IllustrationDRIVING ON A 4 LANE HIGHWAY, MY HEADLIGHTS WENT COMPLETELY DEAD AND WOULD NOT COME BACK ON. HAD TO PULL OFF THE HIGHWAY FOR APPROXIMATELY 5 MINUTES. THIS HAS HAPPENED 3 TIMES AFTER DARK. *TR
2004 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2004 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
5725–50K
3050–75K
1475–100K
10100–150K
1150K+
180 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports2 injury reports
What owners actually said
217 reportsCONSUMER WRITES IN REGARDS TO SAFETY ISSUES FOR 2002 AND 2004 CHEVROLET CORVETTES. *TGW THE CONSUMER STATED HE EXPERIENCED A FAILURE OF A MODULE WHICH CONTROLLED THE ABS AND TRACTION CONTROL SYSTEMS. *JB
I FILL UP THE FUEL TANK. GOT HOME AND SMELLED GAS REAL BAD. LEAKING UNDER LEFT TANK. I CALLED DEALERSHIP.THEY WILL NOT DO ANYTHING. THEY SAID TO CALL GM. I CALLED THEY WILL NOT DO NOTHING. I HAVE OWN GM ALL MY LIFE . I WILL NOT BUY A GM NO MORE, THANKS *TR
TL* THE CONTACT OWNS 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE POWER STEERING FAILED CAUSING THE CONTACT TO CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE TURNED OFF. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOTALED AND THE MANUFACTURER WAS NOT MADE AWARE OF…
Read full complaint
TL* THE CONTACT OWNS 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE POWER STEERING FAILED CAUSING THE CONTACT TO CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE TURNED OFF. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOTALED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,900.
DRIVING A 2004 CHEVROLET CORVETTE AT 65 MPH AND ENGINE SHUT DOWN,LUCKILY ABLE TO COAST TO SIDE OF HIGHWAY WITHOUT AN ACCIDENT. I HAD CAR TOWED TO LOCAL CHEVROLET DEALER-WHERE VEHICLE WAS PURCHASED 19 MONTHS PRIOR) DEALER STATED THAT FUEL PUMP INOPERATIVE AND REQUIRED REPLACEMENT..THE TWO FUEL PUMPS( REGULAR FUEL PUMP AND SIPH…
Read full complaint
DRIVING A 2004 CHEVROLET CORVETTE AT 65 MPH AND ENGINE SHUT DOWN,LUCKILY ABLE TO COAST TO SIDE OF HIGHWAY WITHOUT AN ACCIDENT. I HAD CAR TOWED TO LOCAL CHEVROLET DEALER-WHERE VEHICLE WAS PURCHASED 19 MONTHS PRIOR) DEALER STATED THAT FUEL PUMP INOPERATIVE AND REQUIRED REPLACEMENT..THE TWO FUEL PUMPS( REGULAR FUEL PUMP AND SIPHON FUEL PUMP) LOCATED IN FUEL TANKS ,WERE REPLACED AND ALL TANKS AND MUFFLER WERE RE-INSTALLED.THE FUEL PUMPS WERE NOT OPERATING ,SO THE FUEL TANKS WERE REMOVED AGAIN, AND A RELAY WAS FOUND TO BE DEFECTIVE,FINGERS ON RELAY WERE CURLED UP AND NOT ALLOWING FUEL PUMPS TO RUN. THE COST OF REPLACING FUEL PUMPS WAS CHARGED TO ME AT $2700,HOWEVER THE COST OF REPLACING THE RELAY AND ALL PARTS REMOVED TO REPLACE RELAY, WAS CHARGED TO CHEVROLET FOR A DEFECTIVE RELAY.THE VEHICLE WAS PICKED UP FROM DEALER BY ME ON 9/18/2014;THEN RETURNED 9/19/2014 AS GAS VAPORS WERE DETECTED BY ME INSIDE VEHICLE AND IN MY GARAGE. DEALER CURRENTLY HAS VEHICLE-9/21/2014...UPDATED 10/22/14*BF UPDATED 4/7/2015*JS *TR
WHEN BRAKES ARE APPLIED THEY START TO CATCH AND A GRINDING, CHATTERING IS FELT IN THE BRAKES UNTIL I LET UP OFF THE PEDAL. THE ACTIVE HANDLING CODE APPEARS AND THEN GOES AWAY. ON SEVERAL OCCASIONS THE ACTIVE HANDLING CODE APPEARS AND WILL NOT GO AWAY UNTIL THE VEHICLE IS SWITCHED OFF ANF THEN RESTARTED. *TR
AS I WAS DRIVING THE SERVICE ACTIVE HANDLING MESSAGE CAME ON THE DIC.THEN THE CAR BRAKES ENGAGED PULLING THE CAR TO THE LEFT. *JS
SINCE BUYING THIS CAR AT AUCTION. I NOTICED A FUEL SMELL COMING FROM LEFT REAR WHEELS. I HAVE ASKED THE DEALERSHIP IF THERE WERE ANY RECALLS OR SPECIALS ANNOUNCEMENTS DEALING WITH CAR AND WAS TOLD NO. AFTER READING THE CORVETTE FORUM AND FINDING THERE WAS A REPAIR FOR THE FUEL TANK. NOW MY CAR IS OUT OF THE COVERAGE TIME FRAM…
Read full complaint
SINCE BUYING THIS CAR AT AUCTION. I NOTICED A FUEL SMELL COMING FROM LEFT REAR WHEELS. I HAVE ASKED THE DEALERSHIP IF THERE WERE ANY RECALLS OR SPECIALS ANNOUNCEMENTS DEALING WITH CAR AND WAS TOLD NO. AFTER READING THE CORVETTE FORUM AND FINDING THERE WAS A REPAIR FOR THE FUEL TANK. NOW MY CAR IS OUT OF THE COVERAGE TIME FRAME AND MILEAGE HOWEVER WITH THE TANK BEING DEFECTIVE SHOULDN'T THEY AT LEAST COVER THE TANK. OR WHAT WAS THE AGREEMENT BETWEEN NHTSA AND CHEVROLET. *TR
I FILLED MY TANK TODAY WITH NO OVER FLOW OF GAS. I GOT IN MY VEHICLE AND STARTED THE CAR. I NOW HAVE A VERY STRONG GASOLINE SMELL. IT IS ALL THROUGHOUT THE CABIN AND MAKE GAS APPEARS TO BE RUNNING OUT FASTER THAN NORMAL. I PARK IN A GARAGE WHICH HAS A GAS WATER HEATER IN IT. I AM VERY CONCERNED THAT THE HOUSE COULD CATCH ON FIR…
Read full complaint
I FILLED MY TANK TODAY WITH NO OVER FLOW OF GAS. I GOT IN MY VEHICLE AND STARTED THE CAR. I NOW HAVE A VERY STRONG GASOLINE SMELL. IT IS ALL THROUGHOUT THE CABIN AND MAKE GAS APPEARS TO BE RUNNING OUT FASTER THAN NORMAL. I PARK IN A GARAGE WHICH HAS A GAS WATER HEATER IN IT. I AM VERY CONCERNED THAT THE HOUSE COULD CATCH ON FIRE IF THE LEAK GETS STRONGER. *TR
LEAKING GAS. MECHANIC SAYS GAS TANK IS LEAKING NEEDS REPLACED. SEEMS TO BE A PROBLEM WITH THIS CAR YET THERE IS NO RECALL? *TR
Official recalls
204V273000 · Steering:linkages
Jun 9, 2004
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence & remedy
Consequence: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
04V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE10015 · Fuel Tank Leak
Opened May 12, 2010 · Closed Sep 10, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.