Engine. Review the 257 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports20 fire reports30 injury reports

Engine complaints

257 reports

Clear category filter

Mileage unknown · Nov 17, 2024

Engine

Losing coolant seems like blown head gasket

NHTSA ODI #11625774

Mileage unknown · Jul 29, 2024

Electrical SystemEnginePower Train

Read full complaint

While driving home on the interstate after work, I was travelling at around 65 miles per hour, with the cruise control set at that speed. In an instant I lost all engine power and began to slow down very rapidly. A quick look to the rearview mirror to ensure nothing was approaching the rear of my vehicle, I found that I could see nothing except grey and white smoke behind me from all three mirrors. I was forced to remove myself from the highway for fear of causing an accident by blinding drivers with the smoke coming from my exhaust, and I was able to use the service road to get to the next fueling station. Upon arrival, I opened the hood and found that oil had sprayed out of every available portal in the engine, it exited through the vacuum lines, pressure sensors onto my alternator, saturated my serpentine belt as well as everything else ion the engine compartment. I noticed most of the oil came from a round hole behind the oil filler cap through a busted vacuum diaphragm that had blown out instead of regulating vacuum, indicating extreme positive pressure in the crankcase. As this was my MOS in the Army, I am experienced with dangers and risks involved in these situations, and I will give warning that if this happens during the right traffic situations, lives will be lost as a result of the smoke screen developimg when the oil hits the catalytic convertors combined with the rapid decline in speed without warning of any kind, and when it does happen, and it will, since there are 8 million of these vehicles on the road and counting, this complaint should serve as proper and fair warning od the damgers and risks with allowing this engine to remain in use without a warning system to indicate the tiny plastic check valve has been released from its position. I was fortunate enough that I only suffered a few curse words and horns blowing and flipping me the bird, but i have to admit I was afraid for my life and someone with less driving experience will have a bad outcom

NHTSA ODI #11605021

Mileage unknown · Jun 23, 2024

Engine

The main seal

NHTSA ODI #11596020

Mileage unknown · May 10, 2024

Engine

Since I’ve brought the car there is always an issue with the car overheating and something with the cooling system that needs to be repaired. It happens frequently and I’ve spent more in repairs than what I paid for the car. It’s always something with the coolant system that causes it to overheat which is dangerous.

NHTSA ODI #11588064

Mileage unknown · Oct 26, 2023

Engine

Read full complaint

September 21, 2023 had taken my 2011 Chevy Cruze to a service center because i noticed an oil leak on my garage Floor. the service center replaced the intake manifold cover. Yesterday October 25, 2023 Major Oil Leak, had to pull over, engine was smoking badly. popped the hood and there was oil all over cover and most components around this area. i was told by a few good Samaritans that this oil leaking could potentially cause a fire. no warning lights, only a bad smell and seeing smoke.

NHTSA ODI #11551978

Mileage unknown · Jun 6, 2023

EnginePower Train

Noticed a very hard transmission shift when accelerating from approximately 35 to 40 mph. Hard shifting in this vehicle has been observed over the past year. Milage is approximately 60,000 miles.

NHTSA ODI #11525621

95,000 miles · Mar 23, 2023

Engine

The contact owns a 2011 Chevrolet Cruze. The contact stated that while driving approximately 35 MPH, the vehicle started vibrating. The contact took the vehicle to a certified mechanic who changed the engine oil however, the failure persisted. The contact was informed that there might be an engine failure. The vehicle had not be…

Read full complaint

NHTSA ODI #11513399

Mileage unknown · Jan 14, 2023

Engine

Engine failed due to coolant system failure.

NHTSA ODI #11501792

Mileage unknown · Oct 24, 2022

Engine

Read full complaint

Engine light and P2099 waste gate actuator pin on the turbo of the Cruze has malfunctioned. There was a recall for this exact issue and my vehicle year was included but not my VIN number. I have less than 95,000 miles on the car and this part should also be recalled on my vehicle as well. Many issues with the car: replaced water pump, replaced hoses, constant smell of coolant that dealership claims doesn't exist. Please help! Car is not driveable now. https://static.nhtsa.gov/odi/tsbs/2018/MC-10145482-9999.pdf

NHTSA ODI #11490658

Mileage unknown · Oct 6, 2022

Air BagsEnginePower Train

Read full complaint

Due to OnStar 2G sunsetting their services at the end of this year, all makes of General Motors vehicles did not comply to any of the customers requests to upgrade their module to 4G services, although upon researching, all Canadian GM vehicles did get the upgrade well over 7 years ago. This is well beyond a concern with GM and OnStar customers. With the NHTSA as a safety liaison and protecting the consumer, if a module upgrade can be applied in a vehicle that is on the same assembly parts, platform, electrical components...and be denied from the United States? The NHTSA should realize that this will be frivolous law suits because of neglect and safety concerns with GM and OnStar in the United States.

NHTSA ODI #11488148

Official recalls

16V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jul 5, 2016

General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Consequence & remedy

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.

Additional source detail variants (2)

Electrical System:ignition

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

13V360000 · Service Brakes, Hydraulic:power Assist

Aug 15, 2013

General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.

Consequence & remedy

Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.

Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.

12V288000 · Engine And Engine Cooling

Jun 22, 2012

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.

Consequence & remedy

Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

12V289000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Jun 22, 2012

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.

Consequence & remedy

Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

11V270000 · Steering:gear Box:shaft Sector

May 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH APRIL 21, 2011. THE BOLT ATTACHING THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR INPUT SHAFT MAY NOT HAVE BEEN PROPERLY INSTALLED.

Consequence & remedy

Consequence: THIS COULD ALLOW THE SHAFTS TO SEPARATE, RESULTING IN THE LOSS OF STEERING. LOSS OF STEERING CONTROL MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT, AND IF REQUIRED, REPAIR THE INTERMEDIATE SHAFT/STEERING GEAR ASSEMBLY TO ASSURE THE BOLT IS FULLY SEATED AND THE SHAFT PROPERLY ASSEMBLED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.

11V273000 · Power Train:automatic Transmission:gear Position Indication (prndl)

May 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 6, 2009, THROUGH APRIL 27, 2011 AND EQUIPPED WITH AN AUTOMATIC TRANSMISSION FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, 'TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT,' AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A TRANSMISSION SHIFT LINKAGE THAT IS NOT PROPERLY INSTALLED. IF THE LINKAGE IS NOT PROPERLY INSTALLED, THE PRNDL SHIFT LEVER MAY NOT ACCURATELY REFLECT THE POSITION OF THE TRANSMISSION GEAR. WITH THIS CONDITION, THE DRIVER COULD MOVE THE SHIFTER TO PARK AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN PARK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSION SHIFT LINKAGE FOR CORRECT INSTALLATION AND ADJUST THE SHIFT LINKAGE SYSTEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.

11V221000 · Steering; Steering:column

Apr 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence & remedy

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Additional source detail variants (2)

Steering:column

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Steering

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.

Consequence: SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ12002 · Chapman Chevrolet / Cruze Engine Recall

Opened Oct 15, 2012 · Closed Oct 20, 2014

Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline

NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.

PE12010 · Engine Compartment Fire

Opened Mar 28, 2012 · Closed Jul 19, 2012

Status: closed (inferred from source dates) · Engine

In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.