IllustrationLOW BEAM HEADLIGHTS GO OUT WHILE DRIVING? HAPPENS DAILY THEN LIGHTS COME BACK ON AFTER HOURS? STRANDED 5 HRS ON INTERSTATE AT REST STOP! *TR
2007 Chevrolet Corvette Z06
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette Z06 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
1425–50K
550–75K
375–100K
1100–150K
0150K+
42 reports with mileage · 3 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
What owners actually said
45 reportsTHERE IS A SERIOUS AN DEADLY PROBLEM WITH THE DESIGN OF THE MICHELIN TIRES SPECIFIED FOR THE 2007 (AN OTHER) CORVETTE Z06. THE SIDE WALL OF THE TIRE COMPLETELY COLLAPSES WHILE EXECUTING A SHARP TURN EITHER GOING FORWARD OR BACKING UP. DETAILED DISCUSSION WITH SUPPLIER DISCOUNT TIRE AND SECOND HAND COMMUNICATION WITH THE MICHELI…
Read full complaint
THERE IS A SERIOUS AN DEADLY PROBLEM WITH THE DESIGN OF THE MICHELIN TIRES SPECIFIED FOR THE 2007 (AN OTHER) CORVETTE Z06. THE SIDE WALL OF THE TIRE COMPLETELY COLLAPSES WHILE EXECUTING A SHARP TURN EITHER GOING FORWARD OR BACKING UP. DETAILED DISCUSSION WITH SUPPLIER DISCOUNT TIRE AND SECOND HAND COMMUNICATION WITH THE MICHELIN LEADS ME TO BELIEVE THAT MICHELIN AND DISCOUNT TIRE ARE BOTH AWARE OF THE PROBLEM. THE ABSOLUTE FACT IS THE TIRES DO COLLAPSE WHEN MAKING A SHARP TURN. IF ONE MAKES A SHARP TURN WITH ANY SPEED OR ACCELERATION WILL CAUSE THE TIRE'S SIDEWALL TO COLLAPSE. DANGER DANGER DANGER!!! THE HOME LINK SYSTEM ALSO DOES NOT WORK AND I GOT THE RUN AROUND FOR YEARS WITH NO ACTION TAKEN. *TR
SUBMISSION FROM CONSTITUENT RE REPAIRS ON HIS 2007 CHEVROLET CORVETTE (THE ENGINE "DROPPED A VALVE") *SMD THE CONSUMER WAS INFORMED, THE ENTIRE ENGINE NEEDED TO BE REPLACED AT A COST OF $18,722. INSTEAD OF REPLACING THE ENGINE, AT NO COST TO THE CONSUMER, GENERAL MOTORS OFFERED TO PICK UP 45% OF THE COST, LEAVING THE CONSUMER …
Read full complaint
SUBMISSION FROM CONSTITUENT RE REPAIRS ON HIS 2007 CHEVROLET CORVETTE (THE ENGINE "DROPPED A VALVE") *SMD THE CONSUMER WAS INFORMED, THE ENTIRE ENGINE NEEDED TO BE REPLACED AT A COST OF $18,722. INSTEAD OF REPLACING THE ENGINE, AT NO COST TO THE CONSUMER, GENERAL MOTORS OFFERED TO PICK UP 45% OF THE COST, LEAVING THE CONSUMER TO PAY THE BALANCE OF $10,630. THE CONSUMER STATED GM ISSUED AN INTERNAL BULLETIN AS FAR BACK AS FEBRUARY 2008, THAT SHOWED THEY WERE AWARE OF THE Z06 ENGINE FAILURES AND SHORT LIFE EXPECTANCY.
WHILE DRIVING APPROXIMATELY 45 MPH AT NIGHT, SUDDEN LOSS OF BOTH LOW BEAM HEADLIGHTS WITHOUT WARNING. ALMOST WENT OFF THE ROAD. I HAD TO STOP SUDDENLY. NEARLY MISSED GETTING REAR ENDED IN THE PROCESS. THIS IS NOT SAFE! *TR
EXHAUST VALVE GUIDES ARE EXCESSIVELY WORN BEYOND SERVICE LIMIT. APPROXIMATELY 4 TIMES SERVICE LIMIT. THIS IS A DEFINITE SAFETY HAZARD TO ME AND TO THOSE AROUND ME. THE WORN VALVE GUIDE CAUSES THE EXHAUST VALVE TO STRETCH, AND EVENTUALLY BREAK. WHEN THE VALVE HEAD BREAKS, IT BEATS ITS WAY OUT OF THE ENGINE, CAUSING POTENTIALL…
Read full complaint
EXHAUST VALVE GUIDES ARE EXCESSIVELY WORN BEYOND SERVICE LIMIT. APPROXIMATELY 4 TIMES SERVICE LIMIT. THIS IS A DEFINITE SAFETY HAZARD TO ME AND TO THOSE AROUND ME. THE WORN VALVE GUIDE CAUSES THE EXHAUST VALVE TO STRETCH, AND EVENTUALLY BREAK. WHEN THE VALVE HEAD BREAKS, IT BEATS ITS WAY OUT OF THE ENGINE, CAUSING POTENTIALLY: ENGINE LOCKUP, OIL SPILL ON HIGHWAY, LARGE SMOKE CLOUD AND DEBRIS OUT THE REAR OF THE VEHICLE. LOSS OF CONTROL OF THE VEHICLE IMMINENT DANGER TO THOSE AROUND ME DUE TO LOSS OF VISION AND SLIPPERY ROADWAY. THIS ISSUE AFFECTS ALL 2006 TO 2013 CHEVROLET CORVETTE Z06. *TR
IT IS STOCK AND NO TUNE VERIFIED BY ( RELIABLE CHEVROLET IN SPRINGFIELD MO. AND SHOW-ME SPEED IN NIXA MO.) AT 49562 MILE IT DROP THE #6 EXHAUST VALVE WHICH IN TURN DESTROYED THE MOTOR I HAVE HAD THIS CAR TO 3 DIFFERENT SHOPS AND THEY ARE ALL SAYING THE SAME THING EXCESSIVE WEAR ON ALL THE EXHAUST VALVE GUIDES 2 OF THE SHOPS DET…
Read full complaint
IT IS STOCK AND NO TUNE VERIFIED BY ( RELIABLE CHEVROLET IN SPRINGFIELD MO. AND SHOW-ME SPEED IN NIXA MO.) AT 49562 MILE IT DROP THE #6 EXHAUST VALVE WHICH IN TURN DESTROYED THE MOTOR I HAVE HAD THIS CAR TO 3 DIFFERENT SHOPS AND THEY ARE ALL SAYING THE SAME THING EXCESSIVE WEAR ON ALL THE EXHAUST VALVE GUIDES 2 OF THE SHOPS DETERMINED THIS WEAR CAUSED THE EXHAUST VALVE TO BREAK OTHER SHOP COULDN'T SAY. *TR
THE RIGHT FRONT OEM WHEEL ON THE VEHICLE HAD SEVERAL SPOKES THAT WERE BUSTED COMPLETELY IN HALF. THERE WAS NO ABUSE TO THE WHEEL, NO IMPACT OR CURB RASH OF ANY KIND. THE VEHICLE HAS NEVER BEEN RACED OR OPERATED ON ANY KIND OF TRACK ENVIRONMENT. THERE HAVE BEEN SEVERAL REPORTS OF THE SAME FAILURE ON THE WWW.CORVETTEFORM DISCUSSIO…
Read full complaint
THE RIGHT FRONT OEM WHEEL ON THE VEHICLE HAD SEVERAL SPOKES THAT WERE BUSTED COMPLETELY IN HALF. THERE WAS NO ABUSE TO THE WHEEL, NO IMPACT OR CURB RASH OF ANY KIND. THE VEHICLE HAS NEVER BEEN RACED OR OPERATED ON ANY KIND OF TRACK ENVIRONMENT. THERE HAVE BEEN SEVERAL REPORTS OF THE SAME FAILURE ON THE WWW.CORVETTEFORM DISCUSSION BOARDS. GM HAS IGNORED THE PROBLEM AND DENIED ANY TYPE OF COMPENSATION OR OWNERSHIP OF THE PROBLEM. I HAVE SINCE REPLACED THE WHEEL WITH ANOTHER OEM WHEEL. THIS TYPE OF CATASTROPHIC FAILURE COULD RESULT IN A LIFE AND DEATH SITUATION. *JS
THE LOW BEAMS RANDOMLY STOP WORKING, AFTER THE ENGINE HEATS UP TO OPERATING TEMPERATURE, AND ALMOST CAUSED AN ACCIDENT. THE BEHAVIOR THEN REPEATS EVERY TIME THE CAR IS USED (NOT A ONE-TIME EVENT). I, AND OTHER OWNERS HAVE IDENTIFIED A COMMON CIRCUIT ISSUE IN THE HEADLAMP CONTROLS, WHICH IS ONLY FIXABLE BY REPLACING THE WHOLE BOA…
Read full complaint
THE LOW BEAMS RANDOMLY STOP WORKING, AFTER THE ENGINE HEATS UP TO OPERATING TEMPERATURE, AND ALMOST CAUSED AN ACCIDENT. THE BEHAVIOR THEN REPEATS EVERY TIME THE CAR IS USED (NOT A ONE-TIME EVENT). I, AND OTHER OWNERS HAVE IDENTIFIED A COMMON CIRCUIT ISSUE IN THE HEADLAMP CONTROLS, WHICH IS ONLY FIXABLE BY REPLACING THE WHOLE BOARD. *TR
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE WITH OE CONCEPT ALUMINUM WHEELS. THE CONTACT STATED THAT THE MANUFACTURER PUT STEEL IN THE WHEELS, WHICH CAUSED THE TIRES TO BECOME OUT OF BALANCE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT BECAUSE TWO UNLIKE METALS WERE PLACED TOGETHER, THE TIRES WOULD CERTAINLY DISINTEG…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE WITH OE CONCEPT ALUMINUM WHEELS. THE CONTACT STATED THAT THE MANUFACTURER PUT STEEL IN THE WHEELS, WHICH CAUSED THE TIRES TO BECOME OUT OF BALANCE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT BECAUSE TWO UNLIKE METALS WERE PLACED TOGETHER, THE TIRES WOULD CERTAINLY DISINTEGRATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE EQUIPMENT WAS RETURNED. THE FAILURE AND THE CURRENT MILEAGE WAS 32,000. THE VIN WAS NOT AVAILABLE.
2007 CHEVROLET CORVETTE Z06." SERVICE ACTIVE HANDLING" MESSAGE APPEARS ON INSTRUMENT CLUSTER AT RANDOM INTERVALS. SOMETIMES MESSAGE PRECEDES AN APPLICATION OF ONE OR BOTH FRONT BRAKES WHILE VEHICLE IS IN MOTION CAUSING A VERY DANGEROUS DRIVING SCENARIO. THE VEHICLE HAS ONLY 3800 MILES AND HAS BEEN RETURNED TO THE DEALERSHIP (LON…
Read full complaint
2007 CHEVROLET CORVETTE Z06." SERVICE ACTIVE HANDLING" MESSAGE APPEARS ON INSTRUMENT CLUSTER AT RANDOM INTERVALS. SOMETIMES MESSAGE PRECEDES AN APPLICATION OF ONE OR BOTH FRONT BRAKES WHILE VEHICLE IS IN MOTION CAUSING A VERY DANGEROUS DRIVING SCENARIO. THE VEHICLE HAS ONLY 3800 MILES AND HAS BEEN RETURNED TO THE DEALERSHIP (LONE STAR CHEVROLET..HOUSTON, TEXAS) ONE BEFORE FOR A FIX. A SLEEVE WAS INSTALLED IN THE STEERING COLUMN AS PER A GM DIRECTIVE. THE PROBLEM RETURNED WITHIN 500 MILES OF DRIVING. I HAVE ASKED THE SERVICE DEPARTMENT TO REMOVE THE ACTIVE HANDLING FROM THE CARS COMPUTER AND THEY SAY THEY CANNOT. THE VEHICLE IS UNSAFE TO OPERATE WITH THIS ISSUE IF THE BRAKES ARE APPLIED. I HAVE DISCUSSED THIS ISSUE WITH NUMEROUS OTHER CORVETTE OWNERS (ONLINE AT THE CORVETTE FORUM) WHO HAVE ALSO EXPERIENCED THIS SAME ISSUE AND ONLY A FEW HAVE HAD THE PROBLEM FINALLY CORRECTED. OTHERS, LIKE MYSELF, MUST CONTINUE TO TAKE THE VEHICLES BACK FOR ANOTHER FIX. *TR
Official recalls
109V491000 · Structure:body:roof And Pillars
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence & remedy
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13007 · Simultaneous Loss Of Low-Beam Headlights
Opened Aug 23, 2013 · Closed Jun 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Additional source detail variants (2)
Exterior Lighting
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
PE13013 · Loss Of Low Beam Headlights
Opened May 6, 2013 · Closed Aug 26, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Additional source detail variants (2)
Exterior Lighting
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221