2023 Chevrolet Colorado

The contact owns a 2023 Chevrolet Colorado. The contact stated that while driving on several occasions at various speeds, the Forward Collision Avoidance system activated, and the brakes inadvertently engaged. The Forward Collision Avoidance warning light illuminated, with an audible chime and an unknown message displayed. The contact stated that on one occasion the vehicle was pulled off the highway to avoid crashing with another vehicle. The vehicle was restarted and taken to a dealer. The contact received notification of NHTSA Campaign Number: 24V133000 (Electrical System, Forward Collision Avoidance) while getting service, and a system update was performed, and the front camera system was updated. The vehicle was repaired, but the failure returned three days later. The manufacturer was notified of the failure. The failure mileage was approximately 20,000.

My 2023 Chevrolet Colorado ZR2 cannot receive over‑the‑air (OTA) software updates because the gateway module is still running outdated firmware (XXX.mnf). General Motors issued Service Update XXX to correct this defect by performing a vehicle‑wide programming update. However, GM’s system incorrectly shows the bulletin as “closed” for my VIN even though the gateway module was never updated. The truck was sold to me by Tyrell Chevrolet in [XXX] with this safety‑related service update not completed properly. The dealership has confirmed they cannot perform the required update because GM’s system will not authorize it until the bulletin is reopened. GM corporate has been contacted multiple times, but after several days they have not reopened the bulletin or provided a resolution. Because the gateway module remains on outdated firmware, the vehicle cannot receive critical OTA updates related to safety, diagnostics, and module stability. This condition has been reported by other 2023 Colorado owners and has previously been associated with battery‑drain issues caused by software modules failing to sleep properly. GM has acknowledged the defect by issuing Service Update XXX, but they are refusing to reopen the update for my VIN despite the incomplete firmware and the vehicle’s inability to receive OTA updates. I am filing this complaint so the defect and GM’s refusal to correct it are formally documented. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On May 15, 2026, my 2023 Chevrolet Colorado (2.7L L3B turbocharged engine, approximately 49,000 miles) lost its entire engine oil charge while in normal operation, and at NO point did the low-oil-pressure warning light illuminate to alert me. While driving, a loud buzzing/vibrating noise developed near the upper engine and the center dash area. The vehicle continued to run with no oil-pressure warning of any kind — no low-oil-pressure light and no audible oil-pressure chime. Concerned by the noise, I immediately pulled into a parking lot and checked under the hood. The engine oil dipstick was completely dry, showing no oil whatsoever. I added 3 quarts of oil and the dipstick still showed no reading, indicating the engine had been operating with a critically low or empty oil level. Throughout this entire event, no oil-pressure warning activated. There was no external oil leak, no puddle where the vehicle is normally parked, and no oil in the coolant reservoir, which suggests the oil was being consumed or lost internally rather than dripping out — a condition the driver cannot see or anticipate without a functioning warning system. Drivers depend entirely on the oil-pressure warning system to alert them before oil starvation causes catastrophic engine damage or sudden engine seizure. An engine that seizes without warning while the vehicle is in motion creates an immediate and severe crash risk — sudden loss of motive power in traffic, on a highway, or in an intersection. The complete failure of this warning system to illuminate during a total loss of oil is, by itself, a safety defect independent of whatever is causing the oil loss, because it removes the driver's only opportunity to stop the vehicle safely before failure. These symptoms also align with existing GM service documentation: TSB 25-NA-309 addresses high idle, oil consumption, oil leaks, and MIL illumination caused by internal failure of the PCV oil separator, and service campaign N232415060 addresses a

My truck has used automatic emergency braking multiple times while driving at variable speeds with no obstacles or vehicles in front of me causing whiplash and further damage to my neck that has 5 budging discs. Since I’m only allowed to add a specific mileage and speed below, I’ll note here that it’s happened since I purchased the truck with roughly 35000 miles on it to the current mileage of 44000 and between speeds of 30mph-75mph.

Blind spot monitoring system consistently malfunctions, illuminating the driver mirror warning light when no other vehicles are present. It occurs more frequently after dark, which flickers the bright light continuously, or leaves it on constantly, creating a significant distraction and mistrust of the systems reliability. Dealer had no recommendation for fix.

COMPONENT FAILURE: Body Control Module causing systematic electrical failures: door locks, power windows, window regulators, four-wheel drive transfer case display. Components intact, available for inspection. SAFETY RISK: Door locks malfunction preventing emergency exit. Power windows fail affecting communication/egress. 4WD display fault (yellow AUTO vs white) indicates transfer case control issues affecting traction in mountain winter driving at 10,000ft elevation. Unpredictable electrical failures create safety risk during remote travel. DEALER CONFIRMATION: Approximately 20 dealer visits. Each time: scan codes, test drive, "no fault found." Problem temporarily clears via battery disconnect/reconnect, proving electrical fault not mechanical. Dealer cannot diagnose root cause, hasn't performed systematic electrical testing. MANUFACTURER INSPECTION: None despite repeated failures. WARNING SYMPTOMS: Intermittent: door ajar warnings, power window/lock failures, 4WD indicator yellow, various warning lights. All symptoms simultaneously resolve after battery disconnect/reconnect, indicating BCM or power distribution fault. Pattern repeats with increasing frequency. CRITICAL: Research shows multiple 2023 Colorado owners report identical patterns - intermittent multi-system failures resolving via battery reset. Indicates systematic 2023 model year defect, likely BCM firmware/hardware issue. Problem occurs unpredictably, clears during dealer transport. Request GM engineering data logging during normal operation.

I have experienced brake failure twice while driving my 2023 Chevrolet Colorado. When the failure occurs, the dashboard displays multiple warnings, including “Service Traction Control,” “Service Power Steering Drive With Care,” and “No Assist Soon.” When these messages appear, the steering becomes extremely stiff, the brakes lose stopping power, and the vehicle becomes very difficult to control. The first incident happened around April 2024, and the dealer performed a software update. The issue happened again around October 2024 at approximately 24,000 miles. The vehicle is primarily used on highways and has no modifications. This is a serious safety concern. The combination of brake loss and power steering failure could result in loss of control, crash, injury, or death. There was no warning before the failures occurred. The dealer cannot confirm a permanent fix. This problem needs to be investigated for a potential recall. This vehicle is now unsafe and unreliable. I refuse to transport my family in it. I am seeking a full refund/buyback, as multiple safety system failures are unacceptable and dangerous.

The contact owns a 2023 Chevrolet Colorado. The contact stated that several sensors were activated with contact being alerted to an issue with the Lane Keep Assist, and the vehicle veering out of the intended lane. The contact stated that while driving 45 MPH, the Forward Collision Avoidance: Automatic Emergency Braking activated unintendedly. The contact stated that the failure was self-corrected. The dealer was contacted, and an appointment was scheduled. The contact inquired of the the dealer if the VIN was included in NHTSA Campaign Number: 24V133000 (Electrical System, Forward Collision Avoidance). The dealer informed the contact that the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 15,000.

The contact owns a 2023 Chevrolet Colorado. The contact had taken the vehicle to the dealer for a routine oil change and after the vehicle was serviced, the contact was provided a multi-point vehicle inspection sheet which showed that the brake pads had received a green check mark and that the brake pads were 7-millimeters or greater on both the driver’s and passenger’s side. The next day upon start of the vehicle, the contact stated that a message "New Brake Pads Detected" question was displayed on the instrument panel. The contact selected the "No" option followed by another question to service the brake pads. The contact then stated that a "Service Brake Pad Monitoring System" message appeared on the instrument panel. The vehicle was taken back to the dealer where the dealer was informed of the messages. A mechanic inspected the vehicle and informed the contact that both the brake pads and rotors needed to be replaced. The contact was also informed that the brake pads were 2 millimeters or less, despite the contact receiving information the day prior which stated otherwise. The contact questioned the dealer about the discrepancy and was informed that the computer provided the results for the multi-point vehicle inspection. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 27,000.