Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
490–25K
5925–50K
3450–75K
1175–100K
16100–150K
4150K+
173 reports with mileage · 104 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 168 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports0 fire reports8 injury reports
What owners actually said
277 reports
11,000 miles · Oct 4, 2004
Latches/locks/linkages
PASSENGER POWER DOOR LOCK DOES NOT UNLOCK. THE LOCK DOES LOCK, BUT IN ORDER TO UNLOCK THE PASSENGER DOOR IT MUST BE DONE MANUALLY OR BY THE KEY HOLE OUTSIDE.*AK BECAUSE OF THE NEW UPDATED LOCK VERSIONS BOTH ACTUATORS ON THE DRIVER SIDE DOOR LOCK AND PASSENGER SIDE DOOR LOCK MUST BE REPLACED IN ORDER FOR BOTH LOCKS TO FUNCTI…
Read full complaint
PASSENGER POWER DOOR LOCK DOES NOT UNLOCK. THE LOCK DOES LOCK, BUT IN ORDER TO UNLOCK THE PASSENGER DOOR IT MUST BE DONE MANUALLY OR BY THE KEY HOLE OUTSIDE.*AK BECAUSE OF THE NEW UPDATED LOCK VERSIONS BOTH ACTUATORS ON THE DRIVER SIDE DOOR LOCK AND PASSENGER SIDE DOOR LOCK MUST BE REPLACED IN ORDER FOR BOTH LOCKS TO FUNCTION TOGETHER. ESTIMATED COST TO REPLACE LOCKS $1200.
NHTSA ODI #10093578
8,000 miles · Oct 4, 2004
Seats
WHEN TURNING OFF THE CAR DRIVER SEAT WILL MOVE ALL THE WAY FORWARD, SMASHING THE DRIVER AGAINST THE STEERING WHEEL. *AK
NHTSA ODI #10093572
19,000 miles · Sep 27, 2004
Steering
AFTER RECALL 04V060000 ELECTRONIC COLUMN LOCK REPAIRS WERE DONE CONSUMER WAS STILL HAVING THE SAME PROBLEMS. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10094392
5,000 miles · Sep 7, 2004
Fuel System, Gasoline
THE CONSUMER NOTICED THAT THE GAS GAUGE INDICATED THAT IT NEEDED FUEL. HOWEVER, THE VEHICLE HAD FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE SENDING UNIT NEEDED TO BE REPLACED. *JB
NHTSA ODI #10091512
33,000 miles · Aug 31, 2004
Electrical System
ELECTRONIC MODULE FOR THE AUTOMATIC DOOR LOCKS FAILED. CONSUMER WAS CONCERNED THAT HE OR OTHER OCCUPANTS WOULD BE TRAPPED IF DOORS FAILED AGAIN. *AK THE VEHICLE'S BATTERY FAILED. WHEN THE BATTERY WAS RECHARGED IT CAUSED THE POWER LOCKS ON THE ON THE LEFT SIDE OF THE VEHICLE TO FAIL. *NM
NHTSA ODI #10084019
27,000 miles · Aug 26, 2004
Fuel System, Other
CONSUMER COMPLAINED THAT THE VEHCILE FUEL GAUGE WAS READING A QUARTER OF TANK OF FUEL WHEN THE VEHICLE SHUT OFF WHILE DRIVING. DEALER NOTIFIED. *AK
NHTSA ODI #10089812
28,619 miles · Aug 26, 2004
SteeringCrash
I HAVE A 2000 CORVETTE AND THE STEERING COLUMN LOCKED-UP WHILE DRIVING. THE STEERING WHEEL WILL NOT TURN, AND THE DISPLAY ASKS TO "SERVICE COLUMN LOCK". AFTER 7 HOURS, I STILL HAVEN'T FOUND A CHEVY DEALER THAT SAYS THEY CAN HELP. IF THAT HAD HAPPENED A FEW MINUTES BEFORE WHEN I WAS ON THE INTERSTATE, I COULD HAVE BEEN KILLED.…
Read full complaint
I HAVE A 2000 CORVETTE AND THE STEERING COLUMN LOCKED-UP WHILE DRIVING. THE STEERING WHEEL WILL NOT TURN, AND THE DISPLAY ASKS TO "SERVICE COLUMN LOCK". AFTER 7 HOURS, I STILL HAVEN'T FOUND A CHEVY DEALER THAT SAYS THEY CAN HELP. IF THAT HAD HAPPENED A FEW MINUTES BEFORE WHEN I WAS ON THE INTERSTATE, I COULD HAVE BEEN KILLED. THIS IS A SERIOUS PROBLEM, AND I'VE GOTTEN NOWHERE ON GETTING THE CAR FIXED.*AK
NHTSA ODI #10088629
6,700 miles · Aug 24, 2004
Steering
THE STEERING COLUMN RECALL IS NOT SATISFACTORY. IF CONSUMER HAS A MANUAL TRANSMISSION THEY WILL REPLACE THE COLUMN, AND IF THE TRANSMISSION IS AUTOMATIC ,THEY WILL REMOVE THE ENTIRE PART, LEAVING CONSUMER WITH NO THEFT PROTECTION. *AK
NHTSA ODI #10089566
30,000 miles · Aug 11, 2004
Exterior Lighting
WHILE DRIVING AT ANY SPEED EITHER TURN SIGNALS WILL FAIL TO OPERATE. CONSUMER HAD THE VEHICLE INSPECTED BY A DEALERSHIP, WHO WAS NOT ABLE TO DETERMINE THE CAUSE OF THE TURN SIGNALS BEING INOPERABLE. CONSUMER WAS AWARE OF OTHER CORVETTE OWNER'S THAT HAD THE SAME PROBLEM.
NHTSA ODI #10087667
Mileage unknown · Aug 6, 2004
Steering
STEERING COLUMN LOCKED WITH THE CAR RUNNING. CALLED CHEVROLET CUSTOMER SERVICE AND THEY STATED THAT MY CAR WAS NOT PART OF THE RECALL AND WERE NOT HELPFUL IN GETTING THE CAR FIXED DESPITE THE TREMENDOUS SAFETY HAZARD. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
2000 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration