IllustrationWhen I start my vehicle, the steering wheel locking system does not disengage and the steering wheel stays locked.
2004 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2004 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
5725–50K
3050–75K
1475–100K
10100–150K
1150K+
180 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports2 injury reports
Electrical System complaints
11 reportsThe contact owns a 2004 Chevrolet Corvette. The contact stated while driving, the vehicle failed to move farther than five feet before the vehicle stalled and lost motive power. The pull-out key and wait-ten-seconds message were displayed. The contact had to release the key from the ignition and restart the vehicle. The contact …
Read full complaint
The contact owns a 2004 Chevrolet Corvette. The contact stated while driving, the vehicle failed to move farther than five feet before the vehicle stalled and lost motive power. The pull-out key and wait-ten-seconds message were displayed. The contact had to release the key from the ignition and restart the vehicle. The contact called an independent mechanic and was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified about the failure. The failure mileage was approximately 30,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WA…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED OUTSIDE THE GARAGE AND THE IGNITION WAS STARTED, THE CLUTCH WAS RELEASED AND THE VEHICLE SEIZED. ALSO, THE STEERING COLUMN LOCK WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V060000…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED OUTSIDE THE GARAGE AND THE IGNITION WAS STARTED, THE CLUTCH WAS RELEASED AND THE VEHICLE SEIZED. ALSO, THE STEERING COLUMN LOCK WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE CONTACT CALLED MAGUIRE CHEVROLET CADILLAC OF ITHACA (LOCATED AT 35 CINEMA DR, ITHACA, NY 14850, (607) 272-9292) AND NOTIFIED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,890. *TR
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE SERVICE ACTIVE HANDLING SYSTEM WARNING MESSAGE ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT WARNING CHIME FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THERMOSTAT, SERPEN…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE SERVICE ACTIVE HANDLING SYSTEM WARNING MESSAGE ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT WARNING CHIME FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THERMOSTAT, SERPENTINE BELT AND TENSIONER BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.
I WAS DRIVING ON A HIGHWAY AT 65MPH IN A BUMPY CONSTRUCTION ZONE. ALL OF A SUDDEN, WITHOUT WARNING, THE ENGINE COMPLETELY SHUT DOWN. I WAS ABLE TO STEER THE CAR OFF TO THE SHOULDER OF THE ROAD. AFTER LETTING THE CAR SIT FOR A MINUTE, I WAS ABLE TO RESTART THE CAR AND IMMEDIATELY DROVE IT BACK HOME ON A SURFACE STREET AND TOOK…
Read full complaint
I WAS DRIVING ON A HIGHWAY AT 65MPH IN A BUMPY CONSTRUCTION ZONE. ALL OF A SUDDEN, WITHOUT WARNING, THE ENGINE COMPLETELY SHUT DOWN. I WAS ABLE TO STEER THE CAR OFF TO THE SHOULDER OF THE ROAD. AFTER LETTING THE CAR SIT FOR A MINUTE, I WAS ABLE TO RESTART THE CAR AND IMMEDIATELY DROVE IT BACK HOME ON A SURFACE STREET AND TOOK IT TO THE DEALER THE NEXT DAY. THE DEALER PUT IT ON THE SCOPE AND COULD FIND NO PROBLEMS WITH THE CAR. THE ONLY THING I COULD THINK OF WAS THAT I HAD A MEDALLION ON THE KEY RING AND THE SERVICE MANAGER ADVISED ME TO ONLY KEEP THE IGNITION KEY ON THE RING BECAUSE THE SWAYING OF THE KEY CHAIN MAY HAVE AFFECTED THE IGNITION SWITCH AND TURNED OFF THE ENGINE. BASED ON THE RECENT INFO ON KEYS SWAYING AND CUTTING OFF THE IGNITION TO THE CAR, I WAS WONDERING IF IT AFFECTED THE CORVETTE MODELS ALSO. I ONLY KEEP THE IGNITION KEY ON THE KEY RING AND HAVEN'T HAD A PROBLEM SINCE THAT TIME. *TR
I WAS DRIVING SOUTH, ON I-25, IN ALBUQUERQUE, NM, WHEN I BUMPED THE IGNITION KEY WITH MY HAND AND THE ENGINE SHUT OFF. THIS OCCURRED A COUPLE OF MORE TIMES SINCE THEN. WHEN I HEARD OF THIS HAPPENING WITH OTHER CHEVROLETS, I CALLED A DEALER, IN ALBUQUERQUE, REPORTED THAT IT HAD ALSO HAPPENED IN MY 2004 CORVETTE C5. THE SERVICE…
Read full complaint
I WAS DRIVING SOUTH, ON I-25, IN ALBUQUERQUE, NM, WHEN I BUMPED THE IGNITION KEY WITH MY HAND AND THE ENGINE SHUT OFF. THIS OCCURRED A COUPLE OF MORE TIMES SINCE THEN. WHEN I HEARD OF THIS HAPPENING WITH OTHER CHEVROLETS, I CALLED A DEALER, IN ALBUQUERQUE, REPORTED THAT IT HAD ALSO HAPPENED IN MY 2004 CORVETTE C5. THE SERVICE MANAGER TOLD ME THERE WERE NO RECALLS, ORDERS, OR TECH ORDERS FOR THAT MODEL CAR. HAVE OTHER OCCURRENCES BEEN REPORTED? I HAVEN'T SEEN ANY ON THE CORVETTE BLOGS. *TR
DRIVING 65 MPH ON INTERSTATE 90 WISCONSIN. CAR JUST DIED,COULD NOT GET TO RESTART. 1 HOUR ON THE SIDE THE ROAD. CARS FLYING INCHES FROM US. POLICE OFFICER FINALLY STOPED AND CALLED TOW TRUCK AND STAYED BEHIND US WITH LIGHTS ON SO WE WOULDNT GET HIT. TO FIND OUT THIS IS A COMMON PROBLEM ON LOW MILAGE CORVETTES. SHOULD BE A RECA…
Read full complaint
DRIVING 65 MPH ON INTERSTATE 90 WISCONSIN. CAR JUST DIED,COULD NOT GET TO RESTART. 1 HOUR ON THE SIDE THE ROAD. CARS FLYING INCHES FROM US. POLICE OFFICER FINALLY STOPED AND CALLED TOW TRUCK AND STAYED BEHIND US WITH LIGHTS ON SO WE WOULDNT GET HIT. TO FIND OUT THIS IS A COMMON PROBLEM ON LOW MILAGE CORVETTES. SHOULD BE A RECALL BECAUSE THE CHEVY DEALER IN MIDDELTON WIS DIDNT KNOW WHAT WAS WRONG, IT KEEPS ON BLOWING THE FUEL PUMP FUSE.THEY THINK,BUT NOT SURE ITS THE FUEL PUMP. 2500.00 TO FIX. CORVETTE FORUM STATES THIS IS A COMMON PROBLEM. THIS IS A SAFETY ISSUE I WOULLD THINK. *TR
VEHICLE CUT OFF WHILE DRIVING @ APPROXIMATELY 25 MPH. DASH INDICATOR READ "CHECK GAUGES". I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND FOUND THAT THE FUEL PUMP FUSE HAD FAILED. TRIED ANOTHER FUSE, BUT IT BLEW IMMEDIATELY. VEHICLE WAS TOWED TO LOCAL CHEVROLET DEALER WHO HAS DIAGNOSED PROBLEM AS BOTH FUEL PUMPS HAVE SHORTS CA…
Read full complaint
VEHICLE CUT OFF WHILE DRIVING @ APPROXIMATELY 25 MPH. DASH INDICATOR READ "CHECK GAUGES". I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND FOUND THAT THE FUEL PUMP FUSE HAD FAILED. TRIED ANOTHER FUSE, BUT IT BLEW IMMEDIATELY. VEHICLE WAS TOWED TO LOCAL CHEVROLET DEALER WHO HAS DIAGNOSED PROBLEM AS BOTH FUEL PUMPS HAVE SHORTS CAUSING THE FUEL PUMP FUSE TO BLOW. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE INVESTIGATED. IT SHOULD BE NOTED THAT AFTER A DAY OF SITTING AT THE DEALERSHIP, THE FUEL PUMP FUSE WAS REPLACED AND THE VEHICLE THEN STARTED ENABLING THE DEALER TO DIAGNOSE THE PROBLEM. CHEVROLET ZONE REP WAS CONTACTED, BUT REFUSED TO HELP. THERE IS OBVIOUSLY AN ISSUE WITH THE FUEL PUMPS AS THE REPLACEMENT FUEL PUMPS FROM CHEVROLET HAVE BEEN REDESIGNED. IT SHOULD BE NOTED THAT VEHICLE HAS ONLY 18,316 MILES. *KB
PROBLEM 1: GASOLINE SMELL WITH LEAK AND ULTIMATE FAILURE OF VALVE TO TRANSFER FUEL FROM ONE TANK TO ANOTHER. OCCURRED CONTINUALLY WITH FUEL TANK REGISTERING FULL TO 3/4 TANK THEN DROPPING TO EMPTY AND VEHICLE APPEARED TO BE OUT OF GAS (WOULD NOT RUN UNTIL FUEL ADDED TO TANK). SOLUTION: TOOK VEHICLE TO CHEVROLET DEALERSHIP …
Read full complaint
PROBLEM 1: GASOLINE SMELL WITH LEAK AND ULTIMATE FAILURE OF VALVE TO TRANSFER FUEL FROM ONE TANK TO ANOTHER. OCCURRED CONTINUALLY WITH FUEL TANK REGISTERING FULL TO 3/4 TANK THEN DROPPING TO EMPTY AND VEHICLE APPEARED TO BE OUT OF GAS (WOULD NOT RUN UNTIL FUEL ADDED TO TANK). SOLUTION: TOOK VEHICLE TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "REPLACED L/S GAS TANK AND PUMP AND SENDER AND REPLACED R/S FUEL PUMP AND SENDER. CHECK FUEL GAUGE AND TANKS FOUND L/S FUEL TANK LEAKING AT TOP OF TANK. WELD ALSO FOUND FUEL LEVEL SENSORS OPEN CIRCUIT AND FUEL SYSTEM NOT TRANSFERRING FUEL FROM TANK TO TANK. RETEST AFTER REPAIRS. OK" PROBLEM 2: A/C DISPLAY LIGHTS DO NOT ILLUMINATE AND CONTROLS ARE DIFFICULT TO SEE AT NIGHT. SOLUTION: TOOK TO CHEVROLET DEALERSHIP FOR REPAIRS. REPAIR INVOICE STATES: "CONTROLLER HAS INTERNAL FAILURE, REPLACED CONTROLLER." *TR
Official recalls
204V273000 · Steering:linkages
Jun 9, 2004
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence & remedy
Consequence: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
04V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE10015 · Fuel Tank Leak
Opened May 12, 2010 · Closed Sep 10, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in connector material processing, variations in the welding process, and high stresses placed on the driver's side connector during vehicle use.GM also identified the scope of the subject vehicles involved to be those produced from approximately October 22, 2003 through March 19, 2004.GM does not believe the cracks represent an unreasonable risk to motor vehicle safety based on factors that include; low rate of fuel leaking to the ground, detectable fuel odor, the cracks are at the top of the tank, leaks are detectable during refueling, small quantities of fuel that leaks out, and no associated property damage or personal injury claims.On August 13, 2010, GM issued a Special Coverage Adjustment to remedy fuel tank quick connector leaks and extend the warranty for this issue to 10 years or 100,000 miles in certain 2004 Chevrolet Corvette and Cadillac XLR vehicles.Vehicle owners will be notified by mail of the adjustment and will also be entitled to reimbursement for previously paid repairs covered under the adjustment.(See file for, SERVICE BULLETIN 10150: SPECIAL COVERAGE ADJUSTMENT-FUEL TANK QUICK CONNECTOR LEAK).The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.