NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
239 reportsClear category filter27,000 miles · Sep 9, 2015
Steering
EARLIER THIS YEAR (MAYBE IN JUNE OR JULY), I TOOK MY CAR INTO BOB BELL CHEVROLET FOR THE IGNITION SWITCH AND POWER STEERING RECALL. THEN, APPROXIMATELY TWO WEEKS AGO (AUGUST 31), MY POWER STEERING FAILED, AGAIN, WHILE I WAS PARALLEL PARKING. I CALLED THE DEALERSHIP TO LET THEM KNOW THAT IT APPEARS THAT THE REPAIR WASN'T DONE COR…
Read full complaint
EARLIER THIS YEAR (MAYBE IN JUNE OR JULY), I TOOK MY CAR INTO BOB BELL CHEVROLET FOR THE IGNITION SWITCH AND POWER STEERING RECALL. THEN, APPROXIMATELY TWO WEEKS AGO (AUGUST 31), MY POWER STEERING FAILED, AGAIN, WHILE I WAS PARALLEL PARKING. I CALLED THE DEALERSHIP TO LET THEM KNOW THAT IT APPEARS THAT THE REPAIR WASN'T DONE CORRECTLY OR ISN'T WORKING. THEY TOLD ME THAT I NEEDED TO BRING THE CAR IN TO SEE IF THAT'S THE PROBLEM. THEY DIDN'T EXPRESS ANY TYPE OF APOLOGY FOR THE FAILURE OR SUGGEST THAT THEY WOULD CHECK WITH GM OR REPORT THE FAILURE OF THE REPLACEMENT PART. THEY JUST SUGGESTED THAT THERE WAS NO WAY FOR THEM TO KNOW WHAT IS GOING ON WITH THE CARE THIS TIME.
NHTSA ODI #10762601
61,788 miles · Aug 5, 2015
Steering
I HAD SLOWED DOWN TO MAKE A RIGHT TURN AND MY STEERING WHEEL HAD TIGHTENED UP , MAKING MY CAR GO TOWARDS ONCOMING TRAFFIC . HAD TO USE BOTH HANDS TO FORCEFULLY TURN THE STEERING WHEEL . HAS HAPPENED ABOUT 10 MORE TIMES SINCE THE FIRST INCIDENT . I JUST BOUGHT THIS CAR 03-17-15.
NHTSA ODI #10746326
85,000 miles · Jul 7, 2015
Air BagsSteeringCrashInjury
TL* THE CONTACT OWNED A 2010 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO A DITCH AND FLIPPED OVER APPROXIMATELY FOUR TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS NOT WEARING A SEAT BELT AND WAS EJECTED FROM THE VEHICLE. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNED A 2010 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO A DITCH AND FLIPPED OVER APPROXIMATELY FOUR TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS NOT WEARING A SEAT BELT AND WAS EJECTED FROM THE VEHICLE. THE VEHICLE LANDED ON TOP OF THE DRIVER. THE DRIVER SUSTAINED FOUR FRACTURED RIBS, A FRACTURED FOREARM ON THE LEFT ARM, A PUNCTURE WOUND ON THE LOWER LEFT CALF, A PUNCTURED LUNG, AND NERVE DAMAGE TO THE HIPS AND SHOULDERS. MEDICAL ATTENTION WAS REQUIRED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), 14V171000 (ELECTRICAL SYSTEM), AND 14V153000 (STEERING). THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
NHTSA ODI #10732506
65,000 miles · Apr 3, 2015
Steering
TL* THE CONTACT OWNS A 2010 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10703483
76,000 miles · Mar 14, 2015
Air BagsElectrical SystemSteeringCrashFireInjury
I TOOK EVASIVE ACTION BY SWERVING TO AVOID COLLISION WITH OTHER VEHICLE THAT ABRUPTLY CHANGED LANE AND COLLIDED WITH MY VEHICLE. A RESULTS, MY VEHICLE STRUCK A CONCRETE BARRIER WALL OF THE ROADWAY, THEN BURST INTO FLAMES UPON IMPACT. MY VEHICLE WAS COMPLETELY BURNT OUT AT A TOTAL LOSS BEFORE FIRE RESCUE RESPONDED. THE AIRBAG NE…
Read full complaint
I TOOK EVASIVE ACTION BY SWERVING TO AVOID COLLISION WITH OTHER VEHICLE THAT ABRUPTLY CHANGED LANE AND COLLIDED WITH MY VEHICLE. A RESULTS, MY VEHICLE STRUCK A CONCRETE BARRIER WALL OF THE ROADWAY, THEN BURST INTO FLAMES UPON IMPACT. MY VEHICLE WAS COMPLETELY BURNT OUT AT A TOTAL LOSS BEFORE FIRE RESCUE RESPONDED. THE AIRBAG NEVER DEPLOYED. PRIOR TO ACCIDENT I WAS HAVING NUMEROUS IGNITION RELATED PROBLEMS WITH MY CHEVY COBALT. *TR
NHTSA ODI #10694303
39,010 miles · Jan 22, 2015
Steering
TL*THE CONTACT OWNS A 2010 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, AN ABNORMAL NOISE EMITTED FROM THE STEERING WHEEL. THE CONTACT STATED THAT THE STEERING WHEEL BEGAN TO SHAKE WHENEVER THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DI…
Read full complaint
TL*THE CONTACT OWNS A 2010 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, AN ABNORMAL NOISE EMITTED FROM THE STEERING WHEEL. THE CONTACT STATED THAT THE STEERING WHEEL BEGAN TO SHAKE WHENEVER THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 39,010.
NHTSA ODI #10678300
53,725 miles · Jan 2, 2015
Steering
GM DEALER RECALLED CAR TO FIX ELECTRIC POWER STEERING ASSIST. TOOK CAR IN AND HAD PART REPLACED BUT WHEN CAR WAS DRIVEN HOME IT HAD A GRINDING NOISE AND WAS DIFFICULT TO STEER, WHICH WAS NOT A PROBLEM BEFORE RECALL. RETURNED TO DEALER WHO REPLACED SAID MOTOR AGAIN, WITH SAME RESULTS. RETURNED VEHICLE TO DEALER AGAIN ON 12/3…
Read full complaint
GM DEALER RECALLED CAR TO FIX ELECTRIC POWER STEERING ASSIST. TOOK CAR IN AND HAD PART REPLACED BUT WHEN CAR WAS DRIVEN HOME IT HAD A GRINDING NOISE AND WAS DIFFICULT TO STEER, WHICH WAS NOT A PROBLEM BEFORE RECALL. RETURNED TO DEALER WHO REPLACED SAID MOTOR AGAIN, WITH SAME RESULTS. RETURNED VEHICLE TO DEALER AGAIN ON 12/30/2014 TO DO DIAGNOSTIC ON PROBLEM WITH STEERING, REALER SAID THERE IS NO DANGER TO DRIVE VEHICLE BUT NEEDS STEERING COLUMN WHICH DEALER REFUSES TO REPLACE UNLESS I ABSORB THE COST THERE WAS NO PROBLEMS WITH STEERING BEFORE DEALER EXCHANGED THE ELECTRIC POWER STEERING ASSIST. *TR
NHTSA ODI #10669732
55,000 miles · Nov 10, 2014
SteeringCrash
VEHICLE LOST STEERING ABILITY RESULTING IN CRASH ON BANK OF ROADWAY. *TR
NHTSA ODI #10653941
55,000 miles · Oct 2, 2014
Steering
CHEVY COBALT IGNITION RECALL WORK PERFORMED ON THE CAR. IMMEDIATELY AFTER COMPLETITION OF WORK THE STEERING WHEEL SHAKES, HARD TO CONTROL, HARD TO STEER AND MOTOR IN STEERING COLUMN FAILED. INDEPENDENT MECHANIC CONFIRMED ISSUE. *TR
NHTSA ODI #10640865
68,000 miles · Sep 26, 2014
Steering
TL* THE CONTACT OWNS A 2010 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 60 MPH, THE POWER STEERING FAILED AND A CHIME SOUNDED. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEA…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 60 MPH, THE POWER STEERING FAILED AND A CHIME SOUNDED. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.
NHTSA ODI #10639383
Official recalls
5Aug 10, 2015
General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an electrical short that disables the driver side curtain air bag.
Consequence & remedy
Consequence: A disabled driver side roof-rail air bag will not deploy in the event of a crash necessitating deployment of that air bag, increasing the risk of injury to the driver.
Remedy: GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15075.
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Illustration