEVER ACTED COMPLETELY RIGHT (A COMMON COMPLAINT AMONG MANY CRUZE OWNERS)- NOT SHIFTING PROPERLY WHEN GOING UP HILLS, JERKING WHEN SHIFTING ON FLAT PAVEMENT. IT'S MIND-BLOWING THAT THERE HAVE BEEN SO MANY REPORTED ISSUES OF TRANSMISSION FAILURES IN THIS MODEL, BUT CHEVROLET HAS YET TO MAKE ANY RECALLS. IT'S NOT ONLY A FINANCIAL ISSUE, IT'S A SAFETY CONCERN. I WILL NOT BE BUYING A CHEVY AGAIN, AS THEY WERE UNWILLING TO PROVIDE ANY ASSISTANCE WHEN THIS MAJOR COMPONENT FAILED. NOT EVEN 90K MILES, SEVEN YEARS OLD, THIS SHOULDN'T EVEN BE AN ISSUE YET.

NHTSA ODI #11129492

65,000 miles · Sep 10, 2018

Electrical SystemEnginePower Train

Read full complaint

2016 ECM REPROGRAMMING RECALL EVER SINCE I BROUGHT MY CAR IN FOR THE RECALL IN 2016 TO HAVE THE ECM REPROGRAMMED, I HAVE HAD SEVERE ISSUES WITH VERY ROUGH IDLING, SLOW ACCELERATION, AND INCONSISTENT FUEL USAGE. CHECK ENGINE LIGHT COMES ON AND LISTS SEVERAL SENSORS THAT NEED TO BE REPLACED. WE REPLACED ALL OF THEM AND THE PROBLEM STILL COMES BACK. NOW THE CODES INDICATE THERE IS A CATASTROPHIC ISSUE WITH THE ECM AND CHEVY WILL NOT COVER IT EVEN THOUGH THIS ISSUE STARTED FROM THEIR OWN RECALL.

NHTSA ODI #11128457

66,000 miles · Aug 19, 2018

Power Train

Read full complaint

ON MY WAY TO THE BEACH I APPROACHED A STOP SIGN NEAR THE ENTRANCE OF A BUSY HIGHWAY. AFTER STOPPING I PROCEEDED TO PRESS THE GAS PEDAL AND ALL I GOT WAS ENGINE REVVING THE CAR DIDN'T MOVE AT ALL. I TRIED SHIFTING THE GEAR FROM PARK BACK TO DRIVE AND I TRIED AGAIN. THE CAR STILL DIDN'T MOVE AND I GOT REVVING AGAIN. SOMETHING WAS WRONG WITH THE TRANSMISSION CAUSING THE CAR TO SLIP INTO NEUTRAL WHILE BEING IN DRIVE. I RETURNED THE VEHICLE TO PARK AND TURNED IT OFF, AFTER WAITING A FEW SECONDS I STARTED THE CAR UP AGAIN PUT IT IN DRIVE AND I ACCELERATED FORWARD, I PULLED INTO A NEARBY PARKING LOT AND EASED MY WAY INTO A SPACE, BEFORE MAKING IT ALL THE WAY INTO THE SPACE I LOST GEAR AGAIN. I PUT THE CAR IN REVERSE AND BACKED OUT OF THE SPACE. PUT IN BACK IN DRIVE AND AGAIN DIDN'T GO FORWARD, JUST REVVING. I ULTIMATELY PARKED THE CAR AND HAD IT TOWED TO A MECHANIC. 2011 CHEVROLET CRUZE ARE MOST COMMONLY KNOWN TO HAVE TRANSMISSION PROBLEMS BUT THERE IS NO OPEN RECAL. MY CRUZE COULD HAVE SLIPPED INTO NEUTRAL WHILE I WAS ON THE MIDDLE OF THE HIGHWAY. THERE WAS NO WARNING IT WAS GONNA FAIL. NO LIGHT INDICATIONS, NO STRANGE SOUNDS COMING FROM THE CAR. I HAD THE CAR TOWED TO A NEARBY CHEVROLET DEALER TO SEE IF THEY COULD TELL ME WHAT HAPPENED. THE TRANSMISSION GUY DROVE IT AROUND THE LOT AND THEN TOLD ME HIS BEST EDUCATED GUESS ON WHAT HAPPENED IS THAT THE 3,5,R PLATE BROKEDOWN AND CLOGGED THE FILTER. THEY TOLD ME I NEED A NEW TRANSMISSION. I CONTACTED CHEVROLET AND GM TO SEE IF THEY WOULD HELP AT ALL AND THEY SAID THEY COULD NOT. I HAD THE CAR TOWED SOMEWHERE ELSE TO GET THE TRANSMISSION REBUILT FOR CHEAPER. I TIRED TO ENCOURAGE THE GM REPRESENTATIVE I SPOKE TO, TO LOOK INTO OPENING A RECAL ON THE TRANSMISSIONS OF 2011 CHEVROLET CRUZE BEING THAT IS THE MOST COMMON COMPLAINT. HOWEVER THEY COULD NOT PROVIDE ANY INFORMATION ON IF THEY WOULD OPEN A RECAL.

NHTSA ODI #11120955

Official recalls

16V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jul 5, 2016

General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Consequence & remedy

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.

Additional source detail variants (2)

Electrical System:ignition

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

13V360000 · Service Brakes, Hydraulic:power Assist

Aug 15, 2013

General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.

Consequence & remedy

Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.

Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.

12V288000 · Engine And Engine Cooling

Jun 22, 2012

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.

Consequence & remedy

Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

12V289000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Jun 22, 2012

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.

Consequence & remedy

Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

11V270000 · Steering:gear Box:shaft Sector

May 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH APRIL 21, 2011. THE BOLT ATTACHING THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR INPUT SHAFT MAY NOT HAVE BEEN PROPERLY INSTALLED.

Consequence & remedy

Consequence: THIS COULD ALLOW THE SHAFTS TO SEPARATE, RESULTING IN THE LOSS OF STEERING. LOSS OF STEERING CONTROL MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT, AND IF REQUIRED, REPAIR THE INTERMEDIATE SHAFT/STEERING GEAR ASSEMBLY TO ASSURE THE BOLT IS FULLY SEATED AND THE SHAFT PROPERLY ASSEMBLED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.

11V273000 · Power Train:automatic Transmission:gear Position Indication (prndl)

May 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 6, 2009, THROUGH APRIL 27, 2011 AND EQUIPPED WITH AN AUTOMATIC TRANSMISSION FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, 'TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT,' AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A TRANSMISSION SHIFT LINKAGE THAT IS NOT PROPERLY INSTALLED. IF THE LINKAGE IS NOT PROPERLY INSTALLED, THE PRNDL SHIFT LEVER MAY NOT ACCURATELY REFLECT THE POSITION OF THE TRANSMISSION GEAR. WITH THIS CONDITION, THE DRIVER COULD MOVE THE SHIFTER TO PARK AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN PARK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSION SHIFT LINKAGE FOR CORRECT INSTALLATION AND ADJUST THE SHIFT LINKAGE SYSTEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.

11V221000 · Steering; Steering:column

Apr 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence & remedy

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Additional source detail variants (2)

Steering:column

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Steering

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ12002 · Chapman Chevrolet / Cruze Engine Recall

Opened Oct 15, 2012 · Closed Oct 20, 2014

Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline

NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.

PE12010 · Engine Compartment Fire

Opened Mar 28, 2012 · Closed Jul 19, 2012

Status: closed (inferred from source dates) · Engine

In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.