THE HAZARD SWITCH IS FAULTY. ALL OF THE WIRING FOR THE BRAKE AND TURN SIGNALS GOES THROUGH THE HAZARD SWITCH. EVERY CORVETTE FORUM DETAILS THE FAULTY HAZARD SWITCH. BECAUSE OF THE POOR QUALITY OF THE PART, AND THE POOR DESIGN OF THE ELECTRICAL SYSTEM, IF THE HAZARD SWITCH MALFUNCTIONS, THERE ARE NO BRAKE LIGHTS, AND/OR NO TUR…
Read full complaint
THE HAZARD SWITCH IS FAULTY. ALL OF THE WIRING FOR THE BRAKE AND TURN SIGNALS GOES THROUGH THE HAZARD SWITCH. EVERY CORVETTE FORUM DETAILS THE FAULTY HAZARD SWITCH. BECAUSE OF THE POOR QUALITY OF THE PART, AND THE POOR DESIGN OF THE ELECTRICAL SYSTEM, IF THE HAZARD SWITCH MALFUNCTIONS, THERE ARE NO BRAKE LIGHTS, AND/OR NO TURN SIGNALS OR HAZARD LIGHTS. THERE IS NO INDICATION THAT THE SWITCH IS MALFUNCTIONING UNTIL ANOTHER MOTORIST NOTIFIES YOU VERBALLY OR BY CRASHING INTO YOU, OR PERHAPS IF LAW ENFORCEMENT PULLS YOU OVER FOR IT. *TR
NHTSA ODI #10640041
75,000 miles · Sep 7, 2014
Electronic Stability Control (esc)Service Brakes
THE TRACTION CONTROL AND ABS SYSTEM DOES DOT WORK BECAUSE THE ABS MODULE HAS FAILED AND THERE ARE NO AFTER MARKET REPAIRS OR PARTS. *TR
NHTSA ODI #10631337
25,000 miles · Aug 5, 2014
Electrical SystemEngineService Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE BPMV NEEDED TO BE REPLACED ALONG WITH OTHER UNKNOWN FAILURES. THE MANUFACTURER STATED THAT THE PART NEEDED FOR THE REPAIR WAS DISCONTINUED. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE BPMV NEEDED TO BE REPLACED ALONG WITH OTHER UNKNOWN FAILURES. THE MANUFACTURER STATED THAT THE PART NEEDED FOR THE REPAIR WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 25,000. UPDATED 09/17/14*LJ UPDATED 02/3/2015 *JS
NHTSA ODI #10618946
38,000 miles · May 22, 2014
EngineService Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE MECHANIC STATED THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED HOWEVER, THE PART WAS DISCONTINUED. T…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE MECHANIC STATED THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED HOWEVER, THE PART WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10593381
175,000 miles · Feb 24, 2013
Service BrakesCrash
I WAS LEAVING MY HOUSE TO GO TO WORK AND WHEN I GOT TO THE BUSY STREET, THERE WAS COMPLETE AND TOTAL BRAKE FAILURE. I ENDED UP RUNNING OVER A CURB AND HITTING SOME TREES TO STOP MY CAR. I HAD AAA TOW MY CAR TO A MECHANIC'S SHOP AND HE TRIED WORKING ON IT FOR ABOUT A WEEK TO TEN DAYS AND COULD NOT FIGURE OUT WHY I HAD NO BRAKES…
Read full complaint
I WAS LEAVING MY HOUSE TO GO TO WORK AND WHEN I GOT TO THE BUSY STREET, THERE WAS COMPLETE AND TOTAL BRAKE FAILURE. I ENDED UP RUNNING OVER A CURB AND HITTING SOME TREES TO STOP MY CAR. I HAD AAA TOW MY CAR TO A MECHANIC'S SHOP AND HE TRIED WORKING ON IT FOR ABOUT A WEEK TO TEN DAYS AND COULD NOT FIGURE OUT WHY I HAD NO BRAKES AT ALL. HE SAID THE ABS SYSTEM SEEMS TO BE MALFUNCTIONING, BUT IT SHOULDN'T LEAVE ME WITHOUT ANY BRAKES. HE SAID HE THOUGHT IT WAS A SAFETY ISSUE AND THAT GM WOULD NEED TO BE NOTIFIED ABOUT THIS AND HE URGED ME TO SEND MY CAR TO A GM DEALERSHIP TO TAKE CARE OF THE ISSUE. I HAD AAA TOW MY CAR TO BOB STALL CHEVROLET IN LA MESA, CA AND THEY VERIFIED THAT THE ABS SYSTEM WAS FRIED AND THAT I WOULD NEED TO REPLACE THE UNIT. WHEN I ASKED IF GM WOULD HELP WITH THE COST OF THE REPLACEMENT SINCE IT WAS A SAFETY ISSUE, THEY SAID I WOULD HAVE TO CALL GM CUSTOMER SERVICE. I DID AND THEY SAID THEY WOULDN'T BE ABLE TO ASSIST BECAUSE THE DEALERSHIP WAS TELLING THEM THAT THE CAR HAD BRAKES AND WORKED FINE WHEN THEY GOT IT. NOW I AM SERIOUSLY CONCERNED WITH THE SAFETY OF MY CAR AND THE BRAKES AND THE FACT THAT IF THE ABS GOES OUT OR FRIES, THAT I MIGHT POSSIBLY NOT HAVE BRAKES AT ALL. MY CAR HAS BEEN AT THE DEALERSHIP FOR ALMOST A MONTH NOW AND THEY STILL HAVEN'T BEEN ABLE TO FIX IT YET. *TR
NHTSA ODI #10499865
12,000 miles · Nov 29, 2012
Service Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THE REAR TIRES DISCONNECTED FROM THE VEHICLE CAUSING THE CONTACT TO LOSE CONTROL. THE CONTACT ALSO STATED THE TRACTION CONTROL AND THE ABS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. …
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THE REAR TIRES DISCONNECTED FROM THE VEHICLE CAUSING THE CONTACT TO LOSE CONTROL. THE CONTACT ALSO STATED THE TRACTION CONTROL AND THE ABS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE ABCM MODULE AND THE LEFT FRONT WHEEL BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE ABCM MODULE NOT BEING AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WERE 12,000.
NHTSA ODI #10486438
49,000 miles · May 16, 2012
Electronic Stability Control (esc)Service Brakes
WARNING LIGHTS IN DASH ALERTED ME TO THE ACTIVE HANDLING/TRACTION CONTROL NOT WORKING. THIS IS THE SECOND FAILURE OF THE EBTCM MODULE. CALLED THE GM DEALER FOR THE MODULE ONLY TO FIND OUT IS IT NO LONGER AVAILABLE & THERE IS NO ALTERNATIVE OR REPLACEMENT AVAILABLE. I AM CURRENTLY DRIVING THE CAR WITH THE FUSE PULLED TO RENDER TH…
Read full complaint
WARNING LIGHTS IN DASH ALERTED ME TO THE ACTIVE HANDLING/TRACTION CONTROL NOT WORKING. THIS IS THE SECOND FAILURE OF THE EBTCM MODULE. CALLED THE GM DEALER FOR THE MODULE ONLY TO FIND OUT IS IT NO LONGER AVAILABLE & THERE IS NO ALTERNATIVE OR REPLACEMENT AVAILABLE. I AM CURRENTLY DRIVING THE CAR WITH THE FUSE PULLED TO RENDER THE SAFETY BRAKING SYSTEM INOPERATIVE.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
2000 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration