TAKATA RECALL: MY AIR BAG SIGN PROBABLY IN THE BEGINNING OF JANUARY HAD APPEARED, AND OBVIOUSLY THEY HAVE NOT BEEN WORKING. I HAD GOTTEN INTO AN ACCIDENT ON JANUARY 31ST AND THEY DID NOT DEPLOY. I AM NOT POSITIVE IF THIS IS A PART OF THE RECALL SITUATION, BUT IT HAPPENED OUT OF NO WHERE, I JUST TURNED MY CAR ON ONE DAY AND IT ST…
Read full complaint
TAKATA RECALL: MY AIR BAG SIGN PROBABLY IN THE BEGINNING OF JANUARY HAD APPEARED, AND OBVIOUSLY THEY HAVE NOT BEEN WORKING. I HAD GOTTEN INTO AN ACCIDENT ON JANUARY 31ST AND THEY DID NOT DEPLOY. I AM NOT POSITIVE IF THIS IS A PART OF THE RECALL SITUATION, BUT IT HAPPENED OUT OF NO WHERE, I JUST TURNED MY CAR ON ONE DAY AND IT STOPPED WORKING. ALSO IN THE ACCIDENT MY CAR WAS SITTING AT A RED LIGHT AND HIT BETWEEN THE RANGE OF 35-40 MPH
NHTSA ODI #10968177
111,256 miles · Jan 25, 2013
Wheels
THE RIMS ON THESE 2007 COBALTS BEND EASY WITH THE SIZE OF TIRE THEY ARE SOLD WITH. ANY POT HOLE HIT AT SPEEDS OF 30 - 55 MPH WILL BEND THESE TIRE RIMS. I HAVE REPLACED 2 RIMS AT $ 111.00 A PIECE AND MY BACK RIMS ARE BENT ALSO. WAL-MART, TIEMANS TIRE AND OTHER TIRE STORES ARE AWARE OF THE BAD RIMS ON THESE COBALTS. YOU CAN NOT FI…
Read full complaint
THE RIMS ON THESE 2007 COBALTS BEND EASY WITH THE SIZE OF TIRE THEY ARE SOLD WITH. ANY POT HOLE HIT AT SPEEDS OF 30 - 55 MPH WILL BEND THESE TIRE RIMS. I HAVE REPLACED 2 RIMS AT $ 111.00 A PIECE AND MY BACK RIMS ARE BENT ALSO. WAL-MART, TIEMANS TIRE AND OTHER TIRE STORES ARE AWARE OF THE BAD RIMS ON THESE COBALTS. YOU CAN NOT FIND ANY USED RIMS ANYMORE DUE TO ALL ARE USED TO REPLACE OTHER BENT RIMS ON COBALTS. THIS CAN CAUSE YOU TO LOOSE CONTROL OF YOUR CAR IF A POT HOLE BENDS A RIM AN YOU LOOSE ALL AIR PRESSURE IN THE TIRE. IT WILL ACT AS THOUGH THE TIRE BLEW OUT WITH SUDDEN AIR PRESSURE LOSS. IT IS NOT A SAFE CAR TO DRIVE WITH THIS PROBLEM. *TR
NHTSA ODI #10494742
40,862 miles · Dec 2, 2010
SteeringSuspensionWheels
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT DROVE OVER A POTHOLE AND THE REAR PASSENGER SIDE WHEEL BENT ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE MECHANIC REPLACED THE WHEEL. LATER, THE FAILURE OCCURRED AGAIN WHEN THE CONTACT DROVE OVER ANOTHER POTHOLE. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT DROVE OVER A POTHOLE AND THE REAR PASSENGER SIDE WHEEL BENT ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE MECHANIC REPLACED THE WHEEL. LATER, THE FAILURE OCCURRED AGAIN WHEN THE CONTACT DROVE OVER ANOTHER POTHOLE. THE VEHICLE WAS AGAIN, TAKEN TO A LOCAL MECHANIC AND THE BENT WHEEL WAS REPLACED. THE CONTACT STATED THAT ON A LATER DATE, THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE FRONT VERTICAL BUSHING ON BOTH FRONT LOWER CONTROL ARMS WERE REPLACED AS WELL AS BOTH END LINKS FOR THE FRONT SWAY BAR. IN ADDITION, THE CONTACT STATED THAT THE STEERING SHAFT AND COLUMN ASSEMBLY WOULD ALSO NEED REPLACING. HE CALLED THE MANUFACTURER AND THEY ADVISED HIM THAT THEY COULD NOT ASSIST WITH THE COST OF THE REPAIRS. THE VEHICLE WAS NOT REPAIRED FOR THE STEERING FAILURES. THE FAILURE MILEAGE WAS 40,862 AND THE CURRENT MILEAGE WAS 58,000.
NHTSA ODI #10368636
Mileage unknown · Nov 3, 2010
Wheels
I DRIVE A 2007 CHEVY COBALT WITH DEFECTIVE STEEL WHEELS. HAVE HAD GM DEALER SEND PHOTOS TO GM REP IN THE AREA, DENIES MY CLAIM ON MY DEFECTIVE STEEL FACTORY 15INCH WHEELS. THERE ARE CRACKS THAT START IN THE CENTER OF THE WHEEL THEN THEY TRAVEL RIGHT TO THE CIRCLES IN THE WHEEL. *TR
NHTSA ODI #10363928
369 miles · Nov 1, 2010
Air BagsEngine And Engine CoolingSteering
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT NOTICED MANY PROBLEMS WITH THE VEHICLE SINCE THE DATE OF PURCHASE IN OCTOBER 2006. THE CONTACT STATED THAT THE ALIGNMENT WAS INCORRECT SO THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR ALIGNMENT IMMEDIATELY. ALSO, THE CHECK ENGINE LIGHT, AND THE AIR BAG LIGHT WOULD ILLUMINAT…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT NOTICED MANY PROBLEMS WITH THE VEHICLE SINCE THE DATE OF PURCHASE IN OCTOBER 2006. THE CONTACT STATED THAT THE ALIGNMENT WAS INCORRECT SO THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR ALIGNMENT IMMEDIATELY. ALSO, THE CHECK ENGINE LIGHT, AND THE AIR BAG LIGHT WOULD ILLUMINATE INTERMITTENTLY SO SENSORS WERE REPLACED BY THE DEALER. THE STEERING COLUMN AND POWER STEERING MOTOR, HEADLINER. CATALYTIC CONVERTER, WHEEL BEARINGS, STRUTS, AND THE HEATING/COOLING SYSTEM WERE ALL REPLACED. THE VEHICLE ALSO STALLED COMPLETELY ON AN INTERMITTENT BASIS. THE CONTACT STATED THAT THE PROBLEMS WERE CONSISTENT. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 104,000. THE FAILURE MILEAGE WAS 369.
NHTSA ODI #10363536
Mileage unknown · Oct 5, 2010
Wheels
GM'S STEEL WHEEL RIMS (PART NUMBER: STL08021U45 / BASE PART# : STL08021U ) ARE DANGEROUSLY WEAK METAL/ - THEY BEND VERY EASILY. I HAVE 3 BENT RIMS ON MY 2007 CHEVY COBALT. (THESE SAME MODEL WAS ALSO STANDARD ON 2007-2008 SATURN AURA, AND 2006 -07 CHEVROLET MALIBU ) I HAVE 3 BENT RIMS ACCORDING TO A GM DEALERSHIP AND AN…
Read full complaint
GM'S STEEL WHEEL RIMS (PART NUMBER: STL08021U45 / BASE PART# : STL08021U ) ARE DANGEROUSLY WEAK METAL/ - THEY BEND VERY EASILY. I HAVE 3 BENT RIMS ON MY 2007 CHEVY COBALT. (THESE SAME MODEL WAS ALSO STANDARD ON 2007-2008 SATURN AURA, AND 2006 -07 CHEVROLET MALIBU ) I HAVE 3 BENT RIMS ACCORDING TO A GM DEALERSHIP AND ANOTHER REPAIR SHOP - AND WAS TOLD THAT NEED TO BE REPLACED. I TRIED TO BUY REPLACEMENTS BUT WAS TOLD THEY ARE ON "HOLD" BY GM. NO REPLACEMENT. THESE RIMS ARE RUINING MY CAR BY STRAINING THE WHEEL BEARINGS, THE ALIGNMENT, AND TIRES, NOT TO MENTION JEOPARDIZING MY SAFETY AND THOSE DRIVING AROUND ME. THERE SHOULD BE A RECALL ON THESE CHEAP DANGEROUS RIMS! *TR
NHTSA ODI #10359303
61,203 miles · Mar 2, 2010
Wheels
2007 CHEVY COBALT, 61,000 MILES, BOTH FRONT WHEEL BEARINGS NEEDED REPLACEMENT. SEVERE GRINDING SOUND AND PULLING TO THE LEFT. I HAD TO PAY TO REPLACE BOTH WHEEL BEARING ASSEMBLIES FOR $850.00. *TR
NHTSA ODI #10315483
30 miles · Sep 29, 2009
SteeringWheels
BOUGHT THE CAR IN MAY 2008, SINCE THEN WITHIN ONE YEAR WE REPLACED TIRES ON FRONT 3 AND NEEDING A 4TH TIME NOW. BRAKES AND ROTORS ALSO HAVE BEEN CHANGED 3 TIMES EACH AND STILL HAVING TROUBLE AT 55 MILES AN HOUR SHAKES AND SOME LOSE OF CONTROL. PROBLEM NEEDS TO BE ADDRESSED BUT DEALER AND CHEVY SAYS NOTHING!! VEHICLES TIRES ARE L…
Read full complaint
BOUGHT THE CAR IN MAY 2008, SINCE THEN WITHIN ONE YEAR WE REPLACED TIRES ON FRONT 3 AND NEEDING A 4TH TIME NOW. BRAKES AND ROTORS ALSO HAVE BEEN CHANGED 3 TIMES EACH AND STILL HAVING TROUBLE AT 55 MILES AN HOUR SHAKES AND SOME LOSE OF CONTROL. PROBLEM NEEDS TO BE ADDRESSED BUT DEALER AND CHEVY SAYS NOTHING!! VEHICLES TIRES ARE LOSING TREAD ON THE FRONT OUTSIDE OF THE TIRES. *TR
NHTSA ODI #10285721
41,000 miles · Apr 15, 2009
Electrical SystemPower TrainWheels
I BOUGHT MY 2007 COBALT IN JULY 2008, USED ONLY AS A RENTAL CAR WITH ENTERPRISE, WITH 34K MILES. WITHIN 2 MONTHS, MY ROTORS WERE WARPED AND HAD TO BE REPLACED. MILWAUKEE HAS A TERRIBLE PROBLEM W/ POTHOLES SO I'VE HAD TO PUT 4 NEW RIMS AND TIRES ON IT TOO AND AN ALIGNMENT. IT STILL SHAKES WHEN I GO BETWEEN 45-60MPH. ALSO, THE…
Read full complaint
I BOUGHT MY 2007 COBALT IN JULY 2008, USED ONLY AS A RENTAL CAR WITH ENTERPRISE, WITH 34K MILES. WITHIN 2 MONTHS, MY ROTORS WERE WARPED AND HAD TO BE REPLACED. MILWAUKEE HAS A TERRIBLE PROBLEM W/ POTHOLES SO I'VE HAD TO PUT 4 NEW RIMS AND TIRES ON IT TOO AND AN ALIGNMENT. IT STILL SHAKES WHEN I GO BETWEEN 45-60MPH. ALSO, THE GEAR SHIFT KEEPS GETTING LOCKED IN PARK, LIKE A SENSOR IS BROKEN OR SOMETHING. I HAVE TO CONTINUOUSLY PRESS ON THE BRAKE UNTIL IT GIVES. AND THERE MUST BE A SHORT SOMEWHERE BECAUSE OCCASIONALLY THE BLINKERS NOISE (TICK TICK) AND THE LEFT SPEAKER GO OUT, COME BACK ON, GO OUT, ETC. I'VE HAD THE CAR 8 MONTHS AND HAVE THIS MANY PROBLEMS WITH IT? OF COURSE THE DEALERSHIP IS CHARGING AN ARM AND LEG FOR REPAIRS THAT I CAN'T AFFORD BUT I THINK THEY SHOULD BE RESPONSIBLE FOR THIS BECAUSE THERE IS NO WAY THESE PROBLEMS CAN BE "OPERATOR ERROR." THIS IS A MANUFACTURING PROBLEM! I CAN UNDERSTAND THE TIRES & RIMS BECAUSE I'VE HIT TOO MANY POTHOLES BUT EVERYTHING ELSE? COME ON. ANYONE ELSE COMPLAINED ABOUT SIMILAR ISSUES? *TR
NHTSA ODI #10265428
2,700 miles · Sep 13, 2007
Electrical SystemWheels
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY COULD NOT BE REMOVED FROM THE IGNITION WHILE IT WAS PARKED. THE DEALER REPLACED THE SHIFTER ASSEMBLY. THE FRONT PASSENGER RIM WAS DENTED AND ALSO REPLACED. THE FAILURE MILEAGE WAS 2,700 AND CURRENT MILEAGE WAS 8,000.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
2007 Chevrolet Cobalt Problems, Complaints & Recalls | Skip That Year
Illustration