NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
75 reportsClear category filter17,940 miles · Aug 27, 2014
Electrical SystemFuel System, GasolinePower Train
CAR HAS A HARD YANK AFTER COMING TO A STOP AND STARTING OFF. KNOCKING NOISE COMING FROM REAR OF CAR SINCE DAY ONE OF PURCHASE. VIBRATION IN ACCELERATOR AND GEAR SHIFTER. LIGHTS ON INTERIOR OF CAR DASHBOARD GOES ON AND OFF. PROBLEM STILL HAPPENING TODAY AND THE TSM WAS REPLACED AS WELL, AS THEY ALWAYS SAY THEY CANNOT DUPLICATE T…
Read full complaint
CAR HAS A HARD YANK AFTER COMING TO A STOP AND STARTING OFF. KNOCKING NOISE COMING FROM REAR OF CAR SINCE DAY ONE OF PURCHASE. VIBRATION IN ACCELERATOR AND GEAR SHIFTER. LIGHTS ON INTERIOR OF CAR DASHBOARD GOES ON AND OFF. PROBLEM STILL HAPPENING TODAY AND THE TSM WAS REPLACED AS WELL, AS THEY ALWAYS SAY THEY CANNOT DUPLICATE THE PROBLEM. CHECK ENGINE LIGHT HAS NEVER CAME ON AT ANYTIME THE PROBLEM HAPPENED. IT HAPPENS AFTER CAR IS DRIVEN AND HEATED UP. ONLY HAPPENED WHEN LONG TRIP OVER 50 MILES, NOW SINCE IGNITION HAS BEEN CHANGED ON CALL BACK. PROBLEMS HAS WORSENED LIGHTS ON AND OFF, TRANSMISSION HARD SHIFT WHEN DRIVING SHORT TRIPS AS WELL AS A CONSTANT VIBRATION. KNOCKING COMING FROM GAS TANK SIDE OF CAR WAS MAINLY DURING COOLER WEATHER NOW HAPPENED WHEN DAY WAS ABOVE 90 DEGREES. ELECTRICAL PROBLEM WITH VEHICLE I THINK AND HAS CAUSED MANY PROBLEMS AND EVEN DEATHS. DO NOT THINK IT WAS KEYS IGNITION. I SERIOUSLY THINK IS IN THE ENTIRE ELECTRICAL SYSTEM. PROBLEM SHOULD OF BEEN FIXED WHEN 1ST REPORTED, BUT THEY ONLY RESET THE TRANS COMPUTER. *TR
NHTSA ODI #10628658
Mileage unknown · Apr 6, 2014
SteeringSuspension
MY VEHICLE WAS MAKING A LOUD NOISE I TOOK IT TO THE MECHANIC HE SAID IT WAS THE TIRE ROD END AND BEARING AND IT WAS THE 3RD COBALT WITH THE EXACT SAME ISSUE IN A WEEK THAT HED FIXED HE ALSO SAID HE COULDN'T SEE ANY REASON FOR IT IN EITHER CAR THAT THOSE THINGS USUALLY DON'T JUST WEAR OUT. I ASKED HIM WHAT MIGHT HAPPEN IF I CONTI…
Read full complaint
MY VEHICLE WAS MAKING A LOUD NOISE I TOOK IT TO THE MECHANIC HE SAID IT WAS THE TIRE ROD END AND BEARING AND IT WAS THE 3RD COBALT WITH THE EXACT SAME ISSUE IN A WEEK THAT HED FIXED HE ALSO SAID HE COULDN'T SEE ANY REASON FOR IT IN EITHER CAR THAT THOSE THINGS USUALLY DON'T JUST WEAR OUT. I ASKED HIM WHAT MIGHT HAPPEN IF I CONTINUED TO DRIVE IT AS IS AND HE SAID THE TIRE COULD COME OFF WHILE DRIVING DOWN THE HIGHWAY.COULD YOU PLEASE CHECK INTO THIS? THANK YOU. *TR
NHTSA ODI #10577753
10,000 miles · Mar 6, 2014
SteeringSuspension
NOISY BROKEN STABILIZER LINKS, CONTROL ARM BUSHING BROKEN. QUICK INTERNET SEARCH SHOWS THIS TO BE A WISE SPREAD PROBLEM. *TR
NHTSA ODI #10567562
58,250 miles · Mar 1, 2014
Electrical SystemSteeringSuspensionCrash
THE ENGINE TURNED OFF ALL BY ITSELF WHILE I WAS DRIVING AROUND A CORNER, CAUSING THE CAR TO GO OFF THE ROAD. I WAS GOING ABOUT 35 MPH, AND APPLIED THE BRAKES AS FAST AS I COULD, BUT THE CAR WENT UP AND OVER THE CURB, ACROSS THE SIDEWALK, AND BOTH FRONT TIRES WENT DOWN OFF THE STEEP EDGE OF THE SIDEWALK'S FAR SIDE INTO THE MUD. …
Read full complaint
THE ENGINE TURNED OFF ALL BY ITSELF WHILE I WAS DRIVING AROUND A CORNER, CAUSING THE CAR TO GO OFF THE ROAD. I WAS GOING ABOUT 35 MPH, AND APPLIED THE BRAKES AS FAST AS I COULD, BUT THE CAR WENT UP AND OVER THE CURB, ACROSS THE SIDEWALK, AND BOTH FRONT TIRES WENT DOWN OFF THE STEEP EDGE OF THE SIDEWALK'S FAR SIDE INTO THE MUD. THE PART OF THE CAR BODY IMMEDIATELY BEHIND THE FRONT TIRES WAS ALMOST TOUCHING (WAY LESS THAN 1 INCH ABOVE) THE EDGE OF THE TOP / EDGE OF THE SIDEWALK. I COULDN'T REVERSE BACK UP AND OVER THE SIDEWALK EDGE. A TOW TRUCK WAS CALLED, AND PULLED THE CAR STRAIGHT BACK AND UP/OVER THE EDGE OF THE SIDEWALK AND ONTO THE ROAD. SOME SORT OF DUST COVER THING FROM UP INSIDE THE PASSENGER-SIDE WHEEL WELL HAD BEEN TORN LOOSE DURING THE CRASH OFF THE SIDEWALK EDGE AND WAS STILL LAYING IN THE MUD. AFTER I RESTARTED THE CAR AND DROVE HOME, THE STEERING / SUSPENSION (I CANNOT TELL WHICH) MADE A CREAKING AND GRINDING SORT OF NOISE WHEN TURNING, AND I COULD TELL FROM THE EXTENSIVE BOUNCING AT EVEN LITTLE BUMPS IN THE ROAD THAT BOTH FRONT STRUTS HAD BEEN DAMAGED. *TR
NHTSA ODI #10566616
42,220 miles · Nov 11, 2013
Suspension
I AM WRITING BECAUSE I DID GET THE RECALL ON MY VEHICLE OF THE POWER STEERING , THE MOTOR KIT WAS FIXED ON 8/12/10.I TOOK MY CAR TO MIDAS ON 10/24/2009 FOR A NOISE BUMPING NOISE COMING FROM MY VEHICLE AND FUEL/OIL LEAKING. THEY SAID IT WAS MY STRUTS, AND THEY HAD TO BE REPLACED. I PAID $500.31 FOR THAT REPAIR ALL RECEIPTS AND …
Read full complaint
I AM WRITING BECAUSE I DID GET THE RECALL ON MY VEHICLE OF THE POWER STEERING , THE MOTOR KIT WAS FIXED ON 8/12/10.I TOOK MY CAR TO MIDAS ON 10/24/2009 FOR A NOISE BUMPING NOISE COMING FROM MY VEHICLE AND FUEL/OIL LEAKING. THEY SAID IT WAS MY STRUTS, AND THEY HAD TO BE REPLACED. I PAID $500.31 FOR THAT REPAIR ALL RECEIPTS AND INVOICES ON HAND. ON 4/25/2011 I TOOK MY CAR TO TIRE DISCOUNTERS ONLY TO FIND THAT I NEEDED 2 LOWER CONTROL ARM BUSHINGS(7) LABOR FOR SUSPENSION SERVICE. MY TOTAL COST WAS $339.12. I JUST PULLED UP RECALLS ON MY VEHICLE AND I NOTICED THAT PEOPLE WHERE SAYING THERE STRUTS HAD TO BE REPLACED TO AND THE HAD PROBLEMS WITH THEIR POWER STEERING SUSPENSION. FROM WHAT I HAVE SEEN A FAULTY POWER STEERING IS A COMPONENT OF A LARGER THE LARGER SUSPENSION AND IF LEFT UNFIXED IT COULD LEAD TO OTHER MAJOR PROBLEMS. IF THIS IS TRUE WHY ARE WE NOT GETTING REIMBURSED FOR THESE VERY EXPENSIVE REPAIRS? I SAW WHERE THEY MAY HAVE RECALLED THE WHOLE SUSPENSION, SO DOES THAT MEAN THAT I CAN GET THESE REPAIRS REIMBURSED? *TR
NHTSA ODI #10551806
43,000 miles · Oct 31, 2013
Suspension
GOING OUT OF DRIVEWAY THE FRONT STRUTS SOUND LIKE THEY BOTTOM OUT. TOOK TO A CERTIFIED MACH. AND STRUTS WERE LEAKS OIL AND GAS. REPLACED THEM COST 559.00 . I AM HAVING MORE PROBLEMS WITH THE BACK SHOCKS I THINK WHEN YOU GO OVER A ROUGH PLACE IN THE ROAD IT SOUNDS LIKE THE BOTTOM IS FALLING OUT. CAN NOT AFFORD TO GO BACK TO MACH.…
Read full complaint
GOING OUT OF DRIVEWAY THE FRONT STRUTS SOUND LIKE THEY BOTTOM OUT. TOOK TO A CERTIFIED MACH. AND STRUTS WERE LEAKS OIL AND GAS. REPLACED THEM COST 559.00 . I AM HAVING MORE PROBLEMS WITH THE BACK SHOCKS I THINK WHEN YOU GO OVER A ROUGH PLACE IN THE ROAD IT SOUNDS LIKE THE BOTTOM IS FALLING OUT. CAN NOT AFFORD TO GO BACK TO MACH. NOW . NO WARRANT LEFT BUT CAN NOT GET A HOLD OF ANY ONE TO TALK TO ABOUT THIS PROBLEM THE PLACE WHERE I BOUGHT MY CAR WILL NOT HONOR THERE PREVIOUS CUSTOMERS BECAUSE THEY WENT UNDER A NEW OWNER. I NEED TO KNOW WHOM I CAN CONTACT. I ONLY HAVE A LITTLE OVER 43,450 ON MY CAR. *TR
NHTSA ODI #10550337
65,979 miles · Jul 11, 2013
Suspension
I HAVE NOTICED SOME SMALL CLICKING NOISES FROM THE REAREND OF MY CAR, AND NOW THAT I'M LIVING IN CANADA, I'M REQUIRED TO HAVE MY VEHICLE SAFETY TESTED, SO I TOOK MY VEHICLE IN FOR THIS SAFETY INSPECTION AND IT FAILED DUE TO A CRACKED REAR COIL SPRING. I WAS QUITE SURPRISED BY THIS AND AFTER TALKING WITH THE SHOP OWNER IT IS APP…
Read full complaint
I HAVE NOTICED SOME SMALL CLICKING NOISES FROM THE REAREND OF MY CAR, AND NOW THAT I'M LIVING IN CANADA, I'M REQUIRED TO HAVE MY VEHICLE SAFETY TESTED, SO I TOOK MY VEHICLE IN FOR THIS SAFETY INSPECTION AND IT FAILED DUE TO A CRACKED REAR COIL SPRING. I WAS QUITE SURPRISED BY THIS AND AFTER TALKING WITH THE SHOP OWNER IT IS APPARENT THAT THIS IS A VERY COMMON PROBLEM WITH CHEVROLET COBALTS. THIS MAKES THE CAR UNSAFE TO DRIVE ON THE ROADS IN CANADA LET ALONE ANYWHERE ELSE, AND AFTER HEARING THIS REPORT AND READING FORUMS ON THE INTERNET ABOUT THIS ISSUE, I WANTED TO BRING THIS TO YOUR ATTENTION AS THIS IS A PROBLEM THAT CHEVROLET NEEDS TO FIX. PLEASE LOOK INTO THIS MATTER AND MAKE CHEVROLET MAKE THIS A RECALL SINCE IS NOT THAT BIG OF A JOB, BUT IS A DEFINITE SAFETY ISSUE. *TR
NHTSA ODI #10524347
32,000 miles · Jun 28, 2013
SteeringSuspension
I TOOK MY VEHICLE TO GET IT CHECKED DUE TO A POPPING NOISE WHILE TURNING, I WAS TOLD THE CONTROL ARM BRUSHING (BUSHING) WAS BROKEN. THE PART WAS REPLACED. THEN 4 MONTHS LATER THE POPPING NOISE RETURNED. WHEN TAKEN TO THE DEALERSHIP, IT WAS AGAIN THE CONTROL ARM BRUSHING (BUSHING). AGAIN, IT WAS REPLACED. IN ABOUT 8 WEEKS, THE PO…
Read full complaint
I TOOK MY VEHICLE TO GET IT CHECKED DUE TO A POPPING NOISE WHILE TURNING, I WAS TOLD THE CONTROL ARM BRUSHING (BUSHING) WAS BROKEN. THE PART WAS REPLACED. THEN 4 MONTHS LATER THE POPPING NOISE RETURNED. WHEN TAKEN TO THE DEALERSHIP, IT WAS AGAIN THE CONTROL ARM BRUSHING (BUSHING). AGAIN, IT WAS REPLACED. IN ABOUT 8 WEEKS, THE POPPING NOISE RETURNED AGAIN. I KNEW WHAT IT WAS BY THEN AND I LEFT IT GO FOR AWHILE. IT WAS REPLACED IN DECEMBER OF 2012. AGAIN IT IS BROKEN AS I FILE THIS REPORT AND HAS BEEN FOR A COUPLE WEEKS. *TR
NHTSA ODI #10522326
30,000 miles · May 1, 2013
Electrical SystemSteeringSuspension
HAVE HAD MANY ISSUES WITH THE FRONT STEERING, DEALERSHIP CLAIMS NOTHING FOUND. NOW IT WILL NOT PASS INSPECTION DUE TO THE STEERING KNUCKLES. RADIO WAS REPLACED 3 TIMES!!! DOOR LOCKS DO NOT STAY LOCKED/UNLOCKED. DEALER STATES THEY NEVER FOUND ANY PROBLEMS WITH IT. VEHICLE NOW HAS 110,000 MILES ON IT *TR
NHTSA ODI #10510208
20,000 miles · Sep 10, 2012
Suspension
I PURCHASED THE CAR BRAND NEW IN 2007. I NOTICED AT ABOUT 20,000 MILES THE FRONT SUSPENSION STARTED TO MAKE LOTS OF CLUNKING NOISES AND RATTLING WHENEVER I WENT OVER BUMPS IN THE ROAD. I TOOK THE CAR INTO THE CHEVY DEALER AND THEY SAID NOTHING WAS WRONG WITH THE CAR. THE CAR NOW HAS 42,000 MILES ON IT AND THE NOISE IS STILL THER…
Read full complaint
I PURCHASED THE CAR BRAND NEW IN 2007. I NOTICED AT ABOUT 20,000 MILES THE FRONT SUSPENSION STARTED TO MAKE LOTS OF CLUNKING NOISES AND RATTLING WHENEVER I WENT OVER BUMPS IN THE ROAD. I TOOK THE CAR INTO THE CHEVY DEALER AND THEY SAID NOTHING WAS WRONG WITH THE CAR. THE CAR NOW HAS 42,000 MILES ON IT AND THE NOISE IS STILL THERE. THERE IS ALSO A REALLY AWFUL NOISE WHEN I APPLY THE BRAKES AND RELEASE THEM THE CAR JERKS LIKE THE BRAKES ARE GONNA FALL OFF THE CAR. I RECENTLY TOOK THE CAR TO A MECHANIC AND HE SAID THE BUSHINGS NEED TO BE REPLACED AND POSSIBLY THE STRUTS AND CONTROL ARM. THE MECHANIC SAID THE CAR SHOULD NOT BE HAVING THOSE PROBLEMS WITH THE CARS CURRENT MILEAGE. HE RECOMMENDED I TAKE IT TO THE DEALER SHIP BUT MY WARRANTY HAS SINCE EXPIRED AND THE DEALER SHIP WILL NOT FIX THE CAR. *TR
NHTSA ODI #10474566
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration