2019 Chevrolet Corvette

The contact owns a 2019 Chevrolet Corvette. The contact stated while driving 65 MPH, the passenger’s side rear tire low-pressure warning light illuminated. The contact stopped at a service station and added air to the tire and proceeded to drive however, the warning light illuminated again. The contact took the vehicle to a local tire shop who inspected the vehicle and diagnosed the failure as a cracked rim. The contact took the vehicle to the local dealer and it was confirmed that the rim was cracked. The rim was replaced. The contact stated that several months later the failure recurred on the driver’s side rear wheel. The contact took the vehicle to AutoNation Chevrolet Valencia (23649 Valencia Blvd, Santa Clarita, CA 91355, (661) 200-9107) and it was determined that the rim was cracked. The rim was replaced. The contact was concerned that the failure would return. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.

The contact owns a 2019 Chevrolet Corvette. The contact stated that while driving at 25 MPH, the low tire pressure warning light illuminated. The contact stated that he added air to the tires however, the low tire pressure warning light illuminated again. The contact stated that he then took the vehicle to an independent mechanic who diagnosed the failure as a driver's side rear cracked rim. The vehicle was not repaired as he was waiting to transport it to the dealer. The manufacturer was notified of the failure and advised the contact to take the vehicle to a Chevrolet dealer for diagnosis. The failure mileage was 6,500.

The contact owns a 2019 Chevrolet Corvette. The contact stated while driving 45 MPH, the RPM decreased to 1,200 and the vehicle started to shudder and shake. The contact was able to continue to drive the vehicle to the residence. The contact took the vehicle to a local dealer to be inspected. The dealer performed a transmission flush to fix the failure however, the failure persisted. The contact took the vehicle back to the local dealer who inspected the vehicle and diagnosed the vehicle with 3 bent wheels. The wheels were not replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 4,399. Per the dealership, the bent wheels are not covered under warranty and the problem is the result of normal wear-and-tear. However, I found numerous complaints on the internet stating GM made the wheels with inferior material that is "cast, rather than forged, and is of insufficient strength to withstand the torque and power input from the drivetrain," I am now scared to drive the car because the bent wheels or a safety hazard and will more than likely start to crack which could result in causing a wreck. At this time the only way to correct the failure is to purchase new wheels if I wish to continue to drive the car and prevent from being a safety hazard or causing a collision.

OEM wheels fail. Thousands of online reports of 2015-2019 Corvette C7 Grand Sport and Z06 models wheels cracking without incident. My wheel is available for inspection. Safety was risked by having a wheel crack, loose air pressure and fail under normal operating load, potentially causing a crash. This issue has been reported to GM, has countless incidents also reported and can be easily confirmed at any dealer. My vehicle is currently at the dealer and has been inspected by their professionals. No symptoms prior to failure. No other damage has been noted or reported by the dealership to this wheel or tire.

Vehicle has 6900 miles on it, started to vibrate badly while driving on highway. Car has not been in any accidents and carefully driven. Dealer says the two rear wheels are bent.This could lead to cracking of wheels and/or loss of control of the vehicle. Vehicle is still under 36 month/36,000 mile bumper to bumper warranty. GM will not cover cost to replace and assumes no responsibility.

Bad smell of gas while parked in garage. Looked underneath and was leaking fuel. Looked online early c7 corvette 15-18 has a special recall for the fuel receiver and tank because it was leaking. Gm actually extended one of the warranties because of it. Brought my car to the dealer and said it's not covered under the extended warranty that gm gave. I was 18 days out of my bumper to bumper 3yr 36k miles and gm agreed to pay 90% and me 10%.

The rim cracked from the outside edge and progressed until air begin to leak. The dealer will not replace the rim unless you bought a tire and rim policy. But the manufacture of the tire does warrantee the tire and the dealer knows that to be the case. So the dealer knows the rims are the problem. I have researched and many others have the very same problem with their Corvette rims cracking until air is lost. These rims are definitely improperly designed and they should be recalled.

In February 2021, my Chevy dealer service department found that both of my rear wheels were bent and had to be repaired. My Corvette had 13,319 miles on it and I had never run off road or hit a major pot hole to cause this level of damage. The service technician said that this was 'common' on 2017 to 2019 Corvette Grand Sport and Z06 OEM wheels. Additionally, the wheels would probably 'crack' in the future and need to be replaced. I find this totally unacceptable that GM (Chevy) would design and manufacture defective wheels on a sports car, or any of their vehicles.