IllustrationTHE CAR HAS DEVELOPED A TERRIBLE GASOLINE ODOR. THE CAUSE IS THE FAULTY PLASTIC FITTING AT THE TOP OF THE FUEL PUMP ASSEMBLY. THERE IS A VISIBLE FUEL LEAK RUNNING DOWN THE TANK. THE CAR IS NOT SAFE AND FILLS WITH FUMES. I CANNOT PARK THE CAR INSIDE AND FEAR THAT THE CAR IS DANGEROUS. *TR
2007 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2007 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
8425–50K
6350–75K
3375–100K
16100–150K
4150K+
269 reports with mileage · 72 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports4 fire reports2 injury reports
What owners actually said
341 reportsTL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE VEHICLE WAS EQUIPPED WITH NITROUS SEC FOOSE 8 1/2 BY 19 AND REAR 10 1/2 BY 19(NA) TIRES. THE CONTACT STATED THAT THE TIRES FAILED AND THE SIDEWALLS SPLIT BEFORE THE CONTACT COULD PLACE 100 MILES ON THE TIRES. THE TIRES HAD NOT BEEN REPLACED. THE DOT NUMBER WAS UNKNOWN. THE TIRE…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE VEHICLE WAS EQUIPPED WITH NITROUS SEC FOOSE 8 1/2 BY 19 AND REAR 10 1/2 BY 19(NA) TIRES. THE CONTACT STATED THAT THE TIRES FAILED AND THE SIDEWALLS SPLIT BEFORE THE CONTACT COULD PLACE 100 MILES ON THE TIRES. THE TIRES HAD NOT BEEN REPLACED. THE DOT NUMBER WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS 100. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN.
UPON PARKING THE VEHICLE IN MY GARAGE I NOTICED A VERY STRONG FUEL SMELL EMITTING FROM THE VEHICLE. I SEARCH ALL AROUND THE CAR AND COULD NOT FIND A LEAK. THIS VERY POWERFUL FUEL/GASOLINE SMELL WOULD PERMEATE MY ENTIRE HOUSE CAUSING A BIT OF NAUSEA AT TIMES. I STARTED TO PARK THE CAR OUTSIDE BECAUSE I WAS CONCERNED ABOUT THE POS…
Read full complaint
UPON PARKING THE VEHICLE IN MY GARAGE I NOTICED A VERY STRONG FUEL SMELL EMITTING FROM THE VEHICLE. I SEARCH ALL AROUND THE CAR AND COULD NOT FIND A LEAK. THIS VERY POWERFUL FUEL/GASOLINE SMELL WOULD PERMEATE MY ENTIRE HOUSE CAUSING A BIT OF NAUSEA AT TIMES. I STARTED TO PARK THE CAR OUTSIDE BECAUSE I WAS CONCERNED ABOUT THE POSSIBLE FIRE HAZARD AS WELL AS THE NOXIOUS FUMES. I TOOK THE CAR TO MY LOCAL MECHANIC AND THEY FOUND THAT THE MAIN FUEL PUMP (LOCATED IN THE LEFT SIDE FUEL TANK) HAD BEEN LEAKING FROM THE HIGH PRESSURE SIDE OF THE PUMP. THE PLASTIC THAT FUEL PUMP MODULE IS COMPOSED OF STARTED TO DETERIORATE ON IT'S OWN, AND BEGAN TO SPRAY FUEL ONTO THE TOP OF THE FUEL TANK. THERE IS A LARGE SKID/SUPPORT PLATE THAT HOLDS UP THE FUEL TANK AND THIS PLATE WAS RETAINING A MAJORITY OF THE FUEL. THIS TANK IS ALSO VERY CLOSE TO THE EXHAUST AND I'M JUST FORTUNATE THAT THE FUEL DID NOT SPRAY INTO THAT DIRECTION. AFTER DOING SOME RESEARCH THIS IS A VERY COMMON ISSUE WITH ALL 2005-2013 CORVETTES. SO MANY ISSUES IN FACT THAT AC DELCO (THE VENDOR THAT SUPPLIES THE FUEL PUMP MODULES TO GM) HAS ISSUED 3 UPDATES TO THIS PARTICULAR PART. HERE IS MY OEM PART NUMBER AS WELL AS THE SUBSEQUENT UPDATE PART NUMBERS. MY OE PUMP THAT LEAKED: 15785206 (IS NO LONGER A GOOD AC DELCO #) 1ST UPDATE: 19133441 2ND UPDATE: 19302042 3RD UPDATE: 19149687. *TR
CAR WILL NOT SHIFT OUT OF PARK AFTER STARTING. THIS HAS NOW HAPPENED SEVERAL TIMES. INTERNET SEARCH REVEALS THAT THIS IS A COMMON PROBLEM WITH SOLENOID. *TR
STRONG VAPORS OF RAW FUEL FROM VEHICLE WHEN OVER 1/2 A TANK OF GAS. DEALER COULD NOT LOCATE. GAS LEAK WAS ON TOP OF TANK WHICH WAS NOT VISIBLE FROM UNDERNEATH WITHOUT REMOVAL OF REAR WHEEL WELL. THIS IS DOCUMENTED ON CORVETTE FORUM AS MANY OWNERS HAVE EXPERIENCED THIS ISSUE. IT IS INTERMITTENT AND CAUSED BY CRACKING OF …
Read full complaint
STRONG VAPORS OF RAW FUEL FROM VEHICLE WHEN OVER 1/2 A TANK OF GAS. DEALER COULD NOT LOCATE. GAS LEAK WAS ON TOP OF TANK WHICH WAS NOT VISIBLE FROM UNDERNEATH WITHOUT REMOVAL OF REAR WHEEL WELL. THIS IS DOCUMENTED ON CORVETTE FORUM AS MANY OWNERS HAVE EXPERIENCED THIS ISSUE. IT IS INTERMITTENT AND CAUSED BY CRACKING OF PLASTIC FITTING AT TOP OF THE TANK- APPEARS TO BE A DESIGN DEFECT. *TR
MADE ONLINE CONCERN AND ISSUE WITH LOW BEAM LIGHTS GOING OFF IN 2011. RECALL NOTICE FROM GM; JANUARY 2015, STATES IT WILL INSTALL "JUMPER" WIRE. I ALREADY HAD THIS COMPLETED ON 10/13/2011 WHICH RESULTED AS A SHORT TERM FIX. STILL ENDED UP HAVING PROBLEMS AND EVENTUALLY (HOPING FOR THE RECALL TO TRANSPIRE SOONER) HAVE IT SET UP N…
Read full complaint
MADE ONLINE CONCERN AND ISSUE WITH LOW BEAM LIGHTS GOING OFF IN 2011. RECALL NOTICE FROM GM; JANUARY 2015, STATES IT WILL INSTALL "JUMPER" WIRE. I ALREADY HAD THIS COMPLETED ON 10/13/2011 WHICH RESULTED AS A SHORT TERM FIX. STILL ENDED UP HAVING PROBLEMS AND EVENTUALLY (HOPING FOR THE RECALL TO TRANSPIRE SOONER) HAVE IT SET UP NOW WHERE I NEED TO POP THE HOOD AND INSTALL A 20 AMP FUSE IN ORDER FOR LIGHTS TO GO ON. "JUMPER" FORMAT IS NOT ADEQUATE JUST BE AWARE. THE DESIGN OF THE UBEC UNIT SHOULD BE OVERHAULED TO ACCOMPLISH TWO KEY ISSUES; HEAT AND LESS SHARP BENDS OF THE INTERNAL COPPER WIRING TO PREVENT STRESS AND BREAKING. CURRENTLY ONLY FOG LIGHTS FUNCTION WITHOUT HAVING TO PLUG IN THE 20 AMP FUSE. EVEN MY BRIGHT LIGHTS NEED THE FUSED PLUG IN UNDER THE HOOD. *TR
I AM SMELLING GAS FUMES COMING FROM THE DRIVER SIDE AFTER DRIVING. I CAN HEAR FUEL DRIPPING ON THE EXHAUST WHEN I PARK THE CAR IN MY DRIVEWAY WHICH IS ON AN SLIGHT INCLINE. IF IT IS NOT DRIPPING ON THE EXHAUST IT'S DRIPPING ON SOMETHING HOT BECAUSE IT MAKES A SIZZLING SOUND. PLEASE HELP! SHOULD HAVE A RECALL ABOUT THIS PROBLEM I…
Read full complaint
I AM SMELLING GAS FUMES COMING FROM THE DRIVER SIDE AFTER DRIVING. I CAN HEAR FUEL DRIPPING ON THE EXHAUST WHEN I PARK THE CAR IN MY DRIVEWAY WHICH IS ON AN SLIGHT INCLINE. IF IT IS NOT DRIPPING ON THE EXHAUST IT'S DRIPPING ON SOMETHING HOT BECAUSE IT MAKES A SIZZLING SOUND. PLEASE HELP! SHOULD HAVE A RECALL ABOUT THIS PROBLEM IN MY OPINION. LOTS OF CORVETTE OWNERS ARE DEALING WITH THIS SAME ISSUE. *TR
MY GM SERVICE REQUEST NUMBERB IS:[XXX].THE AUTOMATIC GEAR SELECTOR LEVER OCCASIONALLY GOT STUCK IN PARK (P) AND TOOK A LONG DANGEROUS TIME TO GET IT WORKED LOOSE AND FUNCTIONING PROPERLY. I LIVED WITH IT FOR SEVERAL MONTHS, BUT IT GOT PROGRESSIVELY MUCH WORSE AND MORE DANGEROUS. I SPOKE TO OTHER CORVETTE OWNERS AND FOUND OUT THA…
Read full complaint
MY GM SERVICE REQUEST NUMBERB IS:[XXX].THE AUTOMATIC GEAR SELECTOR LEVER OCCASIONALLY GOT STUCK IN PARK (P) AND TOOK A LONG DANGEROUS TIME TO GET IT WORKED LOOSE AND FUNCTIONING PROPERLY. I LIVED WITH IT FOR SEVERAL MONTHS, BUT IT GOT PROGRESSIVELY MUCH WORSE AND MORE DANGEROUS. I SPOKE TO OTHER CORVETTE OWNERS AND FOUND OUT THAT I HAD A COMMON SAFETY PROBLEM FOR MY MODEL. I FINALLY TOOK THE CAR TO THE DEALER THAT SOLD IT TO ME (MOUNTAIN VIEW CHEVROLET) WHO SAID THEY HAD SEEN A LOT OF THIS DEFECT AND THEY THEN CHARGED ME NEARLY $600 TO CORRECT THIS DANGEROUS DEFECT. NOT RIGHT!!!! IT SHOULD HAVE BEEN RECALLED FROM THE GET-GO AND FIXED PROMPTLY WITHOUT CHARGE. UNABLE TO MOVE IN TRAFFIC, GET OUT OF THE WAY OF DANGER, OR OFF OF RAILWAY TRACKS IS A POTENTIAL KILLER. THERE SHOULD BE A SAFETY RECALL. *TR
STRONG GASOLINE SMELL OUTSIDE AND INSIDE THE VEHICLE WHEN GAS TANK IS OVER 1/2 FULL. *TR
11/15/14 WHILE DRIVING AT NIGHT. ABOUT 30 MIN. INTO MY DRIVE NOTICED THAT MY LOW BEAM HEADLIGHTS WENT OUT. PULLED OVER TO TRY SWITCHING LIGHTS ON AND OFF. STILL WOULD NOT COME BACK ON. HIGH BEAMS AND FOG LIGHTS WORKED. HAD TO DRIVE 15 MIN. WITH FOG LIGHTS AND HIGH BEAMS ON. 12/7/14 DRIVING HOME FROM WORK AT NIGHT,15 MIN. DRIVE…
Read full complaint
11/15/14 WHILE DRIVING AT NIGHT. ABOUT 30 MIN. INTO MY DRIVE NOTICED THAT MY LOW BEAM HEADLIGHTS WENT OUT. PULLED OVER TO TRY SWITCHING LIGHTS ON AND OFF. STILL WOULD NOT COME BACK ON. HIGH BEAMS AND FOG LIGHTS WORKED. HAD TO DRIVE 15 MIN. WITH FOG LIGHTS AND HIGH BEAMS ON. 12/7/14 DRIVING HOME FROM WORK AT NIGHT,15 MIN. DRIVE TO GET HOME. 10 MIN. IN LOW BEAMS GO OUT. SO I DROVE HOME WITH FOG LIGHTS AND HIGH BEAMS ON AGAIN. *TR
Official recalls
214V251000 · Electrical System:wiring; Exterior Lighting:headlights
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence & remedy
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Additional source detail variants (2)
Exterior Lighting:headlights
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
09V491000 · Structure:body:roof And Pillars
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence & remedy
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13007 · Simultaneous Loss Of Low-Beam Headlights
Opened Aug 23, 2013 · Closed Jun 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Additional source detail variants (2)
Exterior Lighting
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
PE13013 · Loss Of Low Beam Headlights
Opened May 6, 2013 · Closed Aug 26, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Additional source detail variants (2)
Exterior Lighting
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221