WE JUST PURCHASED A 2001 CORVETTE COUPE 2 MONTHS AGO. I HAVE HAD A PROBLEM WHEN THE SIGNAL LIGHTS (BOTH) JUST QUIT OPERATING--NO LIGHTS, NO CLICKING, NOTHING, IN AN INSTANT. AFTER A PERIOD OF TIME, THEY WILL WORK AGAIN. HAVE TAKEN THE FUSE OUT AND REINSTALLED IT IN CASE IT MIGHT HAVE BEEN LOOSE. SEEMED TO WORK FOR ABOUT 2 WE…
Read full complaint
WE JUST PURCHASED A 2001 CORVETTE COUPE 2 MONTHS AGO. I HAVE HAD A PROBLEM WHEN THE SIGNAL LIGHTS (BOTH) JUST QUIT OPERATING--NO LIGHTS, NO CLICKING, NOTHING, IN AN INSTANT. AFTER A PERIOD OF TIME, THEY WILL WORK AGAIN. HAVE TAKEN THE FUSE OUT AND REINSTALLED IT IN CASE IT MIGHT HAVE BEEN LOOSE. SEEMED TO WORK FOR ABOUT 2 WEEKS WITHOUT A PROBLEM, THEN SUDDENLY STOPPED WORKING AGAIN. THERE IS NO LOGICAL SEQUENCE OF EVENTS WHEN THIS HAPPENS. GM DEALERSHIP PUT IT ON THE COMPUTER BUT COULD NOT DETECT ANYTHING. THEY INDICATED THAT THE SIGNALS WOULD HAVE TO BE 'NOT WORKING' WHEN I BROUGHT IT IN FOR THEM TO TELL WHAT WAS HAPPENING. THIS IS A POTENTIALLY DANGEROUS SITUATION, ESPECIALLY DURING HIGHWAY DRIVING. *NLM
NHTSA ODI #10023317
Mileage unknown · May 28, 2002
Electrical SystemEngine And Engine CoolingEquipment
SENSOR ON DRIVER'S DOOR HAS BEEN REPLACED NUMEROUS TIMES, INTERMITTENTLY DRIVERS DOOR WILL NOT RESPOND TO REMOTE OPTION.*AK CUSTOMER STATED THAT OIL LEAKED FROM ENGINE AREA. THE DRIVER DOOR RATTLES WHILE DRIVING AND WAS HARD TO CLOSE. THE RIGHT DOOR GLASS HAS WIND NOISE DUE TO DOOR GLASS FAILURE. BRAKES FAILED TO GRAB. THERE W…
Read full complaint
SENSOR ON DRIVER'S DOOR HAS BEEN REPLACED NUMEROUS TIMES, INTERMITTENTLY DRIVERS DOOR WILL NOT RESPOND TO REMOTE OPTION.*AK CUSTOMER STATED THAT OIL LEAKED FROM ENGINE AREA. THE DRIVER DOOR RATTLES WHILE DRIVING AND WAS HARD TO CLOSE. THE RIGHT DOOR GLASS HAS WIND NOISE DUE TO DOOR GLASS FAILURE. BRAKES FAILED TO GRAB. THERE WAS A NOISE WHILE DRIVING DUE TO LEFT SEAT BELT RETRACTOR FAILURE. CONSUMER STATES CD CHARGER WOULD NOT EJECT CD CARTRIDGE, THE STEERING TILT WAS INOPARTIVE, THE DOOR RATTLED, THE SEATS WOULD NOT HOLD PROGRAMMING. *YH
NHTSA ODI #8010559
Mileage unknown · May 21, 2002
Electrical SystemFire
WHILE TRAVELING ON HIGHWAY SMELLED AN ODOR. IT WAS SMOKE COMING FROM UNDERNEATH VEHICLE.*AK
NHTSA ODI #8010258
Mileage unknown · Jan 19, 2002
Electrical SystemSteeringVehicle Speed Control
ACTIVE HANDLING SYSTEM MALFUNCTION - ON THREE SEPARATE OCCASIONS DURING A RECENT ROAD TRIP, I EXPERIENCED A MOMENTARY LOSS OF DIRECTIONAL CONTROL WHILE DRIVING MY VEHICLE AT HIGHWAY SPEEDS. ON EACH OCCASION, I WAS FORTUNATE TO QUICKLY REGAIN CONTROL OF THE VEHICLE AFTER IT INVOLUNTARILY VEERED TO THE LEFT AND CROSSED INTO THE…
Read full complaint
ACTIVE HANDLING SYSTEM MALFUNCTION - ON THREE SEPARATE OCCASIONS DURING A RECENT ROAD TRIP, I EXPERIENCED A MOMENTARY LOSS OF DIRECTIONAL CONTROL WHILE DRIVING MY VEHICLE AT HIGHWAY SPEEDS. ON EACH OCCASION, I WAS FORTUNATE TO QUICKLY REGAIN CONTROL OF THE VEHICLE AFTER IT INVOLUNTARILY VEERED TO THE LEFT AND CROSSED INTO THE ADJACENT LANE OF TRAVEL. SHORTLY THEREAFTER, A DASH BOARD MESSAGE APPEARED : "SERVICE ACTIVE HANDLING". UPON ARRIVAL AT MY DESTINATION, I HAD MY VEHICLE SERVICED AT AN OUT OF TOWN CHEVEROLET DEALER. AFTER CONSULTING WITH GENERAL MOTORS, THE DEALER EXAMINED THE VEHICLE BUT WAS UNABLE TO PROVIDE A "FIX" FOR THE PROBLEM. I ASKED THE DEALER IF THEY WERE AWARE OF ANY SIMILAR PROBLEMS WITH OTHER CORVETTES - THEY RESPONDED - "NO". ACCELERATION DISRUPTION ISSUE - THIS HAS BEEN A PROBLEM SINCE DAY ONE AND CONTINUESS THROUGH TODAY. THE PROBLOEM IS MOST APPARENT WHEN I ATTEMPT TO MERGE INTO TRAFFIC UPON ENTERING A FREEWAY. "EXCESSIVE HEAT" - AS WITH THE ACCELERATION ISSUE , THIS PROBLEM HAS EXISTED SINCE BUYING MY VEHICLE IN AUGUST OF 2000. I PLAN TO HAVE WARRANTY SERVICE WITH RESPECT TO THE ACCELERATION AND HEAT ISSUES SOMETIME IN THE VERY NEAR FUTURE.*AK
NHTSA ODI #757075
Mileage unknown · Jul 12, 2001
Electrical System
2001 CORVETTE Z06- INTERMITTENT PROBLEM-ENGINE TURNS OVER WHEN STARTING BUT FAILS TO CONTINUE RUNNING WHEN STARTER DISENGAGED
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
2001 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration