THE RIGHT REAR OEM FORGED ALUMINUM WHEEL ON THE 2002 CORVETTE HAS DEVELOPED A CRACK. DISCUSSION OF THIS CORVETTE WHEEL CRACKING ISSUE ON VARIOUS WEB FORUMS HAS INDICATED THAT MANY OF THESE SAME OEM CORVETTE WHEELS HAVE CRACKED. I CONSIDER THIS CRACKED WHEEL UNSAFE SINCE IT COULD LEAD TO CATASTROPHIC WHEEL FAILURE AND AN ACCID…
Read full complaint
THE RIGHT REAR OEM FORGED ALUMINUM WHEEL ON THE 2002 CORVETTE HAS DEVELOPED A CRACK. DISCUSSION OF THIS CORVETTE WHEEL CRACKING ISSUE ON VARIOUS WEB FORUMS HAS INDICATED THAT MANY OF THESE SAME OEM CORVETTE WHEELS HAVE CRACKED. I CONSIDER THIS CRACKED WHEEL UNSAFE SINCE IT COULD LEAD TO CATASTROPHIC WHEEL FAILURE AND AN ACCIDENT.*AK
NHTSA ODI #10195921
Mileage unknown · Apr 26, 2007
Wheels
I HAVE A 2002 C5 CORVETTE, THE REAR RIM HAS A CRACK IN THE SPOKE. I WENT ON CORVETTE FORUM TO SEE IF OTHERS HAVE HAD THIS PROBLEM. THERE WHERE SEVERAL OTHER PEOPLE THAT HAD THE SAME ISSUE. SEVERAL HAD TAKEN THERE CARS TO THE DEALERS, SOME UNDER WARRANTY SOME NOT AND GM WOULD NOT REPLACE THE RIMS. THIS LINK WAS ACTUALLY ON THE C…
Read full complaint
I HAVE A 2002 C5 CORVETTE, THE REAR RIM HAS A CRACK IN THE SPOKE. I WENT ON CORVETTE FORUM TO SEE IF OTHERS HAVE HAD THIS PROBLEM. THERE WHERE SEVERAL OTHER PEOPLE THAT HAD THE SAME ISSUE. SEVERAL HAD TAKEN THERE CARS TO THE DEALERS, SOME UNDER WARRANTY SOME NOT AND GM WOULD NOT REPLACE THE RIMS. THIS LINK WAS ACTUALLY ON THE CORVETTE FORUM ASKING PEOPLE TO WRITE TO YOU AND POSSIBLY GET A SAFETY RECALL STARTED. I ONLY HAVE 39000 MILES 0N THE CAR. I FEEL THIS IS A BIG SAFETY ISSUE, I DIDN'T NOTICE IT UNTIL I HAD NEW TIRES PUT ON AND THE MECHANIC TOLD ME. THIS COULD BE A VERY DANGEROUS ISSUE SHOULD THE RIMS COME APART ON THE HIGHWAY. CAN YOU PLEASE SEE IF OTHERS HAVE REPORTED SIMILAR ISSUES, I DON'T KNOW WHAT IT TAKES FOR A RECALL TO BE ISSUED, BUT I FEEL OBLIGATED TO REPORT IT. *JB
NHTSA ODI #10189068
33,565 miles · Apr 25, 2007
Wheels
RIGHT REAR STOCK RIM ON A 2002 CORVETTE COUPE IS CRACKED. CAR ONLY HAS 33,000 MILES ON IT. I WILL HAVE TO GET A NEW RIM IN ORDER TO FIX THE ISSUE. *TR
NHTSA ODI #10188811
20,000 miles · Mar 26, 2007
Wheels
THE CHROMED WHEELS ON MY 2002 CHEVROLET CORVETTE ARE CRACKED. ALL 4 WHEES ARE CRACKED AND ON ONE WHEEL 3 OUT OF FIVE SPOKES ARE CRACKED ALMOST COMPLETELY THROUGH. *AK
NHTSA ODI #10186202
27,500 miles · Mar 18, 2007
Wheels
CRACKS IN THE CASTED SPOKES OF MY 2002 CHEVROLET CORVETTE
NHTSA ODI #10185453
35,500 miles · Aug 20, 2006
Wheels
THE DRIVER SIDE REAR WHEEL ON MY 2002 CORVETTE COUPE HAS A CRACK IN 2 OF THE SPOKES. I TOOK IT IN TO MY CHEVY DEALER (CREST CHEVROLET), THEY TOOK PICTURES AND SUBMITTED A CLAIM TO GM. THE GM REP. HAD THE DEALER TAKE THE TIRE OFF THE WHEEL AND SEE IF THE CRACKS GO THROUGH TO THE INSIDE AND GET THE FACTORY NUMBER OFF THE INSIDE & …
Read full complaint
THE DRIVER SIDE REAR WHEEL ON MY 2002 CORVETTE COUPE HAS A CRACK IN 2 OF THE SPOKES. I TOOK IT IN TO MY CHEVY DEALER (CREST CHEVROLET), THEY TOOK PICTURES AND SUBMITTED A CLAIM TO GM. THE GM REP. HAD THE DEALER TAKE THE TIRE OFF THE WHEEL AND SEE IF THE CRACKS GO THROUGH TO THE INSIDE AND GET THE FACTORY NUMBER OFF THE INSIDE & VERIFY IT WAS A GM WHEEL. THE DEALER SERVICE REP CALLED ME AND SAID GM AGREED TO PAY FOR HALF THE COST OF THE WHEEL. I TOLD THE SERVICE MANAGER THAT GM'S OFFER WAS NOT SATISFACTORY AND I WOULD PROCEED IN FILING FORMAL COMPLAINTS. THEY FACT THAT THESE WHEELS ARE A PROBLEM THAT GM IS AWARE OF HAS BEEN DISCUSSED AND DOCUMENTED ON THE CORVETTEFORUM.COM WEBSITE. HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T=1461736. *JB
NHTSA ODI #10166064
26,883 miles · May 8, 2006
Wheels
FOUND STRESS CRACKS IN REAR WHEELS OF 2004 CHEVROLET CORVETTE WAITING FOR DEALER TO CORRECT THE PROBLEM DON'T WANT TO WAIT FOR INJURY, PROPERTY DAMAGE, OR DEATH. *JB
NHTSA ODI #10156987
11,118 miles · Apr 30, 2006
Wheels
2002 CHEVROLET CORVETTE WITH CRACKED WHEELS. *JB
NHTSA ODI #10156457
Mileage unknown · Mar 18, 2006
Wheels
I AM ORIGINAL OWNER OF 2002 CORVETTE COUPE. IT CAME WITH OPTIONAL THIN SPOKE POLISHED ALUMINUM WHEELS. MY DRIVER REAR HAS A STRESS CRACK WHERE THE FORK MEETS THE RIM. MANY OF MY FELLOW CORVETTE FRIENDS HAVE SAME ISSUE. MY CAR HAS 30400 MILES ON THE ODO. SEE FORUM THREAD HERE: HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T…
Read full complaint
I AM ORIGINAL OWNER OF 2002 CORVETTE COUPE. IT CAME WITH OPTIONAL THIN SPOKE POLISHED ALUMINUM WHEELS. MY DRIVER REAR HAS A STRESS CRACK WHERE THE FORK MEETS THE RIM. MANY OF MY FELLOW CORVETTE FRIENDS HAVE SAME ISSUE. MY CAR HAS 30400 MILES ON THE ODO. SEE FORUM THREAD HERE: HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T=1300651&PAGE=1&PP=20 THANK YOU FOR CHECKING INTO THIS.*JB
NHTSA ODI #10153087
55,000 miles · Mar 7, 2006
Wheels
STOCK GM HIGH POLISHED RIGHT REAR CORVETTE C5 18" X 9.5" WHEEL CRACKED. TIRE WENT FLAT, DISCOVERED CRACKS AT 2 SPOKES, LEAKING AIR THROUGH CRACKS REPLACED WHEEL WITH ATERMARKET. *JB UPDATED 05/01/06
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
2002 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration