NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
845 reportsMileage unknown · Mar 13, 2016
Air BagsFuel/propulsion SystemSteering
I JUST BOUGHT 2008 CHEVY COBALT. THE SELLER REPORTED THE MILEAGE INITIALLY AS 112,000. AT TIME OF PURCHASE, 150,000 APPROXIMATELY. HOWEVER THERE WAS/IS NO WAY TO VIEW MILEAGE ON DASH OF CAR, WITH THE EXCEPTION OF BRIEFLY PRIOR TO STARTING THE VEHICLE. IT ACTUALLY SHOWS APPROXIMATELY 159,000 KM. CONVERSION OF KM INTO MILES S…
Read full complaint
I JUST BOUGHT 2008 CHEVY COBALT. THE SELLER REPORTED THE MILEAGE INITIALLY AS 112,000. AT TIME OF PURCHASE, 150,000 APPROXIMATELY. HOWEVER THERE WAS/IS NO WAY TO VIEW MILEAGE ON DASH OF CAR, WITH THE EXCEPTION OF BRIEFLY PRIOR TO STARTING THE VEHICLE. IT ACTUALLY SHOWS APPROXIMATELY 159,000 KM. CONVERSION OF KM INTO MILES SAYS 98,000. IN ADDITION TO MILEAGE DISCREPANCY, THERE IS A VERY STRONG SMELL OF GAS INSIDE THE CAR, THE STEERING WHEEL IS UPSIDE DOWN, 2 OR 3 MOTOR AND OR TRANSMISSION MOUNTS ARE BROKEN OR NOT ATTACHED, RIGHT FRONT ROTOR BAD, NO FUNCTIONING BLINKERS OR BRAKE LIGHTS, DASH LIGHTS INDICATE SVC TIRE MONITOR NEEDS ATTENTION, AIR BAGS NEED SERVICED, BRAKE LIGHT STAYS ON, THE TRUNK RELEASE ISN'T WORKING, THE WIRING IS QUESTIONABLE, ONLY ONE SPEAKER WORKS, NO STEREO ANTENNAE, NO HORN, NO WAY TO VIEW CRITICAL ENGINE INFORMATION, SUCH AS TEMPERATURE OR BATTERY LIFE. SERVICE ENGINE LIGHT ON CONSTANTLY, SELLER INDICATED ALL RECALLS HAD BEEN ADDRESSED AND HE WAS SUPPOSED TO BE RESPONSIBLE FOR TAXES ON VEHICLE WHICH WERE INCLUDED IN PRICE, BUT I WOUND UP PAYING BACK REGISTRATION FEES FROM 2014. ALL ATTEMPTS TO RIGHT THIS HAVE BEEN IGNORED. SELLER IMPLIES THAT THE CHEVROLET DEALERSHIP LEFT THE CAR IN THE CURRENT CONDITION.
NHTSA ODI #10846329
110,000 miles · Mar 13, 2016
EngineWheels
MY FUEL PUMP WAS LEAKING, SO WE HAD THE FUEL PUMP REPLACED AND NOW THE AIR CONDITIONING/HEATER/DEFROST SYSTEMS NO LONGER WORK. WE'VE HAD TO REPLACE THE STEERING COLUMN, THE FUEL INJECTION, AND A LEAKING FRONT WINDSHIELD TWICE.ALSO THE FUEL SWITCH. NOW THE CAR SOMEWHAT STALLS WHEN TRYING TO START.
NHTSA ODI #10846315
140,000 miles · Mar 10, 2016
Electrical SystemService BrakesSteering
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING 55 MPH, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE POWER STEERING FAILED AND THE SPEEDOMETER, FUEL GAUGE, AND TACHOMETER NEEDLES MOVED BACK AND FORTH AND DISPLAYED INACCURATE READINGS. THE VEHICLE WAS TAKEN TO THE DEALER TO B…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING 55 MPH, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE POWER STEERING FAILED AND THE SPEEDOMETER, FUEL GAUGE, AND TACHOMETER NEEDLES MOVED BACK AND FORTH AND DISPLAYED INACCURATE READINGS. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ELECTRONIC BRAKE CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE REMEDY DID NOT RESOLVE THE ISSUE. THE CONTACT STATED THAT THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10846009
50,000 miles · Mar 3, 2016
Steering
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, THERE WAS A TEMPORARY LOSS OF POWER STEERING AND THE VEHICLE CONTINUED NORMAL OPERATION. THE FAILURE RECURRED ONE TO TWO TIMES DAILY. IN 2010, THE MANUFACTURER REPLACED THE POWER STEERING MOTOR POSSIBLY UNDER THE CUSTOMER SATISFACTION PROGRAM. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, THERE WAS A TEMPORARY LOSS OF POWER STEERING AND THE VEHICLE CONTINUED NORMAL OPERATION. THE FAILURE RECURRED ONE TO TWO TIMES DAILY. IN 2010, THE MANUFACTURER REPLACED THE POWER STEERING MOTOR POSSIBLY UNDER THE CUSTOMER SATISFACTION PROGRAM. THE FAILURE RECURRED MOST RECENTLY AND THE DEALER DENIED TO SERVICE THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 0V073000 (STEERING) DUE TO THE EXCESSIVE MILEAGE ON THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 06/15/16*LJ
NHTSA ODI #10839738
110,000 miles · Feb 27, 2016
Air BagsElectrical SystemSteering
POWER STEERING WENT OUT WHILE I WAS DRIVING AT A SPEED OF 45 MPH. I CHECKED FUSE AND IT WAS BLOWN. I THEN BUT NEW FUSE IN AND STARTED CAR. THE SECOND I STARTED THE CAR THE FUSE BLEW AGAIN. THE STRANG THING WAS THAT EVEN THO THE FUES HAD BLOWN THE POWER STEERING CONTINUED TO WORK UNTIL THE CAR WAS SHUT OFF. ALSO MY RADIO STARTED …
Read full complaint
POWER STEERING WENT OUT WHILE I WAS DRIVING AT A SPEED OF 45 MPH. I CHECKED FUSE AND IT WAS BLOWN. I THEN BUT NEW FUSE IN AND STARTED CAR. THE SECOND I STARTED THE CAR THE FUSE BLEW AGAIN. THE STRANG THING WAS THAT EVEN THO THE FUES HAD BLOWN THE POWER STEERING CONTINUED TO WORK UNTIL THE CAR WAS SHUT OFF. ALSO MY RADIO STARTED CHANGING STATIONS BY ITSELF AND AIRBAG WARNING CAME ACROSS THE DASH THEN A COUPLE DAYS AFTER THAT STARTED I WENT TO START THE CAR AND IT WOULDN'T. RADIO, OUTSIDE LIGHTS AND BLINKERS, INTERIOR LIGHTS, AND DASH LIGHTS WOULD ALL STILL WORK, BUT IT SEEMED THAT NO POWER WAS GETTING TO THE STARTER NOR THE FULE PUMP. AT THIS TIME THE CAR STILL WON'T START
NHTSA ODI #10838805
105,000 miles · Feb 11, 2016
Steering
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME INOPERABLE AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME INOPERABLE AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.
NHTSA ODI #10825558
108,000 miles · Feb 8, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN HAD DIAGNOSED THAT THERE WAS A FUEL LEAK IN VEHICLE, WHICH CAUSED THE FUEL LINE AND THE FUEL FILTER TO CORRODE. THE VEHICLE WAS NOT REPAIRED. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN HAD DIAGNOSED THAT THERE WAS A FUEL LEAK IN VEHICLE, WHICH CAUSED THE FUEL LINE AND THE FUEL FILTER TO CORRODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE) HOWEVER THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.
NHTSA ODI #10824760
88,000 miles · Jan 30, 2016
Steering
I BOUGHT A 2008 CHEVROLET COBALT FOR MY SIXTEEN YEAR OLD DAUGHTER IN 2012. SHE COMPLAINED OF THE CAR LOSING POWER STEERING ON OCCASION , BUT I DID NOT KNOW TO WHAT EXTENT UNTIL I DROVE THE CAR. THE GAUGES WOULD SUDDENLY START FLUCTUATING AND THE CAN WOULD LOSE ALL POWER STEERING AND THE TRANSMISSION ACTED AS IF IT DIDN'T WANT TO…
Read full complaint
I BOUGHT A 2008 CHEVROLET COBALT FOR MY SIXTEEN YEAR OLD DAUGHTER IN 2012. SHE COMPLAINED OF THE CAR LOSING POWER STEERING ON OCCASION , BUT I DID NOT KNOW TO WHAT EXTENT UNTIL I DROVE THE CAR. THE GAUGES WOULD SUDDENLY START FLUCTUATING AND THE CAN WOULD LOSE ALL POWER STEERING AND THE TRANSMISSION ACTED AS IF IT DIDN'T WANT TO SHIFT. I TOOK CAR TO CHEVY DEALERSHIP IN MOREHEAD CITY N.C. AND THEY KEPT THE CAR FOR TWO WEEKS BECAUSE THEY COULD NOT REPRODUCE SYMPTOMS. I WAS CHARGED FOR INSPECTING CAR, BUT CAR WAS NOT FIXED. I CONTACTED CHEVYS MAINI HEADQUARTERS AND EXPLAINED THE SITUATION. I INFORMED REPRESENT I'VE THAT I DID NOT FEEL SAFE WITH MY DAUGHTER DRIVING THE CAR. SHE ADVISED ME NOT TO DRIVE THE CAR. PROBLEM IS IS THAT I STILL AM MAKING PAYMENTS AND INSURANCE ON VEHICLE MY DAUGHTER ENDED UP BUYING ANOTHER CAR SINCE THEN , DO TO THIS SAFETY ISSUE. I NOW HAVE CAR, WHICH I HAVE HAD TO DRIVE FOR THE LAST MONTH AND IT IS DOING THE SAME THING, YET MORE FREQUENTLY. I AGAIN TOOK CAR TO DEALERSHIP AND HE QUICKLY DIAGNOSED THE CAR WITH HAVING A BAD BATTERY. $200 LATER, I AM NOW HOPEFUL THE CAR IS FINALLY FIXED AFTER YEARS OF DEALING WITH IT. NO , I WAS WRONG AGAIN. I AM COMPLETE DISSAPPOINTED IN CHEVY FOR MAKING SUCH A WORTHLESS PIECE OF JUNK AND THEN NOT HAVING THE INTEGRITY TO OWE UP TO IT'S FAULT IN DEVELOPING A SUBSTAINDURED PRODUCT. IN THE PROCESS OF TRYING TO FIND A SOLUTION OR REPAIR FOR THIS, I HAVE COME ACROSS HUNDREDS IF NOT THOUSANDS OF COMPLAINTS ABOUT THE SAME ISSUE. IS SOMEONE GOING TO HAVE TO BE KILLED BEFORE CHEVY OWNS UP TO ITS MISTAKE AND MAKE IT RIGHT FOR CONSUMERS. I AM IN THE MARKET FOR A NEW CAR, BUT AFTER THIS EXPERIENCE I WILL NOT BE BUYING A CHEVY PRODUCT. I TRULY HOPE THAT THE ISSUE AT HAND WILL BRING ATTENTION TO THE DEFECTS CHEVY IS ALLOWING. THIS IS NOT JUST A CAR PROBLEM, THIS IS PEOPLES LIVES WE ARE TALKING ABOUT.
NHTSA ODI #10823196
86,954 miles · Jan 28, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS A FUEL ODOR COMING FROM THE VEHICLE AND NOTICED FUEL LEAKING IN FRONT OF THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MOISTURE FROM THE MUFFLER PIPE CORRODED THE FUEL LINE, CAUSING IT TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WA…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS A FUEL ODOR COMING FROM THE VEHICLE AND NOTICED FUEL LEAKING IN FRONT OF THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MOISTURE FROM THE MUFFLER PIPE CORRODED THE FUEL LINE, CAUSING IT TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LINE WAS CORRODED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,954. UPDATED 04/14/16*LJ *JS
NHTSA ODI #10822806
Mileage unknown · Jan 27, 2016
Electrical System
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE PARKED, THE INDICATORS IN THE INSTRUMENT PANEL BEGAN TO FLICKER AND THE STEERING WHEEL REQUIRED FORCE IN ORDER TO MANEUVER THE VEHICLE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINE…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE PARKED, THE INDICATORS IN THE INSTRUMENT PANEL BEGAN TO FLICKER AND THE STEERING WHEEL REQUIRED FORCE IN ORDER TO MANEUVER THE VEHICLE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10822564
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration