2023 Chevrolet Colorado

The right front brake caliper failed with 15747 miles. Local dealer made repairs and said the caliper was not the cause. Their cause was blaming a brake controller used in towing the vehicle. If the controller had caused the failure more than one wheel would of been effected. The three remaining wheels all showed fine and had over 7mm of brake lining remaining. The wheel effected had ZERO pad remaining. I have replaced parts in my possession for evidence.

The contact owns a 2023 Chevrolet Colorado. The contact stated that several sensors were activated with contact being alerted to an issue with the Lane Keep Assist, and the vehicle veering out of the intended lane. The contact stated that while driving 45 MPH, the Forward Collision Avoidance: Automatic Emergency Braking activated unintendedly. The contact stated that the failure was self-corrected. The dealer was contacted, and an appointment was scheduled. The contact inquired of the the dealer if the VIN was included in NHTSA Campaign Number: 24V133000 (Electrical System, Forward Collision Avoidance). The dealer informed the contact that the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 15,000.

The contact owns a 2023 Chevrolet Colorado. The contact stated that while driving, the vehicle decelerated from 70 MPH to 30 MPH. During the failure the check engine and traction control warning lights were illuminated. The vehicle was towed to the local dealer who diagnosed an engine cylinder misfire. No further information was available. The contact stated that the vehicle was serviced by the dealer on several occasions for the failure however, the failure persisted. The contact stated that the vehicle was unsafe to drive. The manufacturer was notified of the failure. The failure mileage was 3,000.

The contact owns a 2023 Chevrolet Colorado. The contact had taken the vehicle to the dealer for a routine oil change and after the vehicle was serviced, the contact was provided a multi-point vehicle inspection sheet which showed that the brake pads had received a green check mark and that the brake pads were 7-millimeters or greater on both the driver’s and passenger’s side. The next day upon start of the vehicle, the contact stated that a message "New Brake Pads Detected" question was displayed on the instrument panel. The contact selected the "No" option followed by another question to service the brake pads. The contact then stated that a "Service Brake Pad Monitoring System" message appeared on the instrument panel. The vehicle was taken back to the dealer where the dealer was informed of the messages. A mechanic inspected the vehicle and informed the contact that both the brake pads and rotors needed to be replaced. The contact was also informed that the brake pads were 2 millimeters or less, despite the contact receiving information the day prior which stated otherwise. The contact questioned the dealer about the discrepancy and was informed that the computer provided the results for the multi-point vehicle inspection. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 27,000.

Vehicle shaking very badly when braking. Then “Service Brake Monitor” message displays. Took it to a Chevy dealership who said my rotors were warped. Turns out many people are complaining about it on Reddit. I purchased vehicle with less than 20k miles on it and it was a Chevy certified used vehicle. I don’t feel safe driving it and Chevy will not foot the bill. This could potentially be dangerous for other drivers and my guess is the parts are defective or something other than “driving conditions” are at play. This should not be happening!

I have been having intermittent issues with a warning on dash says service safety retrain system vehicle will shut off on its own doesn't want to restart Vehicle was taken to dealership for a tsb as well as the shutoff issue they had the truck 28 days said they diagnosed the truck could not duplicate my concerns I also explained the issue with display going out flickering brake lights etc, intermittent issue with btakes being hard then extremely soft, i even showed video that they can clearly hear me talking on they did not care. when I picked the truck up from dealership the mileage in was same as mileage out as noted on the paperwork and matches pictures I took They never drove the truck. On Wednesday June 4, 2025 while driving home I ended up running a stop sign and barely missing a car because truck shut off causing my brakes to not respond I was able to get it to stop just in time it was witnessed by a local law enforcement agency I showed the officer my truck would not start and pedal was unresponsive was told it had to be towed had a friend tow to my house. on Saturday June 14, 2025 while on my way to Northern Duchess Hospital the warning came on the display and vehicle shut off I was able to get it off the road could not start it had to call for someone to drive me to the hospital upon release at 5am I had to call my brother to pick me up we got truck to start after 20 mins while driving it he informed me I had no brake lights turn signals or headlight the display was black no speedometer nothing had to call friend to tow again once at my house he started checking fuses found 4 melted fuses one was ECM the others were body control module and something else this truck has 7300 miles on it the problems are getting worse last time at dealership service manager stated he wasn't wasting more than 20 minutes on diagnosing anything. Other issues are windows going down on there own climate controls coming on by itself and air coming in by top of windshield

The contact owns a 2023 Chevrolet Colorado. The contact stated that while driving through a carwash, the roof suddenly became concaved. Upon leaving the carwash the roof suddenly made a loud pop and returned to the normal position. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a structural failure with the roof. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 10.

When battery was beginning to get old/need replacement but vehicle would still start: 1. The power steering assist stopped working intermittently (virtually impossible to steer even at speed) 2. Power brake stopped working intermittently (very hard to get vehicle to stop) Unsafe for me, would have been very unsafe for certain without significant physical strength.