NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,564 reports105,000 miles · Jun 10, 2017
Fuel/propulsion System
FUEL LINES RUSTED NEAR EXHAUST HEAT SHIELD ON DRIVER'S SIDE OF CAR. TWO VISIBLE GAS LEAKS FROM LINES AFTER FUEL PUMP IS ENGAGED, AND CAR IS PARKED. NO DOUBT THE LINES ALSO LEAK GAS WHILE DRIVING. MECHANIC SAYS MOISTURE BUILDS UP IN THE HEAT SHIELD AND RUSTS OUT FUEL LINES. HE SAYS THIS IS A COMMON ISSUE FOR COBALTS HHRS, AND SAT…
Read full complaint
FUEL LINES RUSTED NEAR EXHAUST HEAT SHIELD ON DRIVER'S SIDE OF CAR. TWO VISIBLE GAS LEAKS FROM LINES AFTER FUEL PUMP IS ENGAGED, AND CAR IS PARKED. NO DOUBT THE LINES ALSO LEAK GAS WHILE DRIVING. MECHANIC SAYS MOISTURE BUILDS UP IN THE HEAT SHIELD AND RUSTS OUT FUEL LINES. HE SAYS THIS IS A COMMON ISSUE FOR COBALTS HHRS, AND SATURN IONS, BUT AS FAR AS I'M AWARE, THERE IS NO APPLICABLE RECALL OR SPECIAL COVERAGE ISSUED BY GM FOR THIS FUEL LINE ISSUE.
NHTSA ODI #10994296
142,000 miles · Jun 9, 2017
Electronic Stability Control (esc)
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 70 MPH, THE CHECK ENGINE, TBS, BATTERY, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. IN ADDITION, THE STEERING WHEEL SHOOK VIOLENTLY. THE CONTACT HAD TO MANEUVER TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE SHUT DOWN ON ITS OWN AND THE CONTACT W…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 70 MPH, THE CHECK ENGINE, TBS, BATTERY, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. IN ADDITION, THE STEERING WHEEL SHOOK VIOLENTLY. THE CONTACT HAD TO MANEUVER TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE SHUT DOWN ON ITS OWN AND THE CONTACT WAS NOT ABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT DIAGNOSED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.
NHTSA ODI #10994096
98,704 miles · Jun 7, 2017
Steering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 5 MPH, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE POWER STEERING INDICATOR FLASHED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMAT…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 5 MPH, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE POWER STEERING INDICATOR FLASHED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,704.
NHTSA ODI #10993787
Mileage unknown · May 30, 2017
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING ANY SPEED, THE STEERING LOST POWER AND THE POWER STEERING WARNING INDICATOR REMAINED ILLUMINATED. ALSO, THE CHECK ENGINE WARNING INDICATOR REMAINED ILLUMINATED. THE DEALER WAS NOT CONTACTED ABOUT THE LOSS OF POWER STEERING BECAUSE THE CONTACT WAS UNAWARE OF A RECALL. TH…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING ANY SPEED, THE STEERING LOST POWER AND THE POWER STEERING WARNING INDICATOR REMAINED ILLUMINATED. ALSO, THE CHECK ENGINE WARNING INDICATOR REMAINED ILLUMINATED. THE DEALER WAS NOT CONTACTED ABOUT THE LOSS OF POWER STEERING BECAUSE THE CONTACT WAS UNAWARE OF A RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS REFERRED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10992177
132,670 miles · May 22, 2017
Fuel/propulsion System
FUEL LINE LEAKING IN FRONT OF DRIVER'S SIDE REAR TIRE.
NHTSA ODI #10990968
126,000 miles · May 17, 2017
Steering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING VARIOUS SPEEDS, THE INSTRUMENT PANEL WARNING INDICATORS FLASHED AND THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.
NHTSA ODI #10986230
75,000 miles · May 17, 2017
Electrical System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE VEHICLE SHUT OFF AND THE AIR BAG WARNING, AIR BAG SERVICE, AND POWER STEERING SERVICE INDICATORS FLASHED. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE LOWER PASSENGER SIDE CONNECTION TO THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 35 MPH, THE VEHICLE SHUT OFF AND THE AIR BAG WARNING, AIR BAG SERVICE, AND POWER STEERING SERVICE INDICATORS FLASHED. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE LOWER PASSENGER SIDE CONNECTION TO THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE MANUFACTURER PARTS, DORMAN AND DELPHI, BEING FAULTY. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 14E021000 (ELECTRICAL SYSTEM). THE MANUFACTURER AND THE DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. *AS
NHTSA ODI #10986184
115,500 miles · May 8, 2017
Steering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE POWER STEERING SERVICE INDICATOR ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT PULLED THE VEHICLE OFF THE ROAD AND CALLED AN INDEPENDENT MECHANIC. THE CONTACT WAS INSTRUCTED TO THE VEHICLE OFF AND ON, WHICH CORRECTED THE FAILURE. T…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE POWER STEERING SERVICE INDICATOR ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT PULLED THE VEHICLE OFF THE ROAD AND CALLED AN INDEPENDENT MECHANIC. THE CONTACT WAS INSTRUCTED TO THE VEHICLE OFF AND ON, WHICH CORRECTED THE FAILURE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,500.
NHTSA ODI #10984373
91,800 miles · May 7, 2017
Fuel/propulsion System
I NOTICED A STRONG ODOR OF EXHAUST INSIDE AND OUTSIDE MY CAR WHEN CITY AND HIGHWAY DRIVING AS WELL AS AFTER TURNING CAR OFF AND PARKING. I ALSO EXPERIENCED SLUGGISH STARTS. UPON TAKING MY CAR IN FOR REPAIR IT WAS FOUND TO BE LEAKING FUEL AND THE FUEL LINE WAS REPLACED.. ..UPDATED 05/23/17 *BF UPDATED 09/15/2017 *JS
NHTSA ODI #10983927
142,000 miles · May 6, 2017
Air BagsElectrical SystemFuel/propulsion System
I ALREADY KNOW ABOUT THE AIRBAG AND IGNITION RECALLS BUT, NOW, I HAVE A FUEL LEAK WITH FUEL DRIPPING DOWN THE LINES FROM THE TANK ON TO THE GROUND AT A POSITION ON THE DRIVERS SIDE UNDER THE REAR PASSENGER DOOR AND SEAT.
NHTSA ODI #10983801
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration