2008 Chevrolet Corvette

Fuel system leak. Strong odor of gasoline fuel both around and inside the vehicle. No noticeable fuel product on the ground or underneath the vehicle. I am greatly concerned that this is a very significant fire and vehicle operator/occupant safety hazard. I have also found many other C6 generation Corvette owners online that are experiencing the same thing to their C6 Corvette.

I am a long time Corvette owner and have purchased many through the years. I recently purchased a 2008 Corvette Coupe with only 30k miles, one owner vehicle. Unbelievable to me, I have had to spend over $4,000 the past month replacing the ECM and most notably the Fuel Pump, to relieve the constant Fuel Smell, not to mention the rack and pinion steering gear needs to be replaced, with again, only 30k miles on the vehicle, and that part is discontinued. The failure of the ECM almost cost my wife and I our life when we were coming home to [XXX] from [XXX] . The car completely lost all power on the highway and we almost got railed by traffic. Not a good situation to say the least. I almost had a heart attack. So we had to have it towed and finally made it home, only to find out the next day after a nice ride, my entire garage was overwhelmed with a gas smell that evening which permeated through the whole house. I took notice that GM covered this exact situation with GM Bulletin # xxx back in 2017, so they KNEW there was a problem! My question is, how can GM not cover this NOW. Many 2008 Corvettes are still being bought and sold. I spent over $2800 for this last week! I am asking you and GM to at least cover 50% of this charge. I don't think that is too much to ask. It's much cheaper than having been sued by our family, should me wife and I have not survived that situation on the road, a case I know they would have won. We should definitely be compensated to say the least! Thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My recently purchased 2008 was taken to the local chevy dealer for gas fumes in the garage. The technician reported "The smell is coming from the sending unit on the driver side. There was fuel dripping down the side of the tank and the tank was wet. So the sending unit needs to be replaced" The car has only 16,427 miles on it and has been garage kept. I believe that leaking fuel is a very serious safety issue and that the now expired special service bulletin 150682 should have been a mandatory recall.

There is a strong smell of gas in the passenger compartment and a very strong smell of gas gas on the drivers side near the rear tire. The Chevy dealer has confirmed the the gas smell is due to a know defect where the fuel pump develops cracks in the housing because of the poor quality plastic used. The dealer estimates that it will cost between $3,000 to $4,000 to repair. This is a very dangerous problem. I'm afraid with the very strong smell of gas that an electric spark might cause the car to explode or when it's stored inside cause a vehicle and structure fire. Why has the NHTSA not made GM do a recall for this defect. It is a very serious problem. Owners of any C6 corvette are sitting on a time bomb and their life is in danger. GM has already admitted that it is a design defect but has only issued a service bulletin. Do something before people die.

This car has suffered a known defect that causes fuel to leak out of the tank when the tank is more than 1/2 full. Unfortunately, the leak in my vehicle occurred outside the window that GM arbitrarily set up. (10 years after vehicle put in service or 120,000 miles whichever comes first. My vehicle is a 2008 with 94,000 miles and the problem occurred recently and after GM's window. Therefore, GM will not fix this leaking fuel tank and correct a potentially life-threatening issue. The problem is that this is a serious safety issue with strong fumes inside the cars cabin and strong fumes outside the vehicle with leaking fuel on the tank. The fumes and the leaking fuel are both extreme fire issues. This is a known issue and a known condition that could cause fire and loss of life. NHTSA needs to issue an immediate safety recall to have GM fix all of these leaking fuel tanks.