IllustrationINSIDE RIGHT REAR WHEEL CRACKED, CAUSING AIR LEAKAGE FROM TIRE. CAUSE UNKNOWN, NOT AWARE OF ANY ROAD HAZARD OR POT HOLE INCIDENT. NOTICED CRACK AFTER WHEEL DUMP IN WATER BATH TO LOCATE SLOW LEAK. HAVE GM EXTENDED WARRANTY, DEALER WOULD NOT HONOR.
2016 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2016 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
1825–50K
150–75K
075–100K
0100–150K
0150K+
72 reports with mileage · 31 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
Wheels complaints
59 reportsVEH PURCHASED 9/2015 AND SO FAR I HAVE REPLACE FOUR REAR RIMS AND ONE FRONT. ALL HAVE HAIR LINE CRACKS ON THE INSIDE OF RIM CAUSING RADICAL AIR LOSS, VIBRATION AND TIRE WEAR. NAVIGATION SCREEN FLICKERS AND GOES ON AND OFF AT LEAST TWO TIMES A WEEK AND I HAVE TO OPEN AND CLOSE TO RESTART SCREEN. BLOWER MOTOR WENT OUT AT 37K MILES…
Read full complaint
VEH PURCHASED 9/2015 AND SO FAR I HAVE REPLACE FOUR REAR RIMS AND ONE FRONT. ALL HAVE HAIR LINE CRACKS ON THE INSIDE OF RIM CAUSING RADICAL AIR LOSS, VIBRATION AND TIRE WEAR. NAVIGATION SCREEN FLICKERS AND GOES ON AND OFF AT LEAST TWO TIMES A WEEK AND I HAVE TO OPEN AND CLOSE TO RESTART SCREEN. BLOWER MOTOR WENT OUT AT 37K MILES AND THE TRANSMISSION IS BUCKING, VIBRATING, SHUDDERING AND GOING INTO 5TH GEAR AT 31MPH AND FEELS LIKE IT IS HANGING UP IN 5TH GEAR THE CLUNKS DOWN TO FIRST AT 10MPH. WENT TO DEALER, THEY CLAIMED THEY DID A SOFTWARE UP DATE AND THINGS ARE FINE. LEFT THE DEALERSHIP AND CAME BACK 5 MIN LATER WITH SAME ISSUE. TOOK SERVICE MANAGER FOR A RIDE AND HE CONFIRMED THE HORRIBLE RIDE. HAVE TO TAKE BACK ON TUESDAY 5/28 AND IT FEELS LIKE THE DRIVE SHAFT OR REAR END WILL FALL OUT. THEY SAID IT WAS FINE. I HOPE NOTHING HAPPENS TO ME OR THE CAR.
BOTH REAR WHEELS ON MY Z06 CRACKED ON THE INSIDE NO WARPING NO DINGS OR HITS HAPPENED TOOK TO DEALER TO REPLACE TIRES AND WAS SHOWED THAT BOTH WHEELS CRACKED AND NEED TO BE REPLACED TOO DANGEROUS TO USE HAVE PICTURES IN PHONE AND DEALERS REPORT AND I WILL HOLD ON TO THE WHEELS
RIGHT REAR WHEEL CRACKED. LESS THAN 17K MILES. GM SAYS NOT COVERED UNDER B2B WARRANTY. DISCOVERED WHEN TIRE LOSS AIR WHILE DRIVING. DID NOT HIT ANY POT HOLES WHEN EVENT OCCURRED/DISCOVERED. MODEL IS CORVETTE Z06, WHICH IS NOT A CHOICE ABOVE.
I OWN A 2016 CHEVROLET CORVETTE Z06. I NOTICED A WOBBLING SENSATION ON THE HIGHWAY ONLY TO FIND THAT MY REAR WHEELS ARE BENT AND CRACKED! THE CAR HAS LESS THAN 13K MILES ON IT AND IS NOW UNSAFE TO DRIVE UNLESS I SPEND THOUSANDS ON NEW WHEELS.
BENT WHEELS OR RIMS WITH CRACKS THAT HAVE TO BE REPLACED FOR SAFETY.
CORVETTE REAR WHEEL WAS LOSING AIR SO INSPECTED TIRES AND FOUND NO HOLES. WENT TO CORVETTE FORUM TO LEARN THIS IS A KNOWN PROBLEM ON Z06 AND GRAND SPORTS. SEEMS GM HAS A PROBLEM WITH CRACKING. MY CRACK IS EXACTLY WHAT THE FORUM MEMBERS HAVE. HAIRLINE CRACK IN THE RIM ON THE NON-HUB SIDE. THIS IS A SAFETY ISSUE AS THE RIM C…
Read full complaint
CORVETTE REAR WHEEL WAS LOSING AIR SO INSPECTED TIRES AND FOUND NO HOLES. WENT TO CORVETTE FORUM TO LEARN THIS IS A KNOWN PROBLEM ON Z06 AND GRAND SPORTS. SEEMS GM HAS A PROBLEM WITH CRACKING. MY CRACK IS EXACTLY WHAT THE FORUM MEMBERS HAVE. HAIRLINE CRACK IN THE RIM ON THE NON-HUB SIDE. THIS IS A SAFETY ISSUE AS THE RIM COULD COME APART AT SPEED AND CAUSE A SERIOUS ACCIDENT. I HAVE NO OTHER DAMAGE TO THE WHEEL AND HAVE NOT HAD ANY CURB DAMAGE. I BABY THIS CAR AND THE SAME CRACK THAT MANY OTHERS HAVE EXPERIENCED APPEAR.
FACTORY WHEELS CRACKED FROM NORMAL DRIVING ON THE INNER LIP, TIRE MECHANIC ADVISED HE'S SEEN MANY OF THESE ON THE Z06 WHEELS AND IT'S A KNOWN PROBLEM HOWEVER GM WON'T COVER THE DEFECTIVE WHEELS UNDER WARRANTY. THE CRACKED WHEEL CAUSES A SLOW LEAK END EVENTUALLY CAN BREAK IF GONE UNDETECTED RESULTING IN A LOSS OF CONTROL OF THE V…
Read full complaint
FACTORY WHEELS CRACKED FROM NORMAL DRIVING ON THE INNER LIP, TIRE MECHANIC ADVISED HE'S SEEN MANY OF THESE ON THE Z06 WHEELS AND IT'S A KNOWN PROBLEM HOWEVER GM WON'T COVER THE DEFECTIVE WHEELS UNDER WARRANTY. THE CRACKED WHEEL CAUSES A SLOW LEAK END EVENTUALLY CAN BREAK IF GONE UNDETECTED RESULTING IN A LOSS OF CONTROL OF THE VEHICLE.
ON OR ABOUT SEPTEMBER 11, 2018 I NOTICED MY RIGHT FRONT TIRE WAS LOW ON AIR. I TOOK IT TO LES SCHWAB TIRE AND THEY REPAIRED A LEAK FROM A SCREW. A COUPLE OF DAYS LATER I NOTICED THE TIRE WAS STILL GOING LOW I TOOK IT BACK AND THEY INFORMED ME THAT IT HAD A CRACKED WHEEL. I PURCHASED A NEW WHEEL FROM CHEVROLET AND HAD LESS SCHWAB…
Read full complaint
ON OR ABOUT SEPTEMBER 11, 2018 I NOTICED MY RIGHT FRONT TIRE WAS LOW ON AIR. I TOOK IT TO LES SCHWAB TIRE AND THEY REPAIRED A LEAK FROM A SCREW. A COUPLE OF DAYS LATER I NOTICED THE TIRE WAS STILL GOING LOW I TOOK IT BACK AND THEY INFORMED ME THAT IT HAD A CRACKED WHEEL. I PURCHASED A NEW WHEEL FROM CHEVROLET AND HAD LESS SCHWAB INSTALL IT FOR ME . I JUST RECENTLY 2/22/2019 PUT NEW TIRES ON THE CAR AND THE DEALERSHIP NOTED THE BRAND NEW WHEEL I PUT ON THE RIGHT REAR HAS CRACKS IN IT NOW AS WELL AS THE LEFT REAR WHEEL WHICH IS LOSING AIR. THESE WHEELS ARE EXPENSIVE I BELIEVE THEY RETAIL FOR $800 EACH AT THE DEALER AND ARE DEFECTIVE AND DANGEROUS. MOST OF OUR MILES ARE HIGHWAY MILES DRIVING BETWEEN SAN JOSE CALIFORNIA AND ELK GROVE CALIFORNIA BETWEEN MY OFFICES.
WE HAVE HAD TO REPAIR THEN REPLACE 2 REAR CRACKED RIMS IN THE 1.5 YEARS WE HAVE OWNED THIS VEHICLE. THE FIRST ONE WAS 3 MONTHS AFTER PURCHASING IT AND THE SECOND ONE WAS IN JANUARY 2019. AFTER NOTICING BOTH TIMES THAT FIRST THE LEFT TIRE WAS LOSING AIR A HAIRLINE CRACK WAS NOTICED ON THE INSIDE OF THE RIM. WE HAD IT REPAIRED AND…
Read full complaint
WE HAVE HAD TO REPAIR THEN REPLACE 2 REAR CRACKED RIMS IN THE 1.5 YEARS WE HAVE OWNED THIS VEHICLE. THE FIRST ONE WAS 3 MONTHS AFTER PURCHASING IT AND THE SECOND ONE WAS IN JANUARY 2019. AFTER NOTICING BOTH TIMES THAT FIRST THE LEFT TIRE WAS LOSING AIR A HAIRLINE CRACK WAS NOTICED ON THE INSIDE OF THE RIM. WE HAD IT REPAIRED AND IT DID NOT LAST SO FOR SAFETY REASONS WE NEEDED TO REPLACE IT. THE SAME THING HAPPENED WITH THE RIGHT SIDE IN LATE 2018. IT WAS AGAIN SUGGESTED WE REPAIR IT, THEN AGAIN THE REPAIR DID NOT HOLD AND WE NEEDED TO REPLACE.
Official recalls
217V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.