NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,564 reports32,000 miles · Feb 24, 2010
SteeringSuspension
STEERING SHAKES ALOT ON ROUGH ROADS AND SOMETIMES WHEN APPLYING THE BREAK. WE BROUGHT THE CAR IN TO THE DEALER A DOZEN TIMES. THEY SAID THEY DO NOT KNOW WHAT THE PROBLEM IS. WE BROUGHT IT TO DIFFERENT DEALERS AND THEY SAID IT MIGHT BE THE I-SHAFT WE HAVE NOT FIXED THIS YET BECAUSE WE ARE STILL LOOKING FOR A FOR SURE ANSWER WHAT …
Read full complaint
STEERING SHAKES ALOT ON ROUGH ROADS AND SOMETIMES WHEN APPLYING THE BREAK. WE BROUGHT THE CAR IN TO THE DEALER A DOZEN TIMES. THEY SAID THEY DO NOT KNOW WHAT THE PROBLEM IS. WE BROUGHT IT TO DIFFERENT DEALERS AND THEY SAID IT MIGHT BE THE I-SHAFT WE HAVE NOT FIXED THIS YET BECAUSE WE ARE STILL LOOKING FOR A FOR SURE ANSWER WHAT IT IS. MY FUTURE MOTHER IN LAW HAS A SIMILAR CAR BUT DIFFERENT YEAR AND HAS THE SAME PROBLEM. THE STARTED OF THE SHAKING BOTH CARS HAD 32000 MILES ON THEM. SINCE THE START BOTH CARS HAS REPLACED STRUTS, CONTROL ARM AND TIE RODS. AND WE ARE LOOKING TO REPLACE THEM AGAIN. WHAT IS CAUSING THIS SHAKING? *TR
NHTSA ODI #10313619
52,000 miles · Feb 24, 2010
Steering
2007 CHEVY COBALT. POWER STEERING INTERMITTENTLY GOES OUT WHILE CAR IN USE. HAPPENED 1ST TIME, THEN 2 WEEKS LATER HAPPENED AGAIN. NOW(3 WEEKS AFTER 1ST INCIDENT) HAPPENS DAILY, SEVERAL TIMES A DAY. TURNING THE IGNITION OFF AND RESTARTING FIXES THE PROBLEM. TAKING THE CAR INTO CHEVY DEALERSHIP FOR REPAIR ON FRIDAY. NOW NOT …
Read full complaint
2007 CHEVY COBALT. POWER STEERING INTERMITTENTLY GOES OUT WHILE CAR IN USE. HAPPENED 1ST TIME, THEN 2 WEEKS LATER HAPPENED AGAIN. NOW(3 WEEKS AFTER 1ST INCIDENT) HAPPENS DAILY, SEVERAL TIMES A DAY. TURNING THE IGNITION OFF AND RESTARTING FIXES THE PROBLEM. TAKING THE CAR INTO CHEVY DEALERSHIP FOR REPAIR ON FRIDAY. NOW NOT DRIVING THE CAR IN CASE MORE SERIOUS ISSUES COULD HAPPEN. *TR
NHTSA ODI #10313542
40,000 miles · Feb 23, 2010
Electrical SystemSteering
MY DAUGHTER'S CHEVROLET COBALT 2007 CAR'S POWER STEERING TURNS-OFF WHILE DRIVING AND MAKES IT A HAZARD DURING DRIVING, ESPECIALLY FOR WEAKER INDIVIDUALS. THE STIFFNESS IN STEERING MAKES IT SEEM THAT IT IS LOCKED. RESEARCH ONLINE SHOWS THAT EVEN EARLIER MODELS HAVE THIS PROBLEM. CHEVROLET ENGINEERED MAKING POWER STEERING POWER…
Read full complaint
MY DAUGHTER'S CHEVROLET COBALT 2007 CAR'S POWER STEERING TURNS-OFF WHILE DRIVING AND MAKES IT A HAZARD DURING DRIVING, ESPECIALLY FOR WEAKER INDIVIDUALS. THE STIFFNESS IN STEERING MAKES IT SEEM THAT IT IS LOCKED. RESEARCH ONLINE SHOWS THAT EVEN EARLIER MODELS HAVE THIS PROBLEM. CHEVROLET ENGINEERED MAKING POWER STEERING POWERED ELECTRONICALLY VICE HYDRAULICS AND FLUIDS AS WITH MOST VEHICLES. AND NOW, WE FIND THAT THERE IS NO RECALL FROM CHEVROLET AND TO REPAIR IT WILL COST ABOUT $2K. ABOUT 1/8 THE COST OF THE VEHICLE. IF WERE DOING THE SAME TO A COMPANY LIKE TOYOTA, THEN WE SHOULD ALSO LOOK AT THE CHEVROLET COBALT. *TR
NHTSA ODI #10313449
5,600 miles · Feb 23, 2010
Engine And Engine CoolingFuel System, GasolineCrashFire
MY STEPBROTHER HAD TWO CHEVY COBALTS. THE FIRST ONE HE WRECKED ON A COUNTRY ROAD WHERE HE SKIDDED ON GRAVEL, HIS CAR BURST INTO FLAMES. FORTUNATELY, HE WAS ABLE TO GET OUT OF THE CAR. HE REPLACED IT WITH ANOTHER COBALT. IN JANUARY 2009 HE HAD ANOTHER WRECK, SINGLE CAR. HIS CAR HIT A POLE AND IMMEDIATELY BROKE OUT IN FLAMES. …
Read full complaint
MY STEPBROTHER HAD TWO CHEVY COBALTS. THE FIRST ONE HE WRECKED ON A COUNTRY ROAD WHERE HE SKIDDED ON GRAVEL, HIS CAR BURST INTO FLAMES. FORTUNATELY, HE WAS ABLE TO GET OUT OF THE CAR. HE REPLACED IT WITH ANOTHER COBALT. IN JANUARY 2009 HE HAD ANOTHER WRECK, SINGLE CAR. HIS CAR HIT A POLE AND IMMEDIATELY BROKE OUT IN FLAMES. UNFORTUNATELY FOR MY FAMILY HE WAS NOT ABLE TO GET OUT, HE COULDN'T GET HIS SEAT BELT UNDONE AND THE FLAMES WERE MELTING THE INTERIOR CAUSING CAUSTIC FLAMES. THE POLICEMAN BROKE OUT THE BACK WINDOW TO GET HIM OUT AND THE POLICEMAN WAS HOSPITALIZED FROM SMOKE INHALATION MY BROTHER DIDN'T MAKE IT, HE DIED. I BELIEVE THIS SHOULD BE CHECKED OUT. I WROTE TO CHEVROLET WITH NO RESPONSE. *TR
NHTSA ODI #10313385
44,620 miles · Feb 23, 2010
Steering
I OWN A 2007 CHEVROLET COBALT WITH ROUGHLY 45,000 MILES. JUST RECENTLY, THE POWER STEERING HAS BEGUN TO FAIL. I WILL BE DRIVING DOWN THE HIGHWAY AND, ALL OF A SUDDEN, THE STEERING WHEEL GETS VERY HARD TO STEER AND THE "POWER STEERING FAILURE" NOTIFICATION BEEPS. THIS HAS HAPPENED 3 TIMES WITHIN THE LAST 3 WEEKS. THE FIRST TIME …
Read full complaint
I OWN A 2007 CHEVROLET COBALT WITH ROUGHLY 45,000 MILES. JUST RECENTLY, THE POWER STEERING HAS BEGUN TO FAIL. I WILL BE DRIVING DOWN THE HIGHWAY AND, ALL OF A SUDDEN, THE STEERING WHEEL GETS VERY HARD TO STEER AND THE "POWER STEERING FAILURE" NOTIFICATION BEEPS. THIS HAS HAPPENED 3 TIMES WITHIN THE LAST 3 WEEKS. THE FIRST TIME I WAS MAKING A RIGHT-HAND TURN AND FELT THE WHEEL "POP". THE OTHER 2 TIMES I WAS JUST DRIVING DOWN THE HIGHWAY WITHOUT THE WHEEL TURNED AT ALL. I HAVE CALLED MY LOCAL CHEVROLET DEALER AND THEY CLAIM TO HAVE NEVER HEARD OF THIS PROBLEM BEFORE. I HAVE LOOKED ONLINE AND HAVE FOUND MANY PEOPLE WHO ARE COMPLAINING ABOUT THE SAME PROBLEM BUT SAY THAT THEIR CHEVROLET DEALERS DO NOT KNOW WHAT IS WRONG. THE 2007 COBALT HAS AN ELECTRONIC POWER STEERING SYSTEM WITHOUT THE STANDARD HYDRAULIC SYSTEM AND NO POWER STEERING FLUID. THIS IS AN EXTREMELY DANGEROUS PROBLEM. I AM DRIVING DOWN THE HIGHWAY AT 60+ MILES PER HOUR AND ALL OF A SUDDEN CANNOT STEER MY CAR. I HAVE TO PULL OVER TO THE SIDE OF THE ROAD AND SHUT THE CAR OFF. THIS SEEMS TO RESET THE COMPUTER THAT RUNS THE POWER STEERING AND IT WILL RESUME WORKING ONCE I RESTART THE CAR. *TR
NHTSA ODI #10313315
38,000 miles · Feb 23, 2010
SteeringCrash
2007 CHEVROLET COBALT - POWER STEERING FAILURE. HAPPENS MORE OFTEN WHEN WEATHER/CAR IS WARM, PARTICULARLY WHEN WEATHER IS OVER 75 OR 80. MOST OFTEN WHEN CAR IS WARM, LIKE DURING LONG TRIPS OR WHEN DRIVING MANY PLACES IN ONE DAY (ERRANDS). I HAVE HAD AS MANY AS 5 OCCURRENCES ON DAYS I AM RUNNING MANY ERRANDS. THE DASHBOARD W…
Read full complaint
2007 CHEVROLET COBALT - POWER STEERING FAILURE. HAPPENS MORE OFTEN WHEN WEATHER/CAR IS WARM, PARTICULARLY WHEN WEATHER IS OVER 75 OR 80. MOST OFTEN WHEN CAR IS WARM, LIKE DURING LONG TRIPS OR WHEN DRIVING MANY PLACES IN ONE DAY (ERRANDS). I HAVE HAD AS MANY AS 5 OCCURRENCES ON DAYS I AM RUNNING MANY ERRANDS. THE DASHBOARD WARNING DINGS AND POWER STEERING LIGHT COMES ON, THE POWER STEERING FAILS AND YOU CANNOT CONTROL THE VEHICLE. NORMALLY, YOU CAN STOP THE CAR, TURN OFF THE IGNITION AND RESTART THE CAR AND IT WILL WORK AGAIN FOR A WHILE. ONCE CRASHED INTO MY OWN CARPORT POLE, ONCE RAN OVER A CURB. NO ONE WAS HURT, AND THERE WAS NO SERIOUS PROPERTY DAMAGE, ONLY A BENT SUPPORT POLE ON MY OWN CARPORT, BUT I WAS LUCKY I WAS GOING EXTREMELY SLOW WHEN THIS HAPPENED. IT THIS HAPPENS AT A HIGHER SPEED, OR IN ONCOMING TRAFFIC, IT COULD CAUSE SERIOUS INJURY OR EVEN DEATH. I TOOK THE CAR TO A MECHANIC AND WAS TOLD THE ENTIRE STEERING COLUMN/SYSTEM WOULD HAVE TO BE REPLACED AT A COST OF OVER $2000. I AM UNABLE TO FIX THIS DUE TO THE HIGH COST. THIS CAR IS A 2007 WITH ONLY 38,000 MILES. SHOULD NOT HAVE MAJOR PROBLEMS LIKE THIS. *TR
NHTSA ODI #10312982
37,900 miles · Feb 23, 2010
Steering
2007 CHEVROLET COBALT ELECTRIC POWER STEERING FAILURES. MY POWER STEERING GOES OUT WHILE I AM DRIVING. IT COMES BACK ON AFTER I RESTART THE CAR. I WENT TO THE DEALER AND THEY SAID THERE WAS NOTHING THEY COULD DO UNLESS THEY WERE DRIVING THE CAR WHEN THE POWER STEERING FAILS. THIS HAS BEEN GOING ON FOR 4 MONTHS. I FEEL UNSAFE.…
Read full complaint
2007 CHEVROLET COBALT ELECTRIC POWER STEERING FAILURES. MY POWER STEERING GOES OUT WHILE I AM DRIVING. IT COMES BACK ON AFTER I RESTART THE CAR. I WENT TO THE DEALER AND THEY SAID THERE WAS NOTHING THEY COULD DO UNLESS THEY WERE DRIVING THE CAR WHEN THE POWER STEERING FAILS. THIS HAS BEEN GOING ON FOR 4 MONTHS. I FEEL UNSAFE. I WILL NOT ALLOW MY DAUGHTER TO DRIVE THE CAR. I BOUGHT THE CAR FOR HER. GOODWRENCH HAS BEEN UNRESPONSIVE. I NEED HELP TO FIX THIS PROBLEM. IT SHOULD NOT HAPPEN. I FEEL LIKE THEY ARE SWEEPING IT UNDER THE RUG. *TR
NHTSA ODI #10312941
27,000 miles · Feb 22, 2010
Steering
2007 COBALT, THE POWER STEERING JUST GOES OUT AT ANY SPEED. IT MAKE THE CAR ALMOST IMPOSSIBLE TO CONTROL. *TR
NHTSA ODI #10312872
8,000 miles · Feb 22, 2010
Steering
I PURCHASED A 2007 CHEVY COBALT NEW. AT ABOUT 8,000 MILES, I NOTICED AT LOW SPEEDS, WHEN I TURNED TO THE RIGHT, THE STEERING COLUMN WOULD MAKE A NOISE AND JERKY MOTION. I TOOK THE VEHICLE TO THE DEALERSHIP. THEY REPLACED THE INTERMEDIATE SHAFT, BUT THE PROBLEM RETURNED AFTER ONLY 300 MORE MILES. *TR
NHTSA ODI #10312829
Mileage unknown · Feb 22, 2010
Steering
STEERING FAILURE. *TR
NHTSA ODI #10312664
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration