2019 Chevrolet Corvette

THE NEWER C& CORVETTES, ESPECIALLY THE Z06 AND GRAND SPORT MODELS ARE EXTREMELY SUSCEPTIBLE TO CRACKED RIMS. I RECENTLY HAD TO PAY $170 TO HAVE A RIM A CRACKED AND LEAKING RIM WELDED TO FIX NUMEROUS CRACKS. THIS REPAIR WAS UNSUCCESSFUL AND THE LEAKING HAS BEGUN AGAIN. WHEN MOTORTREND MAGAZINE CONDUCTED AN EXTENDED TEST OF THE C7 CORVETTE GRAND SPORT CORVETTE, IT HAD NO LESS THAN SIX SEPARATE RIM PROBLEM INCLUDING EITHER BENT OR CRACKING PROBLEMS. THE CRACKED RIMS REQUIRED VERY EXPENSIVE REPLACEMENTS, NOT COVERED UNDER WARRANTY. THERE IS AN EXISTING CLASS ACTION LAWSUIT ABOUT THIS CONTINUING PROBLEM. THIS PROBLEM OCCURS ON BOTH CITY STREET AND ON HIGHWAYS WHILE THE CAR IS IN MOTIONS AND COULD BE DISASTROUS IF THE RIM WERE TO TOTALLY FRACTURE AT HIGHWAY SPEEDS. HERE IS A LINK TO A COMMENT ABOUT THIS PROBLEMS. HTTPS://WWW.CORVETTEBLOGGER.COM/2019/05/10/ANOTHER-LAWSUIT-FILED-AGAINST-GM-OVER-CRACKED-CORVETTE-WHEELS/

REPAIRED RIGHT REAR TIRE FOR A NAIL AND DISCOUNT TIRE INFORMED ME OF A CRACKED TIRE RIM. I TOOK CAR TO A AUTHORIZED CHEVROLET DEALER. THEY SAID MY 2019 GRAND SPORT CORVETTE WITH 9300 MILES WARRANTY DID NOT COVER THE RIM. I WAS LOSING TIRE PRESSURE AND THAT'S WHEN I WAS TOLD OF THE CRACKED RIM. AT MY EXPENSE I'M REPLACING THE RIM $985.10

NOTICED A RHYTHMIC VIBRATION AND WENT TO CHEVROLET DEALER TO INVESTIGATE. OEM REAR WHEELS HAVE WARPED OUT OF ROUND. CHEVROLET MECHANIC DID NOT FIND PHYSICAL DAMAGE BUT COULD SEE THAT THEY DID NOT SPIN IN A CIRCULAR MANNER. GM WILL NOT HONOR THE BUMPER TO BUMPER WARRANTY. THIS CAR HAS 6,700 MILES ON IT AND HAS NOT BEEN ABUSED IN ANY MANNER. A VEHICLES WHEELS MUST BE ABLE TO SUPPORT NORMAL ROAD CONDITIONS WITHOUT WARPING, BREAKING OR LEADING TO CATASTROPHIC FAILURE

WITH APPROXIMATLY 12,000 MILES THE DEALER TOLD ME THE LR WHEEL WAS BENT WHEN I HAD IT IN FOR NEW TIRES. AT 13,600 MILES WHEN IN FOR ALIGNMENT I HAD TO REPLACE THE RF WHEEL DUE TO A CRACK. NOT COVERD UNDER WARRANTY, NO SERIOUS POT HOLE HITS, JUST NORMAL ROAD DRIVING. BASED ON NUMEROUS COMPLAINTS ON FOURMS THIS SEEMS TO BE HAPPENING EXCESSIVLY ON THE WIDE WHEEL EQUIPPED CORVETTES.

I AM THE OWNER OF A 2019 CORVETTE ZR1. I WAS DRIVING WHEN I HEARD A LOUD RATTLE SOUND COMING FROM THE FRONT BUMPER AREA. DURING THIS TIME THE FRONT END OF MY CAR BECAME HARD TO CONTROL. I SLOWED DOWN, PARKED THE CAR AND INSPECTED THE FRONT END. UPON INSPECTION I SAW THAT MY FRONT SPLITTER HAD NEARLY DISCONNECTED FROM MY CAR. I TRIED TO DRIVE SLOWLY AND MAKE IT HOME BUT THE SPLITTER WAS SCRAPING AND I DIDN'T FEEL THAT IT WAS SAFE. I ALSO DIDNT WANT TO CAUSE ANY MORE DAMAGE. UPON INSPECTION FROM A SHOP IT WAS FOUND THAT THE CENTER SUPPORT BRACKET THAT HOLDS THE FRONT SPLITTER ON PROPERLY WAS NEVER INSTALLED ON MY DURING PRE-DELIVERY INSPECTION. AFTER SPEAKING WITH SEVERAL OTHER ZR1 OWNERS THAT THIS HAS HAPPENED TO WE NOW BELIEVE THAT SOME CHEVY DEALERS ARE FORGETTING TO PUT THIS CENTER SUPPORT BRACKET ON DURING PRE-DELIVERY INSPECTION WHICH WE BELIEVE CREATES A VERY DANGEROUS SITUATION. WE HAVE INFORMED CHEVY ABOUT THIS SAFETY ISSUE BUT THEY HAVE NOT RESPONDED.

MUCH LIKE MANY OF THE HUNDREDS OF OTHER CORVETTE GRAND SPORT (C7) OWNERS WITH BENT OR CRACKED WHEEL COMPLAINTS, MY CAR HAS FALLEN VICTIM TO GM'S DEFECTIVE DESIGN ACCORDING TO THE CORVETTE SPECIALIST AT MY LOCAL DEALERSHIP AND AN INDEPENDENT INSPECTOR HIRED BY MY THIRD PARTY WARRANTY COMPANY TO REVIEW MY DAMAGE CLAIM. ALL FOUR WHEELS ON MY VEHICLE HAVE SUFFERED, "CATASTROPHIC" DAMAGE ACCORDING TO THE INVESTIGATION DONE BY AN UNBIASED THIRD PARTY AND REPORTED TO THE WARRANTY COMPANY, WHO SUBSEQUENTLY HAVE DENIED MY CLAIM FOR COVERAGE. ALL FOUR WHEELS ARE BENT ON THE INSIDE OF THE BARREL, WITH ONE ALSO BEING CRACKED (LEFT REAR WHEEL). ACCORDING TO THE INDEPENDENT INSPECTORS REPORT, THE DAMAGE WAS NOT CAUSED BY A ROAD HAZARD, BUT BY A DEFECTIVE OEM DESIGN. NOT ONLY IS THIS A MAJOR SAFETY HAZARD THAT SHOULD NOT BE HAPPENING TO A BRAND NEW $75,000 VEHICLE, GM AND OTHER REGULATORY / GOVERNING BODIES ARE DRAGGING THEIR FEET ON TAKING MEANINGFUL ACTION, PLACING LIVES AT DIRECT RISK. AS HUNDREDS OF OTHERS HAVE REPORTED, GM IS DENYING COVERAGE ACROSS THE BOARD, AND AVOIDING ACKNOWLEDGEMENT OF A DESIGN ISSUE WHILE OWNERS ARE HUNG OUT TO FOOT A $3600 BILL TO REPLACE A SET OF WHEELS. THIS DAMAGE IS DUE TO REGULAR, DAILY DRIVING ON ROADS THAT ARE NOT MAINTAINED TO THE HIGHEST QUALITY, SUCH AS THOSE FOUND IN THE MIDWEST, WHICH IS WHERE THIS VEHICLE HAS BEEN DRIVEN. I HAVE VIDEOS OF THE DAMAGE TO EACH WHEEL (WHEELS ON A ROADFORCE BALANCING MACHINE) I CAN PROVIDE ON REQUEST, AND I'M CERTAIN THE INDEPENDENT INSPECTORS REPORT (WHICH CONTAINED EXTENSIVE VIDEO AND PHOTOGRAPHIC EVIDENCE) CAN ALSO BE OBTAINED BY SOMEONE OF AUTHORITY.