Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
4425–50K
3650–75K
1175–100K
4100–150K
3150K+
130 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
157 reports
Mileage unknown · Jul 13, 2004
Structure
A FEW MONTHS AGO I NOTICED MY DRIVER'S DOOR WAS HITTING THE GUIDE WHENEVER I CLOSED THE DOOR. THINKING THE HINGE NEEDED SOME ADJUSTMENT, I TOOK THE CAR TO THE DEALER A COUPLE WEEKS AGO TO FIND OUT HOW TO ADJUST IT OR TO HAVE IT DONE IF IT IS COVERED UNDER THE WARRANTY. THE EVALUATION CONCLUDED THAT THE DOOR (FIBREGLASS) WAS CRAC…
Read full complaint
A FEW MONTHS AGO I NOTICED MY DRIVER'S DOOR WAS HITTING THE GUIDE WHENEVER I CLOSED THE DOOR. THINKING THE HINGE NEEDED SOME ADJUSTMENT, I TOOK THE CAR TO THE DEALER A COUPLE WEEKS AGO TO FIND OUT HOW TO ADJUST IT OR TO HAVE IT DONE IF IT IS COVERED UNDER THE WARRANTY. THE EVALUATION CONCLUDED THAT THE DOOR (FIBREGLASS) WAS CRACKED AND AN ENTIRELY NEW DOOR HAS TO BE INSTALLED (INCLUDING PAINTING IT AND REPAINTING ADJACENT AREAS OF THE BODY.) MY CONCERN IS NOT THE IMMEDIATE FIX, SINCE IT IS COVERED BY THE WARRANTY, BUT IF THIS CONTINUES TO OCCUR IN THE FUTURE, NOT ONLY WILL THE REPAIR COST BE VERY HIGH, BUT THERE WOULD BE A DANGER OF THE DOOR FALLING OFF WHILE DRIVING. THE DEALER TOLD ME THAT THEY HAVE ALREADY REPLACED THREE DOORS AT THEIR FACILITY, SO I PRESUME THE ISSUE MIGHT BE MUCH LARGER NATIONALLY. I AM AWAITING THE REPAIR AT THIS TIME. *LA
NHTSA ODI #10080953
13,000 miles · Jun 14, 2004
Wheels
WHEN DRIVING AT ANY SPEED, THE CONSUMER FELT A VIBRATION COMING FROM THE VEHICLE. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION AND THE MECHANIC DETERMINED THAT ALL FOUR RIMS WERE BENT. *AK THE RIMS WERE BENT FROM NORMAL DRIVING CONDITIONS. *SC *JB
NHTSA ODI #10073872
960 miles · Jun 9, 2004
Electrical SystemSteering
THIS VEHICLE HAS BEEN TO THE DEALERSHIP NUMEROUS TIMES FOR THE FOLLOWING PROBLEMS. THE STEERING COLUMN SYSTEM LOCKED UP 3 TIMES. THE DEALERSHIP SERVICE THE TRACTION MASTER, AND ACTIVE HANDLING SYSTEM SEVERAL TIMES. THIS FAILURE HAS RESULTED IN AN ACCIDENT. THERE'S A RECALL FOR THE ELECTRONIC COLUMN LOCK 04V06000 BUT THE VIN NUM…
Read full complaint
THIS VEHICLE HAS BEEN TO THE DEALERSHIP NUMEROUS TIMES FOR THE FOLLOWING PROBLEMS. THE STEERING COLUMN SYSTEM LOCKED UP 3 TIMES. THE DEALERSHIP SERVICE THE TRACTION MASTER, AND ACTIVE HANDLING SYSTEM SEVERAL TIMES. THIS FAILURE HAS RESULTED IN AN ACCIDENT. THERE'S A RECALL FOR THE ELECTRONIC COLUMN LOCK 04V06000 BUT THE VIN NUMBER ISN'T INCLUDED. CHARGED SYSTEM ONCE. THE CAR IS CURRENTLY SETTING IN MY GARAGE WITH ALL FOUR OF THE ABOVE LISTED PROBLEMS. *AK
NHTSA ODI #10075042
24,000 miles · Jun 8, 2004
Steering
WHILE DRIVING AT ANY SPEED, THE STEERING COLUMN LOCKED. RECALL 04V060000) WAS ISSUED. DEALER REFUSED TO HONOR THE RECALL, STATING THAT THE YEAR OF THE VEHICLE WAS NOT INCLUDED. *AK
NHTSA ODI #10075838
5,000 miles · Jun 4, 2004
Steering
THE STEERING WHEEL LOCKED UP WHEN TURNING TOWARDS THE RIGHT, CAUSING THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. THE OWNER TOOK THE VEHICLE TO THE DEALERSHIP TO BE INSPECTED. *LA *SC *JB
NHTSA ODI #10071905
5,000 miles · May 4, 2004
Steering
WHILE DRIVING AT 40 MPH ELECTRONIC STEERING WHEEL LOCKED UP THE SYSTEM. CONSUMER WAS ABLE TO PULL THE VEHICLE OUT OF ROAD. MANUFACTURER'S ENGINEERING DEPARTMENT AND DEALER'S TECHNICIAN DIDN'T FIND ANYTHING WRONG WITH THE VEHICLE. *AK
NHTSA ODI #10072076
Mileage unknown · Apr 22, 2004
Fuel System, Other
1. WHEN THE FUEL GAUGE READS JUST BELOW HALF, SOMETIMES THE GAUGE WILL SUDDENLY JUMP TO EMPTY. NOTE THAT I NORMALLY REFILL THE TANK (COMPLETELY FULL) WHEN THE FUEL GAUGE READS ABOUT ONE EIGHTH OF A TANK REMAINING.*AK 2. WHEN THIS FAILURE OCCURS, THE VEHICLE CAN ONLY BE DRIVEN A FEW MILES BEFORE RUNNING OUT OF FUEL. THIS HAS HAP…
Read full complaint
1. WHEN THE FUEL GAUGE READS JUST BELOW HALF, SOMETIMES THE GAUGE WILL SUDDENLY JUMP TO EMPTY. NOTE THAT I NORMALLY REFILL THE TANK (COMPLETELY FULL) WHEN THE FUEL GAUGE READS ABOUT ONE EIGHTH OF A TANK REMAINING.*AK 2. WHEN THIS FAILURE OCCURS, THE VEHICLE CAN ONLY BE DRIVEN A FEW MILES BEFORE RUNNING OUT OF FUEL. THIS HAS HAPPENED FOUR TIMES, ALL IN THE LAST FOUR MONTHS. 3. I TOOK IT TO THE DEALERSHIP THAT I PURCHASED IT FROM AND THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM AND THEREFORE THEY WOULD DO NOTHING ABOUT IT. I CALLED THE GM SERVICE COMPLAINT NUMBER AND THEY STATED THEY WOULD DO NOTHING TO ASSIST ME IN GETTING THIS PROBLEM FIXED.
NHTSA ODI #10067687
Mileage unknown · Mar 2, 2004
Fuel System, Other
WHILE DRIVING 85 MPH VEHICLE STALLED. VEHICLE HAS BEEN SERVICED SEVEN TIMES DUE TO STALLING ONCE THE FUEL GAUGE REACHED 3/8. THE DEALERSHIP WAS GOING TO REPLACE THE FUEL GAUGE AGAIN.*AK
NHTSA ODI #10061113
33,500 miles · Mar 1, 2004
SteeringCrash
WHILE DRIVING DRIVER WAS UNABLE TO STEER BECAUSE THE STEERING COLUMN LOCKED. THIS CAUSED THE VEHICLE TO HIT A CURB, AND THE FRONT LEFT WHEEL DETACHED FROM THE VEHICLE. CONSUMER HAD VEHICLE TOWED TO THE DEALER, BUT PROBLEM WAS NOT RESOLVED. *AK
NHTSA ODI #10061059
715 miles · Feb 17, 2004
Electrical System
NUMEROUS PROBLEMS WITH COMPUTER READOUT MESSAGE: SERVICE ABS, SERVICE ACTIVE HANDLING AND SERVICE TRACTION CONTROL. *PH THE VEHICE WAS TAKEN TO TE DEALER SEVERAL TIMES BUT THEY WERE UNABLE TO UNABLE TO RECTIFY THE PROBLEM. *NM
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
2002 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration