IllustrationTHE EXHAUST VALVE BROKE OFF, AND ENGINE BLEW UP. I WAS DRIVING ON HIGHWAY.
2007 Chevrolet Corvette Z06
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette Z06 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
1425–50K
550–75K
375–100K
1100–150K
0150K+
42 reports with mileage · 3 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Engine complaints
26 reportsI AM EXTREMELY CONCERNED ABOUT EXCESSIVE VALVE TRAIN NOISE AND AFTER READING SEVERAL CORVETTE FORUM THREADS ABOUT IMPROPERLY MACHINED HEADS BY GM'S SUPPLIER LINAMAR, AND THAT NUMEROUS VEHICLES HAVE HAD VALVES DROP AND RUIN THE ENGINES CAUSING A LOSS OF CONTROL OF THE VEHICLE DUE TO THE ENGINE STOPPING ABRUPTLY. 88% OF THE CO…
Read full complaint
I AM EXTREMELY CONCERNED ABOUT EXCESSIVE VALVE TRAIN NOISE AND AFTER READING SEVERAL CORVETTE FORUM THREADS ABOUT IMPROPERLY MACHINED HEADS BY GM'S SUPPLIER LINAMAR, AND THAT NUMEROUS VEHICLES HAVE HAD VALVES DROP AND RUIN THE ENGINES CAUSING A LOSS OF CONTROL OF THE VEHICLE DUE TO THE ENGINE STOPPING ABRUPTLY. 88% OF THE CORVETTE FORUM MEMBERS WHO HAVE HAD THEIR CYLINDER HEADS TESTED FOR EXCESSIVE VALVE GUIDE WEAR, WERE OUT OF SERVICE SPECIFICATIONS. SOURCE: HTTP://WWW.CORVETTEFORUM.COM/FORUMS/C6-Z06-DISCUSSION/3386141-THE-OUT-OF-SPEC-GUIDE-WEAR-REGISTRY.HTML GM NEEDS TO ISSUE A RECALL ON THIS ISSUE, THERE HAVE BEEN NUMEROUS ENGINE FAILURES AS A RESULT OF A DROPPED VALVE INTO A CYLINDER WHICH CAN CAUSE SEVERE ACCIDENTS AND FIRES. GM IS VERY AWARE OF THIS ISSUE, BUT REFUSES TO DO ANYTHING ABOUT THIS HUGE SAFETY RISK TO DRIVERS, PASSENGERS, AND NEARBY VEHICLES IF THE ENGINE FAILS GOING DOWN THE ROAD. IT HAS BEEN NOTED ON THE FORUM THAT GM IS VERY AWARE OF THE ISSUES AND I ASSUME THEY THINK NO ONE WILL REPORT THEM FOR NOT HANDLING IT CORRECTLY. THE ISSUE IS THIS IS A CRITICAL SAFETY ISSUE FOR ANYONE DRIVING A 06-13 Z06 MODEL ON THE ROAD. I AM TO THE POINT I DON'T FEEL SAFE TO DRIVE MY VEHICLE ANYMORE DUE TO THE LOUD 'TICKING' VALVE-TRAIN AS IT IS (SYMPTOM) MEANING IT IS LIKELY TO FAIL AT ANY MOMENT SEIZING THE ENGINE WHILE ON THE ROAD. I HAVE WAITED ON GM FOR 6 YEARS TO DO THE CORRECT THING ON THEIR OWN BUT I AM NOW REPORTING IT DUE TO THEIR GROSS NEGLIGENCE AND DISREGARD OF THEIR CUSTOMERS SAFETY.
WHILE DRIVING ON THE ROAD AT APROX. 45MPH, MY CAR EXHAUST VALVE DROPPED IN THE MOTOR CAUSING IMMEDIATE ENGINE FAILURE ALSO CREATING POWER STEERING AND POWER BRAKES TO STOP WORKING IMMEDIATELY. THIS SAME EXHAUST VALVE ISSUES OCCURRED WITH MANY OTHER GM CORVETTES WITH THE 7.0LITER Z06 MOTOR.
VALVE TRAIN ROCKER ARMS BROKEN LEAVING NEEDLE BEARINGS IN THE OIL, AND ALL VALVE GUIDES WERE OUT OF TOLERANCE. *TR
AFTER MONTHS OF READING ABOUT THE EXHAUST VALVE ISSUE WITH CORVETTE Z06S I TOOK MY CAR AND HAD THE HEADS CHECKED. THE SHOP FOUND THE VALVE GUIDE CLEARANCE TO BE OUTSIDE THE SPECIFIED ACCEPTABLE RANGE. THE DEFECT PUTS UNDUE STRESS ON THE SODIUM FILLED VALVES AND IF THE VALVE FAILS IT CAN CAUSE CATASTROPHIC ENGINE DAMAGE AND POTEN…
Read full complaint
AFTER MONTHS OF READING ABOUT THE EXHAUST VALVE ISSUE WITH CORVETTE Z06S I TOOK MY CAR AND HAD THE HEADS CHECKED. THE SHOP FOUND THE VALVE GUIDE CLEARANCE TO BE OUTSIDE THE SPECIFIED ACCEPTABLE RANGE. THE DEFECT PUTS UNDUE STRESS ON THE SODIUM FILLED VALVES AND IF THE VALVE FAILS IT CAN CAUSE CATASTROPHIC ENGINE DAMAGE AND POTENTIALLY DEADLY SITUATION IF THIS OCCURS AT SPEED ON THE ROADWAY AS THE DRIVER WILL LOSE ABILITY TO CONTROL THE VEHICLE POTENTIALLY CAUSING A DEADLY ACCIDENT. I PAID SEVERAL THOUSAND DOLLARS OUT OF POCKET TO FIX THIS ISSUE DESPITE GM ACKNOWLEDGING THERE IS AN ISSUE WITH THESE VEHICLES.
THIS MODEL CORVETTE CAN SUDDENLY DROP AN ENGINE VALVE (EXHAUST OR INTAKE) AND UNEXPECTEDLY DEVELOP A HOLE IN THE BLOCK ACCOMPANIED WITH OIL SPILLED ON THE ROADWAY, SMOKE BILLOWING WITH RISK FOR VEHICLES BEHIND AND IN FRONT, AND THE RISK FOR TOTAL LOSS OF POWER STEERING, BRAKING AND CONTROL OF THE VEHICLE. THE OUTCOME IF THIS …
Read full complaint
THIS MODEL CORVETTE CAN SUDDENLY DROP AN ENGINE VALVE (EXHAUST OR INTAKE) AND UNEXPECTEDLY DEVELOP A HOLE IN THE BLOCK ACCOMPANIED WITH OIL SPILLED ON THE ROADWAY, SMOKE BILLOWING WITH RISK FOR VEHICLES BEHIND AND IN FRONT, AND THE RISK FOR TOTAL LOSS OF POWER STEERING, BRAKING AND CONTROL OF THE VEHICLE. THE OUTCOME IF THIS HAPPENED ON A FREEWAY WITH CARS TRAVELING AT A HIGH RATE OF SPEED IS POTENTIALLY FATAL. ALL OF THIS IS DUE TO MACHINING ERRORS AND SUPPLIER DEFECTS FOR THE ASSOCIATED PARTS (VALVES, GUIDES, ETC.) ON ALL 2006-2013 CORVETTE C6 Z06'S MADE BY GM. *TR
WIGGLE TEST ON ALL VALVES SHOWED ALL EXHAUST VALVES WITH EXCESSIVE GUID WHERE....SAFETY ISSUE....!!! THIS CAN AND HAS LED TO CATASTROPHIC ENGINE FAILURE AT FREEWAY SPEEDS....... *TR
I TOOK MY CAR TO AMERICAN HERITAGE PERFORMANCE IN CALIFORNIA AND HAD THE HEADS CHECKED AND THEY WERE ALL OUT OF SPECK, AT 16000 MILES, AND THIS CAR WAS ONLY STREET DRIVEN, AND HAD TO HAVE ALL THIS WORK DONE ON A LOW MILEAGE CAR WAS VERY UPSETTING, AND IN THE END FINDING OUT THAT MANY CARS HAVE THIS PROBLEM. HAVING TO GET ALL THI…
Read full complaint
I TOOK MY CAR TO AMERICAN HERITAGE PERFORMANCE IN CALIFORNIA AND HAD THE HEADS CHECKED AND THEY WERE ALL OUT OF SPECK, AT 16000 MILES, AND THIS CAR WAS ONLY STREET DRIVEN, AND HAD TO HAVE ALL THIS WORK DONE ON A LOW MILEAGE CAR WAS VERY UPSETTING, AND IN THE END FINDING OUT THAT MANY CARS HAVE THIS PROBLEM. HAVING TO GET ALL THIS WORK DONE ON A VIRTUALLY NEW CAR IS RIDICULOUS.. *TR
WHEN I PURCHASED THE 2007 CORVETTE Z06, I WAS INSTRUCTED TO HAVE THE HEADS CHECKED FOR EXCESSIVE VALVE GUIDE WEAR. I HAD THE HEADS PULLED AND THE VALVES EXAMINED BY A LOCAL EXPERT. HE INDICATED THAT THE VALVE GUIDES WERE OUT OF SPECIFICATION AND NEEDED REPLACEMENT. I REPLACED THESE AT MY OWN EXPENSE OF OVER $2000.00. HAD T…
Read full complaint
WHEN I PURCHASED THE 2007 CORVETTE Z06, I WAS INSTRUCTED TO HAVE THE HEADS CHECKED FOR EXCESSIVE VALVE GUIDE WEAR. I HAD THE HEADS PULLED AND THE VALVES EXAMINED BY A LOCAL EXPERT. HE INDICATED THAT THE VALVE GUIDES WERE OUT OF SPECIFICATION AND NEEDED REPLACEMENT. I REPLACED THESE AT MY OWN EXPENSE OF OVER $2000.00. HAD THE ENGINE BLOWN UP AS A RESULT OF THIS DEFECTIVE CONDITION, THE BREAKS AND POWER STEERING WOULD FAIL CAUSING AN ACCIDENT. I WOULD LIKE GM TO ISSUE A RECALL ON THIS MODEL CORVETTE. *TR
AT ONLY 21,179 MILES, MY DEALER INSPECTED BOTH CYLINDER HEAD BANKS AND FOUND VALVE GUIDE CLEARANCE TO BE WELL OUT OF MAXIMUM ALLOWED SPECIFICATION. THIS DEFECT PUTS UNDUE STRESS ON THE HOLLOW, SODIUM-FILLED EXHAUST VALVES. IF AN EXHAUST VALVE BREAKS, THE EXHAUST VALVE WILL DROP INTO THE COMBUSTION CHAMBER, AND CAUSE A COMPLETE…
Read full complaint
AT ONLY 21,179 MILES, MY DEALER INSPECTED BOTH CYLINDER HEAD BANKS AND FOUND VALVE GUIDE CLEARANCE TO BE WELL OUT OF MAXIMUM ALLOWED SPECIFICATION. THIS DEFECT PUTS UNDUE STRESS ON THE HOLLOW, SODIUM-FILLED EXHAUST VALVES. IF AN EXHAUST VALVE BREAKS, THE EXHAUST VALVE WILL DROP INTO THE COMBUSTION CHAMBER, AND CAUSE A COMPLETE, CATASTROPHIC FAILURE OF THE ENGINE. THIS CAUSES HAZARDOUS CONDITIONS FOR THE DRIVER, PASSENGER, AND SURROUNDING TRAFFIC: THE DRIVE WHEELS MAY BECOME LOCKED AS THE ENGINE SEIZES AND THE ENGINE BLOCK MAY BECOME WINDOWED BY A ROD, CAUSING A LARGE SPILL OF OIL AND COOLANT IMMEDIATELY UNDER THE VEHICLE ON THE ROADWAY. THESE CONDITIONS COULD LEAD TO A SEVERE ACCIDENT FROM A SUDDEN SPIN AND/OR A FIRE. I HAVE LITTLE CONFIDENCE THAT THE CYLINDER HEADS REPLACED ON MY CAR ARE FREE FROM THE VALVE GUIDE CLEARANCE DEFECT. AS MORE OWNERS HAVE BECOME AWARE OF THE PROBLEM, REPLACEMENT CYLINDER HEADS HAVE BEEN MEASURED BEFORE INSTALLATION ON THE ENGINE AND HAVE BEEN FOUND TO HAVE DEFECTS IN VALVE GUIDE CLEARANCE AND VALVE GUIDE TO SEAT CONCENTRICITY, SUCH AS WHAT COULD LEAD TO A DROPPED EXHAUST VALVE AND AN ACCIDENT. THE VEHICLES SHOULD BE RECALLED AND FIXED BEFORE ANY MORE SERIOUS ACCIDENTS OCCUR. ALTHOUGH MY VEHICLE DID NOT FAIL DESPITE HAVING THE DEFECT, I HAVE SEEN A VIDEO OF A SPIN CAUSED BY THE FAILURE, I HAVE SEEN PICTURES OF A VEHICLE AFTER A FIRE CAUSED BY THE FAILURE, AND I HAVE SEEN REPORTS OF APPROXIMATELY 35 FAILURES; ALL FROM CORVETTEFORUM.COM. THEREFORE I AM CONCERNED ABOUT MY SAFETY WHEN DRIVING THE VEHICLE AND I BELIEVE THE NHTSA SHOULD INVESTIGATE THE MATTER. *TR
Official recalls
109V491000 · Structure:body:roof And Pillars
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence & remedy
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13007 · Simultaneous Loss Of Low-Beam Headlights
Opened Aug 23, 2013 · Closed Jun 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Additional source detail variants (2)
Exterior Lighting
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
PE13013 · Loss Of Low Beam Headlights
Opened May 6, 2013 · Closed Aug 26, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Additional source detail variants (2)
Exterior Lighting
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221