IllustrationThe frame on my 2004 Chevy Colorado has rusted/rotted to the point that it snapped, causing the bed to rub against the cab. Mechanic said it is not fixable.
2004 Chevrolet Colorado
Owner reports · Recalls · Investigations
More warning signs than most Colorado years
Owner complaints for the 2004 Chevrolet Colorado are substantially higher than the model-year median of 84.
About this comparison →How this year compares
Owner complaints by model year
Compare all Colorado years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
5025–50K
3950–75K
4575–100K
49100–150K
21150K+
283 reports with mileage · 78 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports13 fire reports14 injury reports
Unknown Or Other complaints
22 reportsFrame rust
Frame of my vehicle is rotting away causing to fail inspection. Just finding out that Toyota did a recall on one of there pick up models replacing their frame due rotting frames that may be a safety factor if it gets into an accident. Does Chevy Colorado have a recall as such? Just had my frame recently welded on a piece of hea…
Read full complaint
Frame of my vehicle is rotting away causing to fail inspection. Just finding out that Toyota did a recall on one of there pick up models replacing their frame due rotting frames that may be a safety factor if it gets into an accident. Does Chevy Colorado have a recall as such? Just had my frame recently welded on a piece of heavy metal to reinforce my frame in order to pass a safety inspection
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major pr…
Read full complaint
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major problems for the safety of the occupants and other drivers on the road. I looked up online if other Colorado owners had the same issue and others have the same problem. I’m am forced to junk this vehicle even though the rest of the truck is in very good condition
FRAME RUSTED OUT LIKE THE TOYOTAS DID AND IS NO LONGER SAFE TO DRIVE.
I SOLD THIS TRUCK LAST SPRING WITH 243,829 ON THE ODOMETER, IT IS NOW FOR SALE WITH 155,000 ON IT
I OWN A 2004 CHEVY COLORADO EXTENDED CAB. THIS TRUCK HAS 110,XXX MILES ON IT. THE PROBLEM IS THE FRAME ON THE VEHICLE, IT BROKE IN 2 PIECES WHERE THE CAB MEETS THE BED. THE FRAME IS COMPLETELY RUSTED AND RUINED. THERE ARE A LOT OF FORUMS ONLINE WITH PEOPLE WITH THE SAME ISSUE IN THE SAME SPOT OF THE FRAME. IT IS VERY UNSETTLING …
Read full complaint
I OWN A 2004 CHEVY COLORADO EXTENDED CAB. THIS TRUCK HAS 110,XXX MILES ON IT. THE PROBLEM IS THE FRAME ON THE VEHICLE, IT BROKE IN 2 PIECES WHERE THE CAB MEETS THE BED. THE FRAME IS COMPLETELY RUSTED AND RUINED. THERE ARE A LOT OF FORUMS ONLINE WITH PEOPLE WITH THE SAME ISSUE IN THE SAME SPOT OF THE FRAME. IT IS VERY UNSETTLING KNOWING EVEN IF I DONT DRIVE THIS TRUCK AGAIN ANOTHER CHEVY COLORADO ON THE HIGHWAY COULD RIP IN 2 PEICES CAUSING AN ACCIDENT DUE TO THE FAULTY FRAME ON THESE TRUCKS. THIS IS AN OBVIOUS ISSUE THAT CHEVY WILL NOT ADDRESS. WHEN MY FRAME BROKE INTO 2 PIECES INWARD DRIVING DOWN THE ROAD. THE BED CAME FREE ON THE DRIVER SIDE AND SMASHED IN THE BACK CORNER OF MY CAB. LUCKILY I WAS NOT ON THE HIGH WAY BECAUSE IF I WAS IT WOULD HAVE CAUSED AN ACCIDENT. I HOPE CHEVY MAKES RIGHT BY THIS.
THE FRAME HAS ALOT OF RUST PLUS THE FRAME IS CRACKED AND THE BACK,THE ENGINE LIGHT IS ON YOU CAN NOT GET A RESPONSE FROM THE PLUGING UNIT. WHE YOU TO CHECK THE PROBLEM.
THE FRAME IS ROTTING OUT--I'VE HAD TO HAVE IT REPAIRED--WELDED--EACH OF THE LAST THREE YEARS AFTER FAILING INSPECTION OR BEING TOLD IT WOULD. SUSPENSION ATTACHMENT AREAS, UNDER AND AROUND SHACKLES, CAB MOUNTS, LONG SECTIONS OF PRIMARY FRAME FROM FRONT TO REAR.
NOTICED THE FRAME IS ROTTING OUT AND NEEDS TO GET FIXED BEFORE IT CAUSES A SERIOUS ACCIDENT AND POSSIBLY DEATH .IT WAS SITTING STILL WHEN NOTICE
Official recalls
310V575000 · Child Seat
Nov 18, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence & remedy
Consequence: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
09V310000 · Exterior Lighting:brake Lights:switch
Jul 29, 2009
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
06V139000 · Exterior Lighting:brake Lights:switch
Apr 27, 2006
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence & remedy
Consequence: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ09001 · Brake Lamp Switch Malfunction
Opened Feb 25, 2009 · Closed Jul 30, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Exterior Lighting
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
PE04076 · Inadvertent Front Airbag Deployment
Opened Nov 10, 2004 · Closed Mar 14, 2005
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:frontal
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.