IllustrationWARNING LIGHT OCCURRED ONCE I TRIED WHAT WAS SAID, REMOVE KEY & WAIT 10 SECONDS, DID THIS NUMEROUS TIMES TO NO AVAIL. TRIED TO MOVE CAR ONCE IT HIT 1 MILE PER CAR STALLS. UPON READING MANUAL SAYS IF DOESN'T UNLOCK GAS FLOW IS SHUT OFF & STALLS. CHECKED THE VIN # AGAINST THE RECALL LIST & MY CAR NOT LISTED.
2002 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2002 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
4425–50K
3650–75K
1175–100K
4100–150K
3150K+
130 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
157 reportsTL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING INDICATOR ILLUMINATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE CONTACT EXPERIENCED A FAILURE RELATED TO THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF A …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING INDICATOR ILLUMINATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE CONTACT EXPERIENCED A FAILURE RELATED TO THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF A DEALER COULD REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 07/18/17*LJ THE CONSUMER SAID THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. UPDATED 08/15/2017*JS
PLASTIC FITTING ON COWL FOR RH WINDSHIELD WASHER BROKE AND DISABLED WASHER. ONLY SOURCE FOR THIS PART IS A USED ONE FROM A SALVAGE OPERATION. GM SHOULD SELL SAFETY RELATED PARTS, ESPECIALLY PLASTIC ONES WHICH ARE SUBJECT TO AGING AND BREAKAGE.
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. WHEN THE CONTACT SHIFTED FROM PARK TO DRIVE, THE STEERING WHEEL FAILED TO UNLOCK. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PREVIOUSLY PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. WHEN THE CONTACT SHIFTED FROM PARK TO DRIVE, THE STEERING WHEEL FAILED TO UNLOCK. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PREVIOUSLY PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,500.
AFTER FUELING VEHICLE AND PARKING IN GARAGE THE VEHICLE FOR DAYS WILL SMELL VERY STRONGLY OF GASOLINE UNTIL GALLONS ARE CONSUMED VIA DRIVING TO APPROX. 3/4 OF TANK. VEHICLE IS NOT OVER FILLED ! NO VISUAL INDICATIONS OF FUEL LEAKING ON GROUND. THIS ALSO HAPPENED SINCE ON JULY 12, 2016 LAST TIME VEHICLE WAS FUELED.
BRAKES FAILED WHILE BACKING OUT OF THE GARAGE. AFTER INSPECTION IT WAS DETERMINED THE BRAKE LINE TO THE LEFT REAR WHEEL DEVELOPED A HOLE DUE TO EXCESSIVE RUSTING OF THE STEEL BRAKE LINE.
WHEN THE FUEL TANK IS FILLED THEIR IS AN ENORMOUS GAS SMELL IN AND OUT OF THE CAR.
CAR HAS FUEL LEAK. ONCE I TURN ON THE CAR IT STARTS LEAKING GAS. I COULD BE STATIONARY OR IN MOTION, IT STILL LEAKS GAS. IT ALSO SMELLS TERRIBLE INSIDE MY CAR. I AM WORRIED ABOUT MY HEALTH AND OTHER CORVETTE OWNERS. SOME CORVETTE OWNERS MAY NOT EVEN NOTICE AND NEXT THING YOU KNOW THERE CAR IS ON FIRE. WORSE CASE SCENARIO THEY CO…
Read full complaint
CAR HAS FUEL LEAK. ONCE I TURN ON THE CAR IT STARTS LEAKING GAS. I COULD BE STATIONARY OR IN MOTION, IT STILL LEAKS GAS. IT ALSO SMELLS TERRIBLE INSIDE MY CAR. I AM WORRIED ABOUT MY HEALTH AND OTHER CORVETTE OWNERS. SOME CORVETTE OWNERS MAY NOT EVEN NOTICE AND NEXT THING YOU KNOW THERE CAR IS ON FIRE. WORSE CASE SCENARIO THEY COULD BE INJURED OR EVEN DEATH. THIS IS A SAFETY ISSUE AND GM SHOULD RECALL THIS. IM LUCKY TO BE EVEN WRITING THIS I COULD'VE BLOWN UP WHILE DRIVING THE CAR.
THE PLASTIC PIECE ATTACHING THE HEADLIGHT VERTICAL ADJUSTING MECHANISM TO THE HEAQDLIGHT FRAME BROKE AND FELL OFF, CAUSING LARGE SHIFTS IN THE HEADLIGHT AIM DUE TO ROAD IRRREGULARITIES. CHEVROLET DOES NOT MAKE AVAILABLE DETAIL PARTS OF THIS RATHER COMPLICATED MECHANISM, MAKING IT NECESSARY TO BUY A COMPLETE RETRACTABLE HEADLIGHT…
Read full complaint
THE PLASTIC PIECE ATTACHING THE HEADLIGHT VERTICAL ADJUSTING MECHANISM TO THE HEAQDLIGHT FRAME BROKE AND FELL OFF, CAUSING LARGE SHIFTS IN THE HEADLIGHT AIM DUE TO ROAD IRRREGULARITIES. CHEVROLET DOES NOT MAKE AVAILABLE DETAIL PARTS OF THIS RATHER COMPLICATED MECHANISM, MAKING IT NECESSARY TO BUY A COMPLETE RETRACTABLE HEADLIGHT ASSEMBLY FOR $1,000+. THIS DISCOURAGES PROPER REPAIR OF THIS SAFETY RELATED ISSUE.
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000.
Official recalls
104V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.