NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
277 reports41,000 miles · Nov 10, 2014
Steering
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL SEIZED AS THE SERVICE STEERING COLUMN LOCK LIGHT ILLUMINATED. AS A RESULT, THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL SEIZED AS THE SERVICE STEERING COLUMN LOCK LIGHT ILLUMINATED. AS A RESULT, THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING).THE MANUFACTURER HAS NOT BEEN MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10653914
70,000 miles · Nov 10, 2014
Electronic Stability Control (esc)Service Brakes
I WAS DRIVING ON A MAIN STREET THIS SUMMER AT ABOUT 40 MPH AND PUT ON THE BRAKES AND THEY LOCK UP, MY CAR WHEN SIDEWAYS AT 40 MPH, VERY LUCKY KNOW ONE WAS HURT!! WENT TO THE DEALER TO HAVE THE CAR CHECKED OUT AND WAS TOLD THE EBCM WAS BAD AND THERE WAS NO FIX FOR IT !!! SO NOW I AND I'M SURE A LOT OF OTHERS HAVE A VERY UNSAFE AN…
Read full complaint
I WAS DRIVING ON A MAIN STREET THIS SUMMER AT ABOUT 40 MPH AND PUT ON THE BRAKES AND THEY LOCK UP, MY CAR WHEN SIDEWAYS AT 40 MPH, VERY LUCKY KNOW ONE WAS HURT!! WENT TO THE DEALER TO HAVE THE CAR CHECKED OUT AND WAS TOLD THE EBCM WAS BAD AND THERE WAS NO FIX FOR IT !!! SO NOW I AND I'M SURE A LOT OF OTHERS HAVE A VERY UNSAFE AND DANGEROUS VEHICLE THAT CHEVROLET SEEMS TO HAVE NO OBLIGATION TO SUPPLY A REPAIR FOR. YOU WOULD THINK NHTSA WOULD STEP ON AND FORCE CHEVROLET TO RESOLVE THIS ISSUE , OR IS IT GOING TO TAKE A DEATH TO MAKE SOMEONE ACT ? *TR
NHTSA ODI #10653778
93,000 miles · Sep 29, 2014
Electrical SystemExterior LightingService Brakes
THE HAZARD SWITCH IS FAULTY. ALL OF THE WIRING FOR THE BRAKE AND TURN SIGNALS GOES THROUGH THE HAZARD SWITCH. EVERY CORVETTE FORUM DETAILS THE FAULTY HAZARD SWITCH. BECAUSE OF THE POOR QUALITY OF THE PART, AND THE POOR DESIGN OF THE ELECTRICAL SYSTEM, IF THE HAZARD SWITCH MALFUNCTIONS, THERE ARE NO BRAKE LIGHTS, AND/OR NO TUR…
Read full complaint
THE HAZARD SWITCH IS FAULTY. ALL OF THE WIRING FOR THE BRAKE AND TURN SIGNALS GOES THROUGH THE HAZARD SWITCH. EVERY CORVETTE FORUM DETAILS THE FAULTY HAZARD SWITCH. BECAUSE OF THE POOR QUALITY OF THE PART, AND THE POOR DESIGN OF THE ELECTRICAL SYSTEM, IF THE HAZARD SWITCH MALFUNCTIONS, THERE ARE NO BRAKE LIGHTS, AND/OR NO TURN SIGNALS OR HAZARD LIGHTS. THERE IS NO INDICATION THAT THE SWITCH IS MALFUNCTIONING UNTIL ANOTHER MOTORIST NOTIFIES YOU VERBALLY OR BY CRASHING INTO YOU, OR PERHAPS IF LAW ENFORCEMENT PULLS YOU OVER FOR IT. *TR
NHTSA ODI #10640041
75,000 miles · Sep 7, 2014
Electronic Stability Control (esc)Service Brakes
THE TRACTION CONTROL AND ABS SYSTEM DOES DOT WORK BECAUSE THE ABS MODULE HAS FAILED AND THERE ARE NO AFTER MARKET REPAIRS OR PARTS. *TR
NHTSA ODI #10631337
55,641 miles · Aug 6, 2014
Electronic Stability Control (esc)Traction Control System
WARNING LIGHT INDICATOR CAME ON FOR SERVICE TRACTION SYSTEM AND SERVICE ACTIVE HANDLING SYSTEM AND WILL NOT RESET. NO REPLACEMENT PARTS ARE AVAILABLE AND DEALER HAS NO FIX FOR THIS PROBLEM OTHER THAN TO REMOVE THE FUSES ASSOCIATED WITH THESE SYSTEMS. *TR
NHTSA ODI #10619412
25,000 miles · Aug 5, 2014
Electrical SystemEngineService Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE BPMV NEEDED TO BE REPLACED ALONG WITH OTHER UNKNOWN FAILURES. THE MANUFACTURER STATED THAT THE PART NEEDED FOR THE REPAIR WAS DISCONTINUED. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE BPMV NEEDED TO BE REPLACED ALONG WITH OTHER UNKNOWN FAILURES. THE MANUFACTURER STATED THAT THE PART NEEDED FOR THE REPAIR WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 25,000. UPDATED 09/17/14*LJ UPDATED 02/3/2015 *JS
NHTSA ODI #10618946
35,200 miles · Jul 21, 2014
Exterior LightingSteering
TL* THE CONTACT OWNS 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE REPAIRS FOR RECALL NHTSA CAMPAIGN ID NUMBER 04V060000 (STEERING) WERE PERFORMED. HOWEVER, THE DEALER ONLY REPROGRAMMED THE SOFTWARE AND FAILED TO REPLACED THE STEERING WHEEL LOCK MOTOR. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE MANUFACTURER WAS MADE…
Read full complaint
TL* THE CONTACT OWNS 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE REPAIRS FOR RECALL NHTSA CAMPAIGN ID NUMBER 04V060000 (STEERING) WERE PERFORMED. HOWEVER, THE DEALER ONLY REPROGRAMMED THE SOFTWARE AND FAILED TO REPLACED THE STEERING WHEEL LOCK MOTOR. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM WHO INFORMED THE CONTACT THAT HE WOULD BE RESPONSIBLE FOR THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 35,200. UPDATED 11/14/14*CN UPDATED 8/11/2015*JS
NHTSA ODI #10614901
38,000 miles · May 22, 2014
EngineService Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE MECHANIC STATED THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED HOWEVER, THE PART WAS DISCONTINUED. T…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE MECHANIC STATED THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED HOWEVER, THE PART WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10593381
65,500 miles · May 16, 2014
Steering
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING LIGHT ILLUMINATED AS THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER.THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECCURED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING LIGHT ILLUMINATED AS THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER.THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECCURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,500 AND THE CURRENT MILEAGE WAS 69,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10588966
Mileage unknown · Mar 27, 2014
Electrical System
2000 CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO VEHICLE IGNITION PROBLEMS. *SMD THE CONSUMER STATED AFTER THE VEHICLE WAS PURCHASED NEW IN 2000, HE HAD NUMEROUS PROBLEMS WITH THE IGNITION SWITCH, ON A RANDOM BASIS, BUT WERE NOT CONSTANT. ON OCCASION, IT WOULD NOT START WHEN THE KEY WAS TURNED, AND HE WOULD HAVE TO KEEP…
Read full complaint
2000 CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO VEHICLE IGNITION PROBLEMS. *SMD THE CONSUMER STATED AFTER THE VEHICLE WAS PURCHASED NEW IN 2000, HE HAD NUMEROUS PROBLEMS WITH THE IGNITION SWITCH, ON A RANDOM BASIS, BUT WERE NOT CONSTANT. ON OCCASION, IT WOULD NOT START WHEN THE KEY WAS TURNED, AND HE WOULD HAVE TO KEEP TRYING, UNTIL IT DID START. SOMETIMES IT WOULD SHUT OFF ON ITS OWN. THE VEHICLE WAS TAKEN TO 3 DIFFERENT DEALERS, WHO SAID THE COULD NOT HELP HIM UNLESS THE VEHICLE EXHIBITED THE PROBLEM, WHILE IN THE SHOP. IT WASN'T UNTIL 3 YEARS AGO, WHEN THE IGNITION SWITCH, BECAME A REGULAR PROBLEM, WITH STARTING AND STOPPING AND CAUSING THE STEERING WHEEL TO LOCK UP. THERE WERE TIMES, WHEN THE ENGINE WOULD NOT SHUT OFF, AFTER THE KEY WAS REMOVED. HE DISCONNECTED THE BATTERY, HOPING THAT RESOLVE IT, BUT IT DID NOT. THERE WERE TIMES WHEN THE VEHICLE WOULD SHUT OFF, WHILE DRIVING. *JB
NHTSA ODI #10574570
NHTSA investigations
3EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Illustration