NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
25 reportsClear category filterMileage unknown · Apr 5, 2005
Electrical SystemEngine And Engine CoolingStructure
AFTER STARTING THE VEHICLE AND DRIVING OFF THE ENGINES STALLED. AFTER THE VEHICLE WAS REPAIRED, THE VEHICLE WAS DRIVEN FOR ABOUT 600 MILES AND IT LOCKED UP AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP. *AK WHEN THE VEHICLE WAS PARKED, A WARNING CHIME WOULD SOUND. WHEN STARTING THE VEHICLE, IT WOULD ONLY MOVE SEVER…
Read full complaint
AFTER STARTING THE VEHICLE AND DRIVING OFF THE ENGINES STALLED. AFTER THE VEHICLE WAS REPAIRED, THE VEHICLE WAS DRIVEN FOR ABOUT 600 MILES AND IT LOCKED UP AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP. *AK WHEN THE VEHICLE WAS PARKED, A WARNING CHIME WOULD SOUND. WHEN STARTING THE VEHICLE, IT WOULD ONLY MOVE SEVERAL FEET THEN THE FUEL WILL SHUT OFF, CAUSING THE VEHICLE TO STALL IN TRAFFIC. THE VEHICLE HADN'T BEEN ABLE TO BE REPAIRED. OTHER PROBLEMS: THE LOCK CLYINDER WAS NOT READING WHEN THE KEY WAS REMOVED, THEN WHEN THE KEY WAS INSERTED, THE VEHICLE READ THEFT ATTEMPT AND LOCK OUT, A COLUMN LOCK MESSAGE APPEARED ON THE DASH AND THERE WAS A RATTLE IN THE DRIVERS DOORS DUE TO DOOR SPERATION. *SC
NHTSA ODI #10115168
3,900 miles · Jul 9, 2004
Engine And Engine Cooling
AT 3,900 MILES MY NEW CAR WAS DOWN 1QUART OF OIL. UPON QUESTIONING I FOUND THIS WAS COMMON PROBLEM WITH 2001 CORVETTES. AT 15000 MILES GM REPLACE PISTONS BUT SAID THAT IT IS ACCEPTABLE BY GM STARDARDS FOR THE CORVETTE TO BURN A QUART OF OIL EVERY 900 MILES. HOWEVER THEY WON'T GIVE ME INFORMATION IN WRITING ONLY TO MY LAWGER WHIC…
Read full complaint
AT 3,900 MILES MY NEW CAR WAS DOWN 1QUART OF OIL. UPON QUESTIONING I FOUND THIS WAS COMMON PROBLEM WITH 2001 CORVETTES. AT 15000 MILES GM REPLACE PISTONS BUT SAID THAT IT IS ACCEPTABLE BY GM STARDARDS FOR THE CORVETTE TO BURN A QUART OF OIL EVERY 900 MILES. HOWEVER THEY WON'T GIVE ME INFORMATION IN WRITING ONLY TO MY LAWGER WHICH I DON'T FEEL NEEDED YET. I ALSO HAD A FRIEND WHO HAS SAME YEAR CORVETTE AS MINE AND HE TWO IS BURNING OIL. IT IS A KNOW PROBLEM EVEN IN GM WEB SITES FOR IT MECHANICS. PLEASE HELP I'M TIRED OF CHECKING OIL AND REPORTING CONSUMPTION TO DEALERSHIP I DIDN'T PURCHASE A 50,000 CAR FOR THIS.*AK
NHTSA ODI #10080653
28,000 miles · Jan 15, 2004
Engine And Engine Cooling
THIS 2001 CORVETTE WAS TAKEN TO THE DEALER ON SEP T12TH, 2003 FOR ENGINE FAILURE. PISTONS, RODS, BEARINGS & RELATED PARTS WERE REPLACED. VEHICLE WAS RETURNED TO ME 4 WEEKS LATER. AS OF 10/22/03 VEHICLE HAS BEEN RETURNED TO THE DEALER TWICE FOR RELATED ENGINE PROBLEMS & IS IN THEIR SHOP AT THIS TIME WITH NO ESTIMATED COMPLETION…
Read full complaint
THIS 2001 CORVETTE WAS TAKEN TO THE DEALER ON SEP T12TH, 2003 FOR ENGINE FAILURE. PISTONS, RODS, BEARINGS & RELATED PARTS WERE REPLACED. VEHICLE WAS RETURNED TO ME 4 WEEKS LATER. AS OF 10/22/03 VEHICLE HAS BEEN RETURNED TO THE DEALER TWICE FOR RELATED ENGINE PROBLEMS & IS IN THEIR SHOP AT THIS TIME WITH NO ESTIMATED COMPLETION TIME. I HAVE NOT BEEN OFFERED ANY SUBSTITUTE TRANSPORTATION. GM CUSTOMER ASSISTANCE WILL DO NOTHING AND HAS REFUSED TO EXTEND THE WARRANTY OR PROVIDE COMPENSATION FOR LOST USE OF THIS $52,000 VEHICLE.
NHTSA ODI #10071086
Mileage unknown · Jun 17, 2003
Engine And Engine CoolingEquipmentExterior Lighting
NAR 06/19/2003. *MR THE CONSUMERS VEHICLE WAS IN NEED OF NUMEROUS REPAIRS. VOLUNTARY EMISSION RECALL- REPROGRAM THE POWERTRAIN CONTROL MODULE. EXCESSIVE ENGINE OIL CONSUMPTION. ENGINE KNOCKING NOISE. FUEL GAUGE DROPPED TO EMPTY, DRIVER SEAT IS COMING APART, STEERING COLUMN LOCK. AIR CONDITIONER HAS A BAD ODOR. INABILITY TO …
Read full complaint
NAR 06/19/2003. *MR THE CONSUMERS VEHICLE WAS IN NEED OF NUMEROUS REPAIRS. VOLUNTARY EMISSION RECALL- REPROGRAM THE POWERTRAIN CONTROL MODULE. EXCESSIVE ENGINE OIL CONSUMPTION. ENGINE KNOCKING NOISE. FUEL GAUGE DROPPED TO EMPTY, DRIVER SEAT IS COMING APART, STEERING COLUMN LOCK. AIR CONDITIONER HAS A BAD ODOR. INABILITY TO LOCK CAR DOORS. RADIO PRODUCES LOUD STATIC, AND SPEAKERS RATTLE. HEADLIGHTS HAVE A BAD BATTERY AND THE REAR VIEW MIRROR DOESN'T DIM. *CB *JB
NHTSA ODI #10024455
7,500 miles · May 14, 2003
Engine And Engine Cooling
OIL CONSUMPTION IS ABOVE NORMAL FOR A NEW ENGINE. I HAVE EXPERIENCED THE CONSUMPTION OF MORE THAT ONE QUART PER 1000 MILES. DEALER INITIALLY STATED THAT THIS WAS NORMAL FOR A NEW ENGINE AND WOULD IMPROVE AFTER A GOOD BREAK-IN PERIOD. PROBLEM REMAINS. RESEARCH HAS SHOWN THAT THERE IS AN ACKNOWLEDGED PROBLEM WITH EXCESSIVE OIL…
Read full complaint
OIL CONSUMPTION IS ABOVE NORMAL FOR A NEW ENGINE. I HAVE EXPERIENCED THE CONSUMPTION OF MORE THAT ONE QUART PER 1000 MILES. DEALER INITIALLY STATED THAT THIS WAS NORMAL FOR A NEW ENGINE AND WOULD IMPROVE AFTER A GOOD BREAK-IN PERIOD. PROBLEM REMAINS. RESEARCH HAS SHOWN THAT THERE IS AN ACKNOWLEDGED PROBLEM WITH EXCESSIVE OIL CONSUMPTION. CATALYTIC CONVERTER AND EXHAUST PIPES SHOW SIGNIFICANT BLACK OILY RESIDUE. CONCERNED ABOUT POTENTIAL FIRE FROM CATALYTIC CONVERTER. ALSO CONCERNED ABOUT ENVIRONMENTAL EFFECTS. CHEVROLET NEEDS TO TAKE POSITIVE ACTION TO RESOLVE ISSUE. *NLM
NHTSA ODI #10018690
50,000 miles · Apr 9, 2003
Engine And Engine Cooling
THE VEHICLES INTAKE MANIFOLD GASKET BLEW OUT. THE DEALER WAS NOTIFIED. *NLM
NHTSA ODI #10015527
Mileage unknown · Apr 8, 2003
Engine And Engine Cooling
THE ENGINE BURNS EXCESSIVE AMOUNT OF ENGINE OIL. *NLM
NHTSA ODI #10014104
Mileage unknown · Jun 20, 2002
Engine And Engine CoolingSeat BeltsStructure
VEHICLE CONSUMES TOO MUCH OIL DUE TO A DEFECTIVE A MOTOR. CONTACTED DEALER. *AK THE VEHICLE HAD BEEN TO THE DEALER FIVE TIMES FOR COLD PISTON KNOCK PROBLEMS. THE DEALER REPLACED RINGS TWICE, BUT WAS UNABLE TO CORRECT THE PROBLEM. THE LOW OIL LIGHT CAME ON DUE TO EXCESSIVE OIL CONSUMPTION. THE CONSUMER HAD BEEN TO THE DEALERSHIP …
Read full complaint
VEHICLE CONSUMES TOO MUCH OIL DUE TO A DEFECTIVE A MOTOR. CONTACTED DEALER. *AK THE VEHICLE HAD BEEN TO THE DEALER FIVE TIMES FOR COLD PISTON KNOCK PROBLEMS. THE DEALER REPLACED RINGS TWICE, BUT WAS UNABLE TO CORRECT THE PROBLEM. THE LOW OIL LIGHT CAME ON DUE TO EXCESSIVE OIL CONSUMPTION. THE CONSUMER HAD BEEN TO THE DEALERSHIP TEN TIMES FOR PROBLEMS RELATED TO EXCESSIVE OIL USE. THE DRIVER SIDE SEAT BELT RETRACTOR HAD FAILED, BUT THE DEALER REPLACED THE LEFT SIDE SHOULDER ASSEMBLY. THE PASSENGER DOOR OPENING WEATHER STRIP HAD GLUE COMING OUT. ARBITRATOR DENIED THE CONSUMERS REQUEST FOR THE MANUFACTURER REPURCHASE OF THE VEHICLE. *YH
NHTSA ODI #8012288
Mileage unknown · May 28, 2002
Electrical SystemEngine And Engine CoolingEquipment
SENSOR ON DRIVER'S DOOR HAS BEEN REPLACED NUMEROUS TIMES, INTERMITTENTLY DRIVERS DOOR WILL NOT RESPOND TO REMOTE OPTION.*AK CUSTOMER STATED THAT OIL LEAKED FROM ENGINE AREA. THE DRIVER DOOR RATTLES WHILE DRIVING AND WAS HARD TO CLOSE. THE RIGHT DOOR GLASS HAS WIND NOISE DUE TO DOOR GLASS FAILURE. BRAKES FAILED TO GRAB. THERE W…
Read full complaint
SENSOR ON DRIVER'S DOOR HAS BEEN REPLACED NUMEROUS TIMES, INTERMITTENTLY DRIVERS DOOR WILL NOT RESPOND TO REMOTE OPTION.*AK CUSTOMER STATED THAT OIL LEAKED FROM ENGINE AREA. THE DRIVER DOOR RATTLES WHILE DRIVING AND WAS HARD TO CLOSE. THE RIGHT DOOR GLASS HAS WIND NOISE DUE TO DOOR GLASS FAILURE. BRAKES FAILED TO GRAB. THERE WAS A NOISE WHILE DRIVING DUE TO LEFT SEAT BELT RETRACTOR FAILURE. CONSUMER STATES CD CHARGER WOULD NOT EJECT CD CARTRIDGE, THE STEERING TILT WAS INOPARTIVE, THE DOOR RATTLED, THE SEATS WOULD NOT HOLD PROGRAMMING. *YH
NHTSA ODI #8010559
Mileage unknown · Jan 19, 2002
Engine And Engine Cooling
CONSUMER STATES HE HAS DRIVEN THE VEHICLE 5,600 MILES WITH A LOSS OF 2 QUARTS OF ENGINE OIL, CONSUMER WAS INFORMED THAT THE OIL CONSUMPTION IS NORMAL, CONSUMER STATES THAT THE OIL IS BEING BLOWN INTO THE EXHAUST SYSTEM DUE TO A FAULTY ENGINE DESIGN.*JB
NHTSA ODI #564117
NHTSA investigations
2EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
Illustration