NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
166 reportsClear category filterMileage unknown · Aug 18, 2020
Electrical System
CAR WOULD NOT TURN KEY OR SOME TIMES START OR GO INTO GEAR. IT IS ALWAYS HIT AND MISS. WITH THIS CAR CAR STILL HAS ONLY 40 SOME THOUSAND MILES ON ENGINE. ALWAYS BROKE DOWN IN DRIVE WAY OR ANY WHERE EVER PARKED. WHEN DRIVING SOMETIMES SEVERAL DIFFERENT LIGHTS ON DASH COMES ON ALL AT ONCE. THIS CAR HAS BEEN A REAL PROBLEM FROM 201…
Read full complaint
CAR WOULD NOT TURN KEY OR SOME TIMES START OR GO INTO GEAR. IT IS ALWAYS HIT AND MISS. WITH THIS CAR CAR STILL HAS ONLY 40 SOME THOUSAND MILES ON ENGINE. ALWAYS BROKE DOWN IN DRIVE WAY OR ANY WHERE EVER PARKED. WHEN DRIVING SOMETIMES SEVERAL DIFFERENT LIGHTS ON DASH COMES ON ALL AT ONCE. THIS CAR HAS BEEN A REAL PROBLEM FROM 2010.
NHTSA ODI #11350104
150,000 miles · Nov 18, 2019
Electrical System
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE THE CONTACT WAS SEATED IN THE DRIVER'S SEAT WITHOUT THE KEY IN THE IGNITION, THE VEHICLE ATTEMPTED TO START INDEPENDENTLY. THE CONTACT STATED THAT THE INTERNAL LIGHTING FLASHED ON AND OFF. THE CONTACT STATED THAT THE VEHICLE ATTEMPTED TO START INDEPENDENTLY UNTIL THE BATTERY WA…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. WHILE THE CONTACT WAS SEATED IN THE DRIVER'S SEAT WITHOUT THE KEY IN THE IGNITION, THE VEHICLE ATTEMPTED TO START INDEPENDENTLY. THE CONTACT STATED THAT THE INTERNAL LIGHTING FLASHED ON AND OFF. THE CONTACT STATED THAT THE VEHICLE ATTEMPTED TO START INDEPENDENTLY UNTIL THE BATTERY WAS DEPLETED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE BATTERY WAS RECHARGED. CLASSIC CHEVROLET OF LAKE CITY (6190 W BLUE RD, LAKE CITY, MI 49651, (888) 580-3758) WAS CALLED AND INFORMED OF THE FAILURE. THE CONTACT STATED THAT THE IGNITION WAS REPLACED ON FOUR SEPARATE OCCASIONS; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #11280872
50,000 miles · Jul 24, 2019
Air BagsElectrical System
THE VEHICLE BEGAN HAVING ELECTRICAL PROBLEM A FEW YEARS AFTER PURCHASE IN 2008. THE POWER WINDOWS BECAME NON OPERABLE, RADIO SPEAKERS STOPPED WORKING, DOOR LOCKS DON'T UNLOCK VIA POWER SWITCH, AC/ HEAT ISSUES (DOESN'T FUNCTION PROPERLY), AND WIRE HARNESSES NEAR SEAT BELT COLUMN (WHERE BELT MEETS FLOOR) BECAME SEVERED FROM SEAT B…
Read full complaint
THE VEHICLE BEGAN HAVING ELECTRICAL PROBLEM A FEW YEARS AFTER PURCHASE IN 2008. THE POWER WINDOWS BECAME NON OPERABLE, RADIO SPEAKERS STOPPED WORKING, DOOR LOCKS DON'T UNLOCK VIA POWER SWITCH, AC/ HEAT ISSUES (DOESN'T FUNCTION PROPERLY), AND WIRE HARNESSES NEAR SEAT BELT COLUMN (WHERE BELT MEETS FLOOR) BECAME SEVERED FROM SEAT BELT COLUMN MOVEMENT.... THIS CAUSED AIR BAGS TO STOP FUNCTIONING.
NHTSA ODI #11234671
Mileage unknown · Jun 17, 2019
Electrical SystemUnknown Or Other
THE BATTERY OF THIS VEHICLE, AND EVEN NEW ONES FROM THE SAME MANUFACTURER, HAVE THE BATTERY INSTALLED IN THE TRUNK FROM THE FACTORY. THERE'S A BRITTLE PLASTIC TUBE THAT VENTS THE TOXIC FUMES GENERATED BY AN OPERATING BATTERY TO THE OUTSIDE OF THE CAR. IF THIS TUBE IS DAMAGED/BROKEN, IT ALLOWS FUMES TO ENTER THE TRUNK, AND SEEP I…
Read full complaint
THE BATTERY OF THIS VEHICLE, AND EVEN NEW ONES FROM THE SAME MANUFACTURER, HAVE THE BATTERY INSTALLED IN THE TRUNK FROM THE FACTORY. THERE'S A BRITTLE PLASTIC TUBE THAT VENTS THE TOXIC FUMES GENERATED BY AN OPERATING BATTERY TO THE OUTSIDE OF THE CAR. IF THIS TUBE IS DAMAGED/BROKEN, IT ALLOWS FUMES TO ENTER THE TRUNK, AND SEEP INTO THE CABIN. THE FUMES CORRODE YOUR LUNGS, WHICH IN SOME CASES, SUCH AS MINE, LEADS TO HYPOXIA, MEANING THAT THE OPERATOR OF THE VEHICLE IS DIZZY & CONFUSED. THIS ISSUE NOT ONLY AFFECTS THE OWNERS/OCCUPANTS OF THE VEHICLES WITH THIS DESIGN, BUT COULD POTENTIALLY ENDANGER UNSUSPECTING PEDESTRIANS/MOTORISTS DUE TO THE OPERATOR OF A VEHICLE BECOMING INCAPACITATED, OR THEY MAY SIMPLY BLACK OUT AT THE WHEEL DUE TO A LACK OF OXYGEN TO THE BRAIN. THE FUMES ARE ALLOWED TO BUILD UP IN THE CABIN OF THE CAR IF THE WINDOWS ARE LEFT UP AND THE AIR CONDITIONER IS ON RECIRCULATE. THE FUMES ARE ODORLESS MEANING THAT YOU CAN GO ABOUT OPERATING THE VEHICLE FOR AN EXTENDED PERIOD OF TIME WITHOUT NOTICING THAT THERE'S A PROBLEM, NOT THAT IT WOULD MATTER SINCE THE FUMES CORRODE THE NERVE IN YOUR NOSE THAT ALLOW YOU TO HAVE A SENSE OF SMELL. THE SYMPTOMS ARE FLU LIKE, WHICH MAY LEAD A VICTIM TO IGNORE THEIR SYMPTOMS. IN MY PARTICULAR INSTANCE, THE FUMES THAT WERE ENTERING THE CABIN OF MY CAR WAS SULFURIC ACID. THIS DESIGN FLAW COULD EASILY LEAD TO DEATH, IF NOT FROM THE HIGHLY TOXIC, CARCINOGENIC FUMES THAT ARE ENTERING THE CABIN OF THE VEHICLE, THEN THE CONFUSION/DIZZINESS THAT THE FUMES LEAD TO, WHICH NOT ONLY ENDANGERS THE OPERATOR OF THE VEHICLE, BUT UNSUSPECTING PEDESTRIANS/MOTORISTS WHO MAY BE IN THE PATH OF A VEHICLE WITH AN OPERATOR WHO HAS BLACKED OUT, OR IS SIMPLY CONFUSED/DIZZY DUE TO A LACK OF OXYGEN TO THE BRAIN. THE PART NUMBER OF THE TUBE FOR MY SPECIFIC CAR IS 15247277. TRUNK BATTERIES SHOULD BE OUTLAWED UNLESS AFTERMARKET.
NHTSA ODI #11220716
130,000 miles · Mar 18, 2019
Electrical SystemSteering
THE GAUGES ON THE DASH GO HAYWIRE. A SUBTLE 'DING DING' SOUND IS MADE. THE ENGINE HAS DIFFICULTY ACCELERATING AND WILL ONLY DO SO IN SPURTS. A POWER STEERING WARNING IS DISPLAYED ON THE DASH AND THE STEERING WHEEL BECOMES VERY TIGHT AND IMPOSSIBLE TO TURN. CAR WILL GIVE YOU ABOUT A MINUTE, TOPS, TO DO SOMETHING BEFORE SHUTTING D…
Read full complaint
THE GAUGES ON THE DASH GO HAYWIRE. A SUBTLE 'DING DING' SOUND IS MADE. THE ENGINE HAS DIFFICULTY ACCELERATING AND WILL ONLY DO SO IN SPURTS. A POWER STEERING WARNING IS DISPLAYED ON THE DASH AND THE STEERING WHEEL BECOMES VERY TIGHT AND IMPOSSIBLE TO TURN. CAR WILL GIVE YOU ABOUT A MINUTE, TOPS, TO DO SOMETHING BEFORE SHUTTING DOWN COMPLETELY. ISSUE HAPPENS RANDOMLY BUT SEEMS TO BE TRIGGERED BY THE CAR DECELERATING INTO FIRST GEAR, AT A STOPLIGHT FOR EXAMPLE. HOWEVER, THIS PAST INCIDENT HAPPENED WHILE ON THE INTERSTATE AND NEARLY CAUSED A COLLISION WITH A SEMI. MY PARTICULAR VIN IS NOT INCLUDED IN THE LOSS OF POWER STEERING RECALL INVOLVING CHEVROLET COBALTS, GENERAL MOTORS RECALL NUMBER:10023 AND NHTSA RECALL NUMBER: 10V073000. HOWEVER, BASED ON PERFORMANCE THE PAST 6 MONTHS, I SINCERELY BELIEVE IT SHOULD BE. *TR
NHTSA ODI #11187430
95,000 miles · Dec 27, 2018
Electrical SystemSteeringVisibility/wiper
"TAKATA RECALL" I AM BUYING THIS VEHICLE FROM A BUY HERE PAY HERE LOT.DURING MY EXPERIERNCE DRIVING THIS CAR. I'VE HAD TROUBLE STEERING THE WHEEL.I BROUGHT IN IN TO TIRE DISCOUNTERS FOR INSPECTION TESTING. THE RESULT THE AUTO TECH EXPLAINED TO ME IN WRITING THAT I HAVE ELECTRICAL ISSUES WITH THE CAR.ALSO THE TIRES WAS PLACED ON …
Read full complaint
"TAKATA RECALL" I AM BUYING THIS VEHICLE FROM A BUY HERE PAY HERE LOT.DURING MY EXPERIERNCE DRIVING THIS CAR. I'VE HAD TROUBLE STEERING THE WHEEL.I BROUGHT IN IN TO TIRE DISCOUNTERS FOR INSPECTION TESTING. THE RESULT THE AUTO TECH EXPLAINED TO ME IN WRITING THAT I HAVE ELECTRICAL ISSUES WITH THE CAR.ALSO THE TIRES WAS PLACED ON BACKWARDS AND THE CAR NEEDS NEW TIRES.THE CHECK ENGINE LIGHT IS ON IN THE CAR.IN MOTION ON THE STREET WHEN EXPERIENCING THIS PROBLEM.THE SENSORS ARE BAD.THIS VECHICLE IS PROGRAMMED AND NEEDS A REMOTE.I HAVE TO GO TO THE DEALER RESOLVE IT.TIME AUTO SALES IN LATONIA KENTUCKY PREVIOUS OWNER OF THIS CAR.
NHTSA ODI #11163647
115,000 miles · Aug 17, 2018
Electrical SystemExterior LightingFuel/propulsion System
I FIRST HAD NOTICED MY FRONT PASSENGER SPEAKER WOULD CUT IN AND OUT. IT DIDN'T MATTER IF THE CAR WAS STATIONARY OR IF I WAS DRIVING. THE FOLLOWING WEEK I WAS DRIVING THROUGH THE PARKING LOT OF MY JOB AND THE DOORS LOCKS STARTED LOCKING AND UNLOCKING RAPIDLY BY THEMSELVES. AND NOW THEY RARELY EVER DO EITHER WHEN I TRY AND PUSH TH…
Read full complaint
I FIRST HAD NOTICED MY FRONT PASSENGER SPEAKER WOULD CUT IN AND OUT. IT DIDN'T MATTER IF THE CAR WAS STATIONARY OR IF I WAS DRIVING. THE FOLLOWING WEEK I WAS DRIVING THROUGH THE PARKING LOT OF MY JOB AND THE DOORS LOCKS STARTED LOCKING AND UNLOCKING RAPIDLY BY THEMSELVES. AND NOW THEY RARELY EVER DO EITHER WHEN I TRY AND PUSH THE LOCK BUTTONS. SO THEY EITHER HAVE TO STAY LOCKED OR UNLOCKED DEPENDING THE MOOD OF THE CAR. THE FOLLOWING WEEK I HAD A GAS LEAK AND HAD TO HAVE IT SERVICED BECAUSE THAT IS VERY DANGEROUS. THE MECHANIC TOLD ME THAT THERE WAS A RECALL ON THAT PLASTIC PIECE TO FUEL SYSTEM BUT ONLY IN SOUTHERN STATES AND I LIVE IN THE NORTH. AND NOT TO LONG AFTER THAT MY TURN SIGNAL SWITCH WOULDN'T STAY ON OR IT WOULDN'T SHUT OFF BY IT'S SELF. ALSO DANGEROUS TRYING TO HOLD SWITCH ON WHILE MAKING A TURN.
NHTSA ODI #11120583
85,000 miles · Aug 8, 2018
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
BATTERY KEEPS DYING AND KEY IS STUCK IN IGNITION. HAVE TO KEEP REPLACING BATTERY EVERY 8 MONTHS WHICH ARE BRAND NEW 5 YEAR BATTERY. FUEL LINE WAS REPLACED BUT STILL STRONG ODOR OF GAS AND ROTTING FUEL LINE AGAIN. SAFETY HAZARD! THIS HAS BEEN REPORTED BY A LARGE NUMBER OF PEOPLE. WHY IS THERE NOT A RECALL ON THIS?? VEHICLE WAS ST…
Read full complaint
BATTERY KEEPS DYING AND KEY IS STUCK IN IGNITION. HAVE TO KEEP REPLACING BATTERY EVERY 8 MONTHS WHICH ARE BRAND NEW 5 YEAR BATTERY. FUEL LINE WAS REPLACED BUT STILL STRONG ODOR OF GAS AND ROTTING FUEL LINE AGAIN. SAFETY HAZARD! THIS HAS BEEN REPORTED BY A LARGE NUMBER OF PEOPLE. WHY IS THERE NOT A RECALL ON THIS?? VEHICLE WAS STATIONARY AT THE TIME. THIS HAPPENS ALL THE TIME SO I CAN ONLY PUT ONE DATE IN HERE. SOMETHING IS ALSO WRONG WITH MY ELECTRICAL SYSTEM AND THE CHECK ENGINE LIGHT COMES ON ALL THE TIME AFTER DIAGNOSING WITH MY MECHANIC AND HAVING IT TURNED OFF. WHY ISN'T GM DOING ANYTHING TO HELP US?
NHTSA ODI #11118459
75,000 miles · Aug 7, 2018
Electrical System
IGNITION SWITCH
NHTSA ODI #11118331
120,000 miles · Jun 27, 2018
Electrical SystemEnginePower Train
INSTRUMENT CLUSTER MALFUNCTIONING, SPEEDOMETER AND WARNING INDICATORS FLASHING, GOING OUT, RESUMING NORMAL OPERATION, THEN REPEATING THE FAILURE SYMPTOMS REPEATEDLY. DURING FAILURE SYMPTOMS THE TRANSMISSION AND ENGINE BOG DOWN, STALL AND THE POWER STEERING ASSIST FAILS (WITH ENGINE STILL RUNNING) . RANDOM ELECTRICAL ISSUES SUCH …
Read full complaint
INSTRUMENT CLUSTER MALFUNCTIONING, SPEEDOMETER AND WARNING INDICATORS FLASHING, GOING OUT, RESUMING NORMAL OPERATION, THEN REPEATING THE FAILURE SYMPTOMS REPEATEDLY. DURING FAILURE SYMPTOMS THE TRANSMISSION AND ENGINE BOG DOWN, STALL AND THE POWER STEERING ASSIST FAILS (WITH ENGINE STILL RUNNING) . RANDOM ELECTRICAL ISSUES SUCH AS THE CHECK ENGINE LIGHT, CAR ALARM SENSOR, ETC FLASH ON AND OFF THEN START WORKING AGAIN TOTALLY NORMALLY. CAN NOT GET THE FAILURE TO OCCUR AT THE DEALERSHIP OR MECHANICS. FAILS SEVERAL TIMES A WEEK. FAILS WHEN DRIVING ON STREET, HIGHWAY AT LOW SPEEDS, MEDIUM SPEEDS OR HIGH SPEEDS.
NHTSA ODI #11104312
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration